Enviro EG 28 B - Manuals

Enviro EG 28 B – Manual in PDF format online.

Manuals:

Manual

Manual Enviro EG 28 B

Summary

Page 2 - SAFETY PRECAUTIONS; CAREFULLY READ THE FOLLOWING INFORMATION:; Installation and repair should be done by a; Always keep the appliance area clear; Do not operate with

SAFETY PRECAUTIONS FOR SAFE INSTALLATION AND OPERATIONOF YOUR "ENVIROGAS" STOVE, PLEASE, CAREFULLY READ THE FOLLOWING INFORMATION: GENERAL • Installation and repair should be done by a qualified service person. The appliance should be inspected before use and at once least annually by a qual...

Page 3 - ENVIROGAS EG 28 B VENT UNITS; ASSEMBLY INSTRUCTIONS

TABLE OF CONTENTS Safety Precautions 2 Code Approvals 3 Deciding where to locate your stove 4 Venting 6 Installation of Log Sets and Embers 8 Operating Instructions 9 Maintenance and Technical 10 Trouble Shooting 11 Gas Line Connection 12 Electrical 13 Parts and Accessories 14 Fuel Type Conversion 1...

Page 4 - DECIDING WHERE TO LOCATE YOUR STOVE; IN CANADA

4 DECIDING WHERE TO LOCATE YOUR STOVE DIMENSIONS: FIG. 1 Front Width: 22"/ 56cm Rear Width: 22"/ 56cm Height: 27-1/2"/ 70cm* Depth 19"/ 48cm (*not including vent coupling) Shipping Weight: 210 lbs/95 kg CLEARANCES: A. Side wall to stove 10"/ 25cm B. Rear wall to stove 4"/ 10c...

Page 5 - VENT TERMINAL CLEARANCES

VENT TERMINAL CLEARANCES Figure 3 A= Clearance above grade, verandah, porch, deck, or [balcony (*12 inches (30cm) minimum] B= Clearance to window or door that may be opened [*12 inches (30cm) minimum] C= Clearance to permanently closed window [minimum 12 inches (30cm) recommended to prevent condensa...

Page 6 - VENTING; SUPPLY OF ADEQUATE COMBUSTION AND VENTILATION AIR.; FLUE GAS SPILL SWITCH; CONDITIONS

VENTING This model must have a vent opening in the rear of the unit. Confirm this and also check that the label on the right side panel door states "Vented Room Heater". WARNING: THIS APPLIANCE HAS BEEN DESIGNED TO OPERATE BY DRAWING COMBUSTION AIR AND DILUTION AIR FROM THE ROOM. THE DRAFT H...

Page 7 - A. USING AN EXISTING CHIMNEY; MANUFACTURERS GENERAL VENTING

A. USING AN EXISTING CHIMNEY • Measure the height of the chimney beforehand and purchase the appropriate kit. Never attempt to over stretch a flexible liner to accommodate the height of the chimney. • Any flue damper must be removed or locked permanently in the open position. • The chimney must be c...

Page 8 - INSTALLATION OF LOG SET and EMBERS; CAUTION: NEVER OPERATE THIS APPLIANCE WITH THE DOOR REMOVED; INSTALLING THE LOGSET

INSTALLATION OF LOG SET and EMBERS INSTALLING THE GLOWING EMBERS A bag of Rock Wool embers is provided for use on the burner tray. CAUTION: Use only the type of ember material supplied with this appliance. Due to the irregular size of the ember material there may be more than required. If over time,...

Page 9 - OPERATING INSTRUCTIONS; LIGHTING INSTRUCTIONS; TO TURN OFF GAS TO

OPERATING INSTRUCTIONS FOR YOUR SAFETY READ BEFORE OPERATING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. A) This appliance is equipped with a pilot, which must be lit by hand by following these ins...

Page 10 - MAINTENANCE AND TECHNICAL; CLEANING OF GLASS; TO REPLACE DOOR AND GLASS ASSEMBLY; FOR CLEANING THE INSIDE OF THE FIREBOX; TROUBLE SHOOTING

MAINTENANCE AND TECHNICAL Annually check to ensure that your Venting system is clear. Periodically check the pilot and burner. Check to see that all the burner ports are clean and clear. Check the pilot head for blockage. Check to ensure the pilot flame is blue with small yellow tips. CLEANING OF GL...

Page 12 - GAS LINE CONNECTION; ORIFICE SIZES, PRESSURE AND BTU’S; NATURAL GAS PROPANE; ON THE INSIDE OF THE RIGHT HAND SIDE PANEL.; NEVER USE AN OPEN FLAME FOR LEAK TESTING

GAS LINE CONNECTION ORIFICE SIZES, PRESSURE AND BTU’S NATURAL GAS PROPANE GAS Orifice size #42 dms #53 dms Manifold pressure. 3.8” wc (0.95 kPa) 11” wc (2.74 kPa) Min. Manifold pressure. 1.1” wc (0.27 kPa) 2.7” wc (0.67 kPa) Supply Pressure. 7.0” wc (1.74 kPa) 12” wc (2.98 kPa) Min. Supply pressure....

Page 13 - DO NOT; INSTALLING REMOTE THERMOSTAT OR WALL SWITCH; CAUTION

The ENVIROGAS EG 28.FS.BV. will operate with no external power supply. These models have a Millivolt gas control which uses the pilot flame to generate enough electricity to operate the main burner. The appliance when installed, must be electrically connected and grounded in accordance with local co...

Page 14 - PARTS AND ACCESSORIES; Service Parts available from your local Envirogas Dealer; Accessories

14 PARTS AND ACCESSORIES Service Parts available from your local Envirogas Dealer Burner Control Assembly Natural Gas Pilot Assembly Propane Pilot Assembly Door Bolt Relief Door Gasket Regulating Valve Piezo Igniter Burner Switch B-vent Spill switch 220 ° Orifice Blank Convection Blower Light Bulb H...

Page 15 - ADJUSTING THE VENTURI; FUEL CONVERSION

ADJUSTING THE VENTURI • Remove the ash shelf by undoing the screw at each end, pull shelf towards you. • Remove one screw from the cover plate located below the ash shelf. Loosen the other screw (do not remove) swing the cover plate out of the way and tighten screw down to hold it in place. • With a...

Page 16 - WARRANTY; WHEN FILING A WARRANTY CLAIM PLEASE COMPLETE THE FOLLOWING; To the Dealer

16 WARRANTY Because of our high standards Sherwood Industries Ltd. can offer a *Lifetime Warranty on all it’s gas products. Covered under this warranty are Cabinet Sides, Tops, Pedestals, Surround Panels and Chassis. These steel components are covered against manufacture’s defects for 5 years and la...

Page 17 - PARTS LIST

PARTS LIST EC-001 120 ° F CERAMIC TEMP SENSOR EG28-108 FREESTANDING PEDESTAL EC-002 220 ° F CERAMIC SPILL SWITCH EG28-109 FS PEDESTAL DOOR EC-006 SIT NOVA 820 NG VALVE 50% EG28-116 BURNER TRAY TOP EC-007 SIT NOVA 820 LP VALVE 50% EG28-120 FS DV OWNERS MANUAL EC-009 THERMOCOUPLE (POST 10/00) EG28-121...

Page 18 - EG28 FREESTANDING; EXPLODED; Page 2 of 2 JULY 2001

18 FS BV STOVE TOP EG28124 FS DV STOVE TOP EG28-126 FS PEDESTAL DOOR EG28-109 FS PEDESTAL DOOR MAGNET EG28-056 FREESTANDI NG PEDESTAL EG28 108 FIREBOX GOLD BAR EG28-128 UPPER GOLD BARS EG28-129 LOWER GOLD BAR EG28-130 DOOR MAGNET AND BRACKET FS CABINET SIDE PANEL EG28-123 BV TOP BAFFLE EG28-132 DV T...

Page 19 - EG28 DOOR AND GAS TRAY ASSEMBLY; Page 1 of 2 JULY 2001

19 EG28 DOOR AND GAS TRAY ASSEMBLY EXPLODED Page 1 of 2 JULY 2001 GLASS RETAINER GLASS SET WITH TAPE EG28-097 GLASS EXTRUSIONS INNER DOOR WITH GLASS (B) EG28-103 DOOR LATCH BOLT EC-059 OUTER DOOR PAINTED OR GOLD (A) EG28-100 , 102 PAINTED DOOR ASSEMBLY WITH GLASS (A+B) EG28-099 GOLD DOOR ASSEMBLY WI...

Page 20 - INSTALLATION DATA SHEET; Model: EG 28 B vented

INSTALLATION DATA SHEET The following information must be recorded by the installer for warranty purposes and future reference. Model: EG 28 B vented Name of Dealer: ___________________________________________ Address: ___________________________________________ _____________________________________...