Heat & Glo VRTIKL-AU - Manuals

Heat & Glo VRTIKL-AU – Manual in PDF format online.

Manuals:

Manual

Manual Heat & Glo VRTIKL-AU

Summary

Page 2 - Table of Contents

3 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 Table of Contents 1 Listing and Code Approvals A. Design and Installation Considerations . . . . . . . . . . . . . . . 4B. Non-Combustible Materials Specifi cation. . . . . . . . . . . . . . 4C. Combustible Materials Specifi cation . . . . . . . . . . ....

Page 3 - A. Gas Pressure Requirements; Servicing the Appliance.; Table 1; Minimum Inlet Pressure; Gas Information

21 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 A. Gas Pressure Requirements Pressure requirements for VRTIKL-AU Stoves are shown in Table 1 below. Two taps are provided on the right hand side of the gas control for a test gauge connection to measure the inlet and outlet pressures. See Section 10 : ...

Page 4 - A. Ignition System Wiring; • This gas stove is equipped with an electronic ignition; CAUTION; WARNING

22 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 BATTERY PORT (4 AA BATTERIES) VALVE PILOT IGNITION MODULE 6VDC ON/OFF SWITCH THERMOCOUPLE BLOCK (CONNECTED TOBACK OF VALVE) PILOT GAS LINE CONNECTED TOBACK OF VALVE IGNITION MODULE (6V) ON/OFF WALL SWITCH VALVE FLAME SPARKER/ SENSOR ANT. REMOTE CONTROL...

Page 5 - SECURING THE GAS STOVE; ALLEN HEAD SCREWS; D. Leveling and Lagging Down the Appliance; Appliance Setup; A. Remove Glass Door

23 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 B. Remove Shipping Materials Remove shipping materials from inside or underneath the fi rebox. The gas line is shipped inside back panel. To access the gas line remove the top plate from the gas stove. Remove and retain the two Allen head screws that h...

Page 6 - Remove the inner extension collar (Shown in; Figure; and discard the solid back panel.; F. Top to Rear Flue Conversion; Remove the top plate with hole and discard. (

24 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 Figure 7.4 The manufacturer recommends securing the lag bolt from the component bag in the center hole in the bottom plate (clearance hole). This bolt will help to prevent tip-ping forward. CLEARANCE HOLE Figure 7.5 Using pliers, adjust the counter scr...

Page 7 - ON BACK OF APPLIANCE:; place. Install the inner extension collar.; INNER EXTENSION COLLAR

25 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 7. Install the cover plate with gasket to the top of gas stove with screws previously removed ( Figure 7.10 ). Figure 7.10 ON BACK OF APPLIANCE: 6. Remove the four screws from the cover plate on rear of gas stove. Set cover plate aside. Retain screws. ...

Page 9 - A. Before Lighting Appliance

27 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 A. Before Lighting Appliance Read this entire manual prior to using the appliance. Failure to follow the instructions may result in property damage, bodily injury, or even death. 8 8 Operating Instructions • Remove all shipping materials from inside an...

Page 10 - B. Lighting the Appliance; Electronic Ignition; NOT FOR USE; This heater is equipped with an igni-

28 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 B. Lighting the Appliance Electronic Ignition LIGHTING INSTRUCTIONS TO TURN OFF GAS TO HEATER 1. Push the ‘OFF’ button on remote. 2. Remove batteries from receiver. FOR YOUR SAFETY READ BEFORE LIGHTING W A R N I N G : If you do not follow these instruc...

Page 11 - Initial Break-in Procedure; C. After Appliance is Lit; D. Frequently Asked Questions

29 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 ISSUE SOLUTIONS Condensation on the glass This is a result of gas combustion and temperature variations. As the gas stove warms, this condensation will disappear. Blue fl ames This is a result of normal operation and the fl ames will begin to yellow as...

Page 12 - A. Front Door Glass Assembly Removal

30 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 9 9 Maintaining and Servicing Appliance Although the frequency of appliance servicing and maintenance will depend on use and the type of installation, a qualifi ed service technician should perform an appliance checkup at the beginning of each heating ...

Page 14 - Troubleshooting; A. Electronic Ignition System

32 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 10 10 Troubleshooting With proper installation, operation, and maintenance your gas appliance will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist a qualifi ed service person in the diagnosi...

Page 15 - Hearth Pad; Reference Materials; A. Appliance Dimension Diagram Without Stone Surround

33 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 A B G F H E Hearth Pad D C I Figure 11.1 Appliance Dimensions Height includes 9.53 mm hearth pad. A B C D E F G H I Millimeters 479 1045 1035 403 76 181 762 733 867 11 11 Reference Materials A. Appliance Dimension Diagram Without Stone Surround Dimensi...

Page 16 - B. Appliance Dimension with Stone Surround Diagram

34 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 G F A B C D E Hearth Pad B. Appliance Dimension with Stone Surround Diagram Figure 11.2 Appliance Dimensions with Stone Surround Height includes 9.53 mm hearth pad. A B C D E F G Millimeters 753 620 768 83 428 867 1126 Height includes 9.53 mm hearth pa...

Page 17 - C. Flue Components List; COMPONENTS

35 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 C. Flue Components List COMPONENTS Ceiling Support / Wall Thimble, Black 656-230 150 mm Pipe Length, Black 908B 220 mm Pipe Length, Black 907B 310 mm Pipe Length, Black 906B 600 mm Pipe Length, Black 904B 910 mm Pipe Length, Black 903B 1210 mm Pipe Len...

Page 18 - Part number list on following page.; Log Set Assembly

36 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 D. Service Parts 3 4 2 16 15 14 13 12 11 10 9 8 7 6 5 1 19 18 17 20 Service Parts Diagram VRT-GY-N-AU, VRT-BZ-N-AU VRT-GY-P-AU, VRT-BZ-P-AU Beginning Manufacturing Date: July 2007 Ending Manufacturing Date: ______ Part number list on following page. Lo...

Page 19 - Service Parts

37 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 Service Parts List VRTIKL-AU Service Parts IMPORTANT: THIS IS DATED INFORMATION. The most current information is located on your dealers’ VIP site. When ordering, supply serial and model numbers to ensure correct service parts. ITEM DESCRIPTION SERIAL ...

Page 20 - Valve Assembly

38 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 Valve Assembly Parts List Service Parts Valve Assembly VRTIKL-AU Beginning Manufacturing Date: July 2007 Ending Manufacturing Date: ______ IMPORTANT: THIS IS DATED INFORMATION. The most current information is located on your dealers’ VIP site. When ord...

Page 21 - LIMITED 10 YEAR WARRANTY

39 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 E. Warranty Policy HEAT & GLO LIMITED 10 YEAR WARRANTY In order to presumptively establish the dates to which your HEAT & GLO Limited Warranty runs, you must mail the completed warranty card to HEAT & GLO, 20802 Kensington Boulevard, Lakevi...

Page 22 - F. Contact Information; Please contact your Heat & Glo dealer; DEALERSHIP WHERE PURCHASED:; Your Records for Model:; VRTIKL-AU Balanced Flue Gas Appliance; For Service or Replacement Parts Contact:

40 Heat & Glo • VRTIKL-AU • 2123-900 • 7/07 F. Contact Information Heat & Glo, a brand of Hearth & Home Technologies, Inc. 20802 Kensington Boulevard Lakeville, MN 55044, USA Please contact your Heat & Glo dealer with any questions or concerns. For the location of your nearest Heat &...