Enviro C-10804 - Manuals - manualsarea.com

Page 2 - Table of Contents

2 Table of Contents Introduction.............................................................................................................3 Pellet Quality..................................................................................................3 Automatic Safety Features.....................

Page 3 - Introduction; Pellet quality is important, please read the following:; will void the warranty.; REASONS WHY THE UNIT OVERHEATED.

3 Introduction * This manual is designed for the home owner in conjunction with the technical manual. * P ELLET Q UALITY : Pellet quality is important, please read the following: Your enviro pellet stove has been designed to burn wood pellets only. Do not use any other type of fuel, as this will voi...

Page 4 - adjusting the slider damper located on the left side of the stove.; Caution: Do not connect to any air distribution duct or system.; warranty. Check with your dealer for fuel recommendations.; THE USE OF CORDWOOD IS PROHIBITED BY LAW.

4 I MPORTANT S AFETY D ATA : P lease read this entire Owner’s Manual before installing or operating your ENVIRO Pellet Stove. Failure to follow these instructions may result in property damage, bodily injury or even death. Contact your local building or fire official to obtain a permit and any infor...

Page 5 - KEEP ASH PAN FREE OF RAW FUEL.; SAVE THIS INSTRUCTION MANUAL FOR FUTURE REFERENCE; The rating label is located on the back of the hopper.

ASHES: Disposed ashes should be placed in a metal container with a tight-fitting lid. The closed container of ashes should be on a non-combustible floor on the ground, well away from all combustible materials pending final disposal. The ashes should be retained in the closed container until all cind...

Page 6 - Operating Instructions; THE SLIDER / DAMPER MUST BE SET AT TIME OF INSTALLATION.

6 Operating Instructions D IMENSIONS - F REESTANDING : Figure 1: Empress Dimensions. 24 7 / 16 " (621mm) 27 3 / 8 " (695mm) 24 3 / 16 " (614mm) 15 3 / 8 " (390mm) 25 3 / 4 " (653mm) 15 3 / 4 " (400mm) S LIDER / D AMPER S ETTING : THE SLIDER / DAMPER MUST BE SET AT TIME OF INS...

Page 7 - air flow to the fire.

7 SPECIAL NOTES:Pellet quality is a major factor in how the pellet stove will operate. If the pellets have a high moisture content or ash content the fire will be less efficient and has a higher possibility of the fire building up and creating clinkers (hard ash build-up). If this happens, pull the ...

Page 8 - DO NOT OPERATE THE UNIT WITH THE DOOR OR ASH PAN OPEN.; low setting is too hot for the room (see “; DO NOT unplug unit while Combustion fan is operating.

8 Operating Instructions O PERATING Y OUR P ELLET S TOVE : PRE-BURN INSTRUCTIONS: The burn pot liner holes must be clear and the liner installed correctly against the ignitor tube for proper operation. Check the hopper for enough pellets to start the unit. DO NOT OPERATE THE UNIT WITH THE DOOR OR AS...

Page 9 - Routine Cleaning and Maintenance

9 2-3 Days / Weekly Semi-annually or 2 Tons of Fuel Burn Pot and Liner Exhaust Vent Ash Pan Fresh air Intake Tube Inside Firebox Blower Mechanisms Door Glass Heat exchanger tubes Heat exchanger tubes Behind firebox liners Ash pan and Door gaskets All Hinges Door Latch Post Season Clean-up TOOLS REQU...

Page 10 - DO NOT PLACE UNBURNED OR RAW PELLET FUEL IN ASH PAN.; Installation of firebox backing:

ASH PAN AND DOOR GASKETS (weekly) After extended use the gasketing may come loose. To repair this, glue the gasketing on using high- temperature fiberglass gasket glue available from your local ENVIRO dealer. This is important to maintain an airtight assembly. ASH PAN (weekly)The ash pan is located ...

Page 12 - Warranty

12 Warranty Sherwood Industries Ltd. gives a five year limited warranty on all steel manufactured parts. A one-year warranty is provided on all electrical components. The above limited warranties are extended only to the original purchaser.There is no warranty on the following parts: ● Glass window ...

Page 13 - Installation Data Sheet

MANUFACTURED BY: SHERWOOD INDUSTRIES LTD. 6782 OLDFIELD RD. SAANICHTON, BC, CANADA V8M 2A3 www.envirofire.biz July 30, 2004 C-10804 NAME OF OWNER: _________________________________________ ADDRESS: _________________________________________ _________________________________________ __________________...