Enviro Enviro Maxx - Manuals

Page 2 - Table of Contents

Table of Contents 2 Introduction........................................................................................3 Rating Label Location................................................................3Pellet Quality.............................................................................3...

Page 3 - Introduction

3 Introduction * This manual is designed for the home owner in conjunction with the technical manual. * R ATING L ABEL L OCATION : The rating label is located on the inside of the hopper. P ELLET Q UALITY : Pellet quality is important, please read the following: Your Enviro pellet stove has been des...

Page 4 - Safety Warnings & Recommendations; FIRE EXTINGUISHER AND SMOKE DETECTION:

4 Safety Warnings & Recommendations Please read this entire Owner’s Manual before installing or operating your Enviro Pellet Stove. Failure to follow these instructions may result in property damage, bodily injury or even death. Any unauthorized modification of the appliance or use of replacemen...

Page 5 - ELECTRICAL: The use of a surge protected power bar is recommended.; KEEP ASH PAN FREE OF RAW FUEL.; strongly; must; SAVE THIS INSTRUCTION MANUAL FOR FUTURE REFERENCE.

5 Safety Warnings & Recommendations ELECTRICAL: The use of a surge protected power bar is recommended. The unit must be grounded. The grounded electrical cord should be connected to a standard 110-120 volts (3.6 Amps), 60 hertz electrical outlet and also must be accessible. If this power cord sh...

Page 6 - Operating Instructions

21 13 / 16 " (554mm) 15 15 / 16 " (404mm) 21 9 / 16 " (548mm) 41 1 / 4 " (1047mm) 41 13 / 16 " (1063mm) 23 13 / 16 " (605mm) 25 5 / 8 " (650mm) 26 3 / 4 " (680mm) 25 1 / 16 " (637mm) Operating Instructions D IMENSIONS & S PECIFICATIONS : Figure 1: Dimensions o...

Page 7 - ALSO FIND THE REASONS WHY

7 Operating Instructions C ONTROL B OARD F UNCTIONS : 1. AUGER TRIM: Used to change feed rates on LOW ONLY for poorer quality fuels. Push the Auger Trim button until the number 1 and 5 lights appear on the Heat Level Indicator. This will increase the feed rate to 4 seconds ON time Auger pulse. This ...

Page 8 - OPERATION

Operating Instructions O PERATING Y OUR P ELLET S TOVE : DO NOT OPERATE THE UNIT WITH THE DOOR OR ASH PAN OPEN. Keep hopper lid closed except during re-fuelling.CAUTION: When operating during adverse weather, such as high winds or freezing rain, if the unit exhibits dramatic changes in combustion st...

Page 9 - to smoke escaping from the stove.; THE SLIDER / DAMPER MUST BE SET AT TIME OF INSTALLATION.

9 too much air – Close slider (push in) slightly. • If the flame is in the middle of these two characteristics with a bright yellow/orange, active flame with no black tips then the air is set for proper operation, refer to Figure 7. The combustion exhaust blower is a variable speed blower controlled...

Page 10 - TOOLS REQUIRED TO CLEAN UNIT:; Routine Cleaning and Maintenance; BURNER POT AND LINER; HEAT EXCHANGER TUBES

Check the Burn Pot Liner DAILY Weekly Bi-annually or 2 Tons of Fuel Burn Pot and Liner - Empty Exhaust Vent Heat Exchanger Tubes Fresh Air Intake Tube Ash Box Blower Mechanisms Door Glass Heat Exchanger Tubes Inside Firebox Behind Firebox Liners Ash Pan and Door Gaskets All Hinges Door Latch Post Se...

Page 12 - lubricate this motor. Check gaskets and replace if needed.

Routine Cleaning and Maintenance EXHAUST VENT (Biannually) This vent should be cleaned every year or after two tons of pellets. We recommend contacting your dealer for professional cleaning. To clean the vent pipe, tap lightly on the pipe to dislodge any loose ash. Open the bottom of the “T” to dump...

Page 13 - Warranty; Limited Lifetime Warranty:; exclusions apply to this warranty.; Here is how our Warranty works; Sign and verify that work and information are correct.

13 Warranty Sherwood Industries Ltd. is the manufacturer of the Enviro line of heating products. At Sherwood Industries, our commitment to the highest level of quality and customer service is the most important thing we do. Each Enviro stove is built on a tradition of using only the finest materials...

Page 14 - Exclusions and Limitations:

Warranty Exclusions and Limitations: 1. This Warranty does not cover tarnish, discoloration or wear on the plating or paint. 2. This Warranty excludes wear and tear or breakage caused by cleaning, moving or service on log set. 3. A qualified installer must install this stove or fireplace. This Limit...

Page 16 - Installation Data Sheet

16 NAME OF OWNER: _________________________________________ ADDRESS: _________________________________________ _________________________________________ _________________________________________ PHONE:___________________________________ NAME OF DEALER: _________________________________________ ADDRE...