Page 3 - USE ONLY HAYWARD GENUINE REPLACEMENT PARTS; SAVE THESE INSTRUCTIONS
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 3 WARNING – Risk of Electric Shock. All electrical wiring MUST be in conformance with applicable local codes, regulations, and the National Electric Code (NEC). Hazardous voltage can shock, burn, and cause death or serious property damage. To reduce the ris...
Page 4 - Product Specifications; Quick connect intake and discharge pipe connection.; Installation Instructions
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 4 Product Specifications Dimensions General Information Introduction This manual contains information for the proper installation and operation of the Hayward PowerFlo Matrix ® pump. WARNING - Read and follow all instructions in this owner’s manual and on t...
Page 5 - Pump Mounting; Hayward recommends a minimum clearance around the pad of 18” to; Plumbing; All electrical wiring should be performed by a qualified; WARNING; WARNING; Voltage; WARNING; Permanently ground motor
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 5 Pump Mounting Fasten pump to base or pad with screws or bolts to reduce vibration and stress on pipe or hose joints. Hayward recommends a minimum clearance around the pad of 18” to allow adequate access for servicing pump and piping. Plumbing Installing u...
Page 6 - Selecting Pump’s Discharge Position (4 Steps); Disengage and lift off strainer cover.; Priming Pump; Open all valves before starting system.; Figure 1
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 6 Wiring If other lights or appliances are also on the same circuit, be sure to add their amp loads before figuring wire and circuit breaker sizes. (NOTE: If unsure how to do this or if this is confusing, consult a licensed electrician). Use the load circui...
Page 7 - Storage/Winterization; Purging the system with compressed air can cause components to; Allowing the pump to freeze will void the warranty.; CAUTION; motor before draining pump.; Start-Up for Winterized Equipment
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 7 Storage/Winterization WARNING – Explosion Hazard. Purging the system with compressed air can cause components to explode, with risk of severe injury or death to anyone nearby. Use only a low pressure (below 5 PSI), high volume blower when air purging the ...
Page 8 - Shaft Seal Change Instructions; Hayward Dealer or service center if you have any questions.
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 8 Shaft Seal Change Instructions CAUTION -Only qualified personnel should attempt rotary seal replacement. Contact your local authorized Hayward Dealer or service center if you have any questions. WARNING - Read and follow all instructions . Failure to foll...
Page 9 - Troubleshooting; Motor Will NOT Start – Check For:; Mechanical binding and electrical overload.; Motor Hums, But Does NOT Start – Check For:; Centrifugal switch stuck in OPEN position.; Pump Won’t Prime; Check voltage to ensure that the motor is rotating at full RPM’s.
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 9 Troubleshooting Motor Will NOT Start – Check For: 1. Improper or loose wiring connections; open switches or relays; tripped circuit breakers, GFCI’s, or blown fuses. 2. Manually check rotation of motor shaft for free movement and lack of obstruction. (See...
Page 10 - Troubleshooting Continued:; Noisy Pump – Check For:; Air leak in suction piping causing rumbling in pump.; Maintenance; Keep motor clean. Insure air vents are free from obstruction.
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 10 Troubleshooting Continued: Noisy Pump – Check For: 1. Air leak in suction piping causing rumbling in pump. 2. Cavitation due to restricted or undersized suction line or leak at any joint, low water level in pool, and unrestricted discharge return lines. ...
Page 11 - Parts Diagram; Description
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 11 Replacement Parts Parts Diagram Parts Listing Ref. No. Part No. Description Ctn. Qty. No. Req’d 1 SPX5500D Strainer Cover with Lock Ring & 'O' Ring 10 1 2 SPX5500H Strainer Cover 'O' Ring 10 1 3 SPX5500F Strainer Basket 10 1 4 SPX5500G Strainer Retai...
Page 12 - USE ONLY; HAYWARD; WW; Y HAYWARD GE; Pool Pr; ENUINE REPLA; roducts Li; ACEMENT PAR; mited Wa; RTS; rranty
To originONE (1) The limidefectivwithout Proof ofdetermi To obtaAuthoriz Haywardrepair. The Haymanufa The expwarrantrespons Some stmay not *Supe Pleas First Stree City_ Phon E-Ma Seria Mode Pool If younecesInsteseria Plea Mail Attn: Or RE Po ▲ Retain this W nal purchasers o year from the da ited war...
