Heat Controller BGE-103A - Manuals

Service Manual 5 Safety Precautions Do not operate or stop the unitby inserting or pulling out thepower plug. • It will cause electric shock or fire due to heat generation. Do not damage or use anunspecified power cord. • It will cause electric shock or fire. Do not operate with wet handsor in damp ...

Service Manual 7 Installation Installation Remove packing sheet from the back of the sleeve,and packing corner and blue tape from the air condi-tioner. If you use an existing wall sleeve, you should mea-sure its dimensions. Install the new air conditioner according to these instal-lation instruction...

• Pick a location which will allow the conditioned air to blow into the area you want. Good installation withspecial attention to the proper position of the unit willlessen the chance that service will be needed. ITEMS IN INSTALLATION HARDWARE You may not need all parts in the kit. Discard unusedpar...

Service Manual 9 Installation Procedure A 1. If you are using the new sleeve (optionally supplied with your unit),skip to step 3. Otherwise, install theplastic grille from the kit. Cut the plastic grille to 25-1/2" wide and 15-1/4" high. Place the plastic grille tothe inside of the wall slee...

10 Room Air Conditioner Installation Procedure B 1. Redirect the louvers at the back of the wall sleeve to 60° angle as shown in the FIG 8. The use of pliers isrecommended. 2. If the wall sleeve already has a rear grille, skip to step 4. If the wall sleeve does not have a rear grilleor louvered pane...

12 Room Air Conditioner Installation Procedure C 1. Redirect the louvers at the back of the wall sleeve to 60° angle as shown in the FIG 15. The use of pliersis recommended. 2. If the wall sleeve already has a rear grille, skip to step 4. If the wall sleeve does not have a rear grilleor louvered pan...

14 Room Air Conditioner Operating Instructions Operating Instructions Controls The controls will look like one of the following. MODE TIMER POWER FAN SPEED Fan Heat Energy Saver Cool Timer TEMP ' F F1 LOWF2 HIGH REMOTE CONTROL SIGNALRECEIVER POWER MODE - Push this button to shift mode of operation f...

Service Manual 15 Operating Instructions Remote control The remote control and control panel will look like one of the following pictures. Power Te m p Fan Speed Timer Mode POWER • To turn the air conditioner ON, push this button. To turn the air conditioner OFF, push the button again. • This button...

16 Room Air Conditioner Operating Instructions How to insert Batteries 1. Remove the cover from the back of the remote controller. 2. Insert two batteries. • Be sure that the (+) and (-) directions are correct. • Be sure that both batteries are new. 3. Re-attach the cover. • Do not use rechargeable ...

Service Manual 17 Disassembly Instructions Disassembly Instructions Mechanical Parts — Before the following disassembly, POWER SWITCH is set to OFF and disconnected the power cord. 1. FRONT GRILLE 1. Open the inlet grille upward or downward.2. Remove the screw which fastens the front grille.3. Pull ...

18 Room Air Conditioner Disassembly Instructions 4. ORIFICE, HEATER ASSY AND TURBO FAN 1. Remove the front grille. (Refer to section 1) 2. Remove the cabinet. (Refer to section 2) 3. Remove the 2 screws which fasten the evaporator at the left side and the right side. (See Fig. 27) 4. Move the evapor...

Service Manual 19 6. SHROUD 1. Remove the fan. (Refer to section 5)2. Remove the screw which fasten the shroud.3. Remove the shroud. (See Fig. 32)4. Re-install the component by referring to the removal procedure, above. 7. MOTOR 1. Remove the cabinet. (Refer to section 2)2. Remove the clamp cord and...

Service Manual 21 Disassembly Instructions 12. CONDENSER 1. Remove the cabinet. (Refer to section 2)2. Remove the brace and the shroud cover. (Refer to section 4) 3. Remove the 5 screws which fasten the condenser.4. After discharging the refrigerant completely, unbraze the interconnecting tube at th...

24 Room Air Conditioner Schematic Diagram Schematic Diagram Wiring Diagram ■ ELECTRIC HEATING MODEL

Service Manual 25 Troubleshooting Guide Troubleshooting Guide Piping System Following is a brief description of the important components and their functions in the refrigeration system.Refer to Fig. 41 to follow the refrigeration cycle and the flow of the refrigerant in the cooling cycle. MOTOR COMP...

26 Room Air Conditioner Troubleshooting Guide Troubleshooting Guide In general, possible trouble is classified in two causes.The one is called Starting Failure which is caused from an electrical defect, and the other is Ineffective AirConditioning caused by a defect in the refrigeration circuit and ...

Service Manual 27 Troubleshooting Guide Fails to Start Check of circuit breakerand fuse. Gas leakage of feeler bulbof thermostat Check of control switch. Only fan fails to start. Improper wiring. Defect of fan motorcapacitor. Irregular motor resistance( ).Irregular motor insulation( ). Replacement o...

28 Room Air Conditioner Troubleshooting Guide COMPLAINT CAUSE REMEDY Check voltage at outlet. Correct if none. Check voltage to rotary switch. If none, checkpower supply cord. Replace cord if circuit is open. Check switch continuity. Refer to wiring diagramfor terminal identification. Replace switch...

Service Manual 29 Troubleshooting Guide NAME PLATE RATING MINIMUM MAXIMUM 115V 103.5V 126.5V 208/230V 187V 253V COMPLAINT CAUSE REMEDY Check voltage. See the limits on the preceding.page. If not within limits, call an electrician. Check the wire connections, if loose, repair orreplace the terminal. ...

30 Room Air Conditioner COMPLAINT CAUSE REMEDY Check the voltage. See the limits on the preced-ing page. If not within limits, call an electrician. Check overload, if externally mounted.Replace if open. (If the compressor temperatureis high, remove the overload, cool, and retest.) If not running, de...

Service Manual 31 Product Specifications REMARK 　 BGE-103A 　 　 BGE-123A 　 　 REMARK POWER SUPPLY CAPACITY (Btu/h) INPUT (W) RUNNING CURRENT (A) E.E.R. (Btu/W.h) CAPACITY (Btu/h) INPUT (W) RUNNING CURRENT (A) INDOOR (°C) OUTDOOR (°C) INDOOR (°C) OUTDOOR (°C) (inch) (mm) (inch) (mm) (inch) (mm) LOUVERE...