FMI FVF24PW - Manuals - manualsarea.com

Page 2 - DANGER: Carbon monoxide; Carbon Monoxide Poisoning:; WARNING: Any change to; WARNINGS

2 105194 UNVENTED PROPANE/LP GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED SAFETYINFORMATION DANGER: Carbon monoxide poisoning may lead to death! Carbon Monoxide Poisoning: Early signs of carbon monoxide poisoning resemble the flu,with headaches, dizziness, or nausea. If youhave these signs, t...

Page 3 - OWNER’S MANUAL; LOCAL CODES; Where listed vented decorative logs; OPERATION; Figure 1 - Product Identification; Control Knob; UNPACKING; CAUTION: Do not remove the; Continued

3 105194 OWNER’S MANUAL AUT O OF F ON O F F P IL OT O N H I L O H I L O PRODUCTIDENTIFICATION LOCAL CODES Install and use heater with care. Follow alllocal codes. In the absence of local codes, usethe latest edition of The National Fuel GasCode ANSI Z223.1/NFPA 54*. *Available from: American Nationa...

Page 4 - Unusually Tight Construction; per

4 105194 UNVENTED PROPANE/LP GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED PROVIDING ADEQUATEVENTILATION The following are excerpts from NationalFuel Gas Code ANSI Z223.1/NFPA 54, Sec-tion 5.3, Air for Combustion and Ventilation. All spaces in homes fall into one of the threefollowing ventilat...

Page 5 - DETERMINING FRESH-AIR FLOW FOR HEATER LOCATION; Determining if You Have a Confined or Unconfined Space

5 105194 OWNER’S MANUAL DETERMINING FRESH-AIR FLOW FOR HEATER LOCATION Determining if You Have a Confined or Unconfined Space Use this work sheet to determine if you have a confined or unconfined space. Space: Includes the room in which you will install heater plus any adjoining rooms with doorless ...

Page 6 - Ventilation Air From Outdoors; Do not provide openings for; Figure 3 - Ventilation Air from Outdoors

6 105194 UNVENTED PROPANE/LP GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED AIR FORCOMBUSTION ANDVENTILATION Continued VENTILATION AIR Ventilation Air From InsideBuilding This fresh air would come from an adjoiningunconfined space. When ventilating to anadjoining unconfined space, you must pro-...

Page 7 - LOG SIZING REQUIREMENTS; MINIMUM FIREPLACE; INSTALLATION; CHECK GAS TYPE; A. Clearances from the side of the fireplace; *Minimum 16 inches from Side Wall

7 105194 OWNER’S MANUAL LOG SIZING REQUIREMENTS Log Minimum Firebox Size Height Depth Front Rear * Width Width 18" 17" 14" 24" 20" 24" 17" 14" 28" 21" 30" 17" 14" 34" 24" INSTALLATION ANDCLEARANCES(Vent-Free Operation Only) WARNING: Maintai...

Page 8 - If Not Using Mantel; If using a mantel, proceed to If Using; Noncombustible; Noncombustible material OK.; Installing Damper; If Using Mantel; If you cannot meet these

8 105194 UNVENTED PROPANE/LP GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED INSTALLATION Continued Minimum NoncombustibleMaterial Clearances If Not Using Mantel Note: If using a mantel, proceed to If Using Mantel. If not using a mantel, follow theinformation below. You must have noncombustible ...

Page 9 - Figure 7 - Minimum Mantel Clearances When Using Hood; Figure 6 - Minimum Mantel Clearances Without Using Hood; MANTEL CLEARANCES; flue damper open; FLOOR CLEARANCES; A. If installing appliance on the floor level,; Hearth

9 105194 OWNER’S MANUAL Figure 7 - Minimum Mantel Clearances When Using Hood INSTALLATION Continued Figure 6 - Minimum Mantel Clearances Without Using Hood MANTEL CLEARANCES In addition to meeting noncombustible mate-rial clearances, you must also meet requiredclearances between fireplace opening an...

Page 10 - Installation Items Needed; Fitting; Area of Various Standard; Figure 10 - Attaching Damper Clamp; Damper

10 105194 UNVENTED PROPANE/LP GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED INSTALLATION Continued INSTALLING HEATER BASEASSEMBLY WARNING: If installing in a sunken fireplace, special care isneeded. You must raise the fire-place floor to allow access toheater control panel. This will in-sure a...

Page 11 - WARNING: A qualified service; CAUTION: Avoid damage to; External Regulator

11 105194 OWNER’S MANUAL CONNECTING TO GASSUPPLY WARNING: A qualified service person must connect heater togas supply. Follow all local codes. CAUTION: Never connect heater directly to the propane/LPsupply. This heater requires anexternal regulator (not supplied).Install the external regulator be-tw...

Page 12 - Figure 15 - Equipment Shutoff Valve; WARNING: Never use an open; Correct all leaks at once.; Figure 14 - Gas Connection; * Minimum inlet pressure for purpose of input adjustment.

12 105194 UNVENTED PROPANE/LP GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED ON POSITION OFF POSITION Figure 15 - Equipment Shutoff Valve Open Closed EquipmentShutoffValve Pressure Testing Gas SupplyPiping System Test Pressures In Excess Of 1/2 PSIG(3.5 kPa) 1. Disconnect appliance with its app...

Page 13 - Figure 16 - Checking Gas Joints; INSTALLING LOGS; Make sure log does not; One Piece Log Set; CAUTION: After installation; Items Included for Installation; • Switch; Connecting to Log Set; WARNING: Do not connect; The wire may be shortened; Figure 17 - Connecting the Wire Terminals; Wall Switch

13 105194 OWNER’S MANUAL AUT O OF F ON AUT O OF F ON O FF P IL OT O N H I L O H I L O INSTALLATION Continued Figure 16 - Checking Gas Joints WARNING: Failure to posi- tion the parts in accordance withthese diagrams or failure to useonly parts specifically approvedwith this heater may result in prop-...

Page 14 - FOR YOUR SAFETY; • If fireplace has glass doors,

14 105194 UNVENTED PROPANE/LP GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED O F F PIL O T O N L O I H AUTO OFF ON 1. STOP! Read the safety informationin column 1. 2. Make sure equipment shutoff valveis fully open. 3. Set switch in OFF position. OPERATINGHEATER FOR YOUR SAFETY READ BEFORE LIGHT...

Page 15 - Pilot Burner; CAUTION: Do not try to adjust; Shutting Off Heater; Lighting; Do not leave the se-; GHRC Series Operation:

15 105194 OWNER’S MANUAL Figure 21- Pilot IgnitorElectrode Pilot Burner 9. Slightly push in and turn controlknob counterclockwise to the ON position. 10. Wait one minute and switch selector switch to the ON position to lightburner. Note: AUTO is only functional when using GWMT1 or GWMS2 op-tional ac...

Page 16 - Figure 24 - Correct Pilot Flame Pattern; PILOT FLAME PATTERN; • turn heater off (see To Turn Off Gas to; BURNER PRIMARY AIR HOLES; GHRCTA Series Operation:; • In the AUTO mode, the thermostat

16 105194 UNVENTED PROPANE/LP GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED OPERATINGHEATER Continued Figure 22 - Setting the Selector Switch, Control Knob, and FlameAdjustment Knob for Remote Operation Selector Switch in Remote Position (OptionalRemote Control) ONOFFREMOTE O FF PILO T O N L O...

Page 17 - TROUBLESHOOTING; WARNING: Turn off heater; POSSIBLE CAUSE; All troubleshooting items are listed in

17 105194 OWNER’S MANUAL TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing.Only a qualified service persons h o u l d s e r v i c e a n d r e p a i rheater. CAUTION: Never use a wire, needle, or similar object to cleanODS/pilot. This can damage ODS/pilot unit. POSSIBLE CAUSE 1. ...

Page 18 - OBSERVED PROBLEM; nance, page 20) or replace burner orifice

18 105194 UNVENTED PROPANE/LP GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED OBSERVED PROBLEM Burner does not light after ODS/pilot is lit Delayed ignition burner Burner backfiring during combustion Slight smoke or odor during initial operation Moisture/condensation noticed on windows Heater pr...

Page 19 - IMPORTANT

19 105194 OWNER’S MANUAL TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply.• Do not try to light any appliance.• Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s ...

Page 20 - PARTS UNDER WARRANTY; LOGS; Figure 27 - Pilot Inlet Air Hole

20 105194 UNVENTED PROPANE/LP GAS LOG HEATER FIREPLACE MANUFACTURERS INCORPORATED REPLACEMENTPARTS Note: Use only original replacement parts. This will protect your warranty coverage forparts replaced under warranty. PARTS UNDER WARRANTY Contact authorized dealers of this product.If they can’t suppl...

Page 21 - SPECIFICATIONS; Remote Ready; ACCESSORIES; When Gas Pressure Is Too Low; FIREPLACE HOOD; WIRING DIAGRAM; Note

21 105194 OWNER’S MANUAL SPECIFICATIONS Heat Majic™ 18" Heat Majic™ 24" and 30" Remote Ready Remote Ready Btu 17,500/27,000 19,000/31,500 Type Gas Propane/LP Only Propane/LP Only Ignition Piezo Piezo Pressure Manifold 8.0" W.C. 8.0" W.C. Inlet Gas Pressure (in. of water) Maximum ...

Page 23 - PARTS LIST; KEY

23 105194 OWNER’S MANUAL PARTS LIST This list contains replaceable parts used in your heater. When ordering parts, follow theinstructions listed under Replacement Parts on page 20 of this manual. KEY PART NUMBER FOR NO. FVF18PW FVF24PW FVF30PW DESCRIPTION QTY. 1 105186-01 105186-02 105186-03 Log, 1 ...

Page 24 - NOT A UPC; KEEP THIS WARRANTY; WARRANTY INFORMATION; Model; LIMITED WARRANTY; For information about this warranty write:

105194-01Rev. D03/02 NOT A UPC KEEP THIS WARRANTY WARRANTY INFORMATION Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standard written warranty.We make no ...

FMI FVF24PW - Manuals

Manuals:

Manual FMI FVF24PW

Summary

FMI Manuals