Enviro 1200-V Insert - Manuals

Enviro 1200-V Insert – Manual in PDF format online.

Manuals:

Manual

Manual Enviro 1200-V Insert

Summary

Page 2 - Table of Contents

Table of Contents 2 Safety Precautions..........................................................................................3Operating Instructions.....................................................................................4 Building Your Fire...............................................

Page 3 - Safety Precautions; FOR SAFE INSTALLATION AND OPERATION OF YOUR “ENVIRO” WOOD

3 Safety Precautions FOR SAFE INSTALLATION AND OPERATION OF YOUR “ENVIRO” WOOD STOVE, PLEASE CAREFULLY READ THE FOLLOWING INFORMATION: ● Please read this entire manual before you install and use your new woodstove. Failure to follow instructions may result in property damage, bodily injury or even d...

Page 4 - Operating Instructions; FIRST START; will be set to automatic.; FIRE EXTINGUISHER AND SMOKE DETECTION:

Operating Instructions FIRST START When first installed, the chimney, firebricks and steel are cold and it usually takes several hours on a fairly high burn for them to become hot and dry enough for the stove to function well. We recommend during the unit’s first burn that a door and window are open...

Page 5 - CHIMNEY FIRE, WHICH COULD DAMAGE THE CHIMNEY OR CAUSE A HOUSE FIRE.; away from heater while it is in use.

CREOSOTE - ITS FORMATION AND REMOVAL: When wood is burned slowly, it may produce tar and other vapors that, combined with moisture, form creosote. These vapors condense in the relatively cooler chimney flue of a slow burning fire and, if ignited, make an extremely hot fire. Therefore, the smoke pipe...

Page 6 - DO NOT OVERLOAD THE STOVE.; Helpful Hints Worth Repeating; Helpful advice on the correct way to start your fire.

6 Operating Instructions d) Regulate the heat output of the stove by adjusting the air controls to allow a larger fire and vice versa. A short period of experimentation with the control settings will allow you to regulate the heat output to keep your home comfortable. Do not use a grate or elevate t...

Page 7 - to always open the door slowly between placing wood into the fire.; What type of wood is best to use as firewood?; spillage when refueling, open the door slowly.; Is it normal for soot to cover the glass at the beginning of a fire?

7 Operating Instructions g) Once the kindling has started to burn, add some smaller pieces of seasoned, dry firewood. Note: Adding large pieces at the early stages will only serve to smother the fire. Continue adding small pieces of seasoned dry firewood, keeping the door slightly open until each pi...

Page 8 - column gauge can be used to reference this amount.; Note

8 Operating Instructions 7. What is draft? Draft is the ability of the chimney to exhaust or draw smoke produced during the normal combustion process. Too much draft may cause excessive temperatures in the appliance and may damage the appliance. Inadequate draft may cause backpuffing or “plugging” o...

Page 10 - Specifications

S PECIFICATIONS : Table 1: 1200-V & 1700-V General Information. Model 1200 Insert 1700 Insert Width x Depth 273⁄4” x 211⁄2” (705 mm x 546 mm) 273⁄4” x 26” (705 mm x 660 mm) Height of body 19 1 / 16 ” (484 mm) or 19 9 / 16 ” (497 mm) Fire box size (depth x width x height) 16.1” x 18.25” x 11.15” ...

Page 11 - Type of protection

11 Specifications C LEARANCES T O C OMBUSTIBLES - 1200-V I NSERT : A Minimum clearance to an unshielded side wall 10” (254 mm) B Minimum clearance to an unshielded 8” (203 mm) mantel 21” (533 mm) C Minimum top facing (protruding 3⁄4” [19 mm]) clearance 171⁄2” (445 mm) D Minimum side facing (protrudi...

Page 13 - or

13 Specifications D IMENSIONS - 1200-V I NSERT : 34 13 / 16 "( 88 5m m ) 19 1 / 16 " (4 84 m m ) or 19 9 / 16 " (4 97 m m ) 22 5 / 16 "( 56 6m m ) 26 15 / 16 " (6 84 m m ) 20 7 / 8 " (5 30 m m ) 47 3 / 8 "( 12 03 m m ) 20 7 / 8 " (5 29 m m ) 21 9 / 16 "( 54 8m m )...

Page 15 - Installation; are pre-installed on the base of the unit.

Installation Please read and understand these instructions before installing pedestal or ash pan and leg option. Failure to follow these instructions carefully could cause personal injury or property damage. All screws are pre-installed on the base of the unit. R EMOVAL F ROM P ALLET : • Remove the ...

Page 16 - professional installer.

Installation M ASONRY F IREPLACE I NSTALLATION : Unless you are experienced, we recommend installation by your dealer or a professional installer. Install only in a masonry fireplace with a good-condition chimney at least 15 ft (4.6 m) high, both of which have been constructed in accordance with the...

Page 18 - USA O

Installation Leveling Legs Figure 14: Removable flue collar in place. Figure 15: Leveling legs. S URROUND P ANEL S EALED I NSTALLATION F OR USA O NLY : Note: Though this is an allowable installation, we do not recommend it because of the possibility of poor draft, and therefore poor stove performanc...

Page 19 - A B; NOTE

19 Installation I NSTALLATION U SING A B LOCK -O FF P LATE F OR USA O NLY : If this unit is to be installed into a masonry fireplace or a zero-clearance fireplace with a direct connection you must install a non-combustible seal-off device such as a block-off plate or damper adapter. By installing a ...

Page 21 - When replacing bricks, use only pumas type fire bricks.; Bri

21 Installation M ODEL 1200-V B RICK P LACEMENT & T UBE L OCATIONS : COMPLETE THE STOVE AND SMOKE PIPE INSTALLATION BEFORE PLACING THESE BRICKS. When replacing bricks, use only pumas type fire bricks. TOTAL BRICKS: 12 - Full size bricks 9” long x 4.5” wide x 1.25” thick (22.9 cm long x 11.4 cm w...

Page 22 - Tube A

22 Installation M ODEL 1700-V B RICK P LACEMENT & T UBE L OCATIONS : COMPLETE THE STOVE AND SMOKE PIPE INSTALLATION BEFORE PLACING THESE BRICKS. When replacing bricks, use only pumas type fire bricks.TOTAL BRICKS: 16 - Full size bricks 9” long x 4.5” wide x 1.25” thick (22.9 cm long x 11.4 cm wi...

Page 23 - DO

23 C-C AST C ERAMIC B AFFLE I NSTALLATION : 1. Slide the right C-Cast Ceramic Baffle in over the secondary air tubes at the top of the firebox. The tab must be on the top and pointing towards the center and the smooth side is to face down. Left Ceramic Baffle Right Ceramic Baffle Figure 23: Installa...

Page 26 - Rating Label

Rating Label 26 **Alcove (Use double wall pipe) / Alcôve (Utilisant le double connecteur de mur) I Total width / Largeur totale 55” (1397 mm) Model/Modèle 1200 J Total height / Hauteur totale 78” (1981 mm) K Top of stove to ceiling / Le sommet de poêle au plafond 49” (1245 mm) L Sidewall to unit / D...

Page 27 - Parts List; Description

Parts List Reference # Description Part # 1 120F (49C) Ceramic Fan Temperature Sensor EC-001 2 Insert Burner Switch EC-026 3 FPI Fan Controller 115V EC-039 4 Domestic Power Cord 115V EC-042 5 Heyco Strain Relief EC-044 6 Wood Door Gasket EF-168 7 Glass with Tape 10-000 8 Enviro Logo Gel Decal 50-322...

Page 28 - Parts Diagram

28 Parts Diagram 10 11 13 12 4 25 5 3 2 1 17 7 18 23 21 29 26 22 6 32 33 16 31 34 28 30 27 8 19 20 9 9 ITE M N O .Pa rt # D ES C RIP TIO N 2. 12 00 -V O p tio ns & Pa rts /Q TY . 1 10 -0 00 G la ss w ith Ta p e 1 2 50 -1 09 9 12 00 & 17 00 Fro nt Se co nd a ry A ir Tu b e A 2 14 15 24

Page 29 - Warranty; Limited Lifetime Warranty:; as certain restrictions and exclusions apply to this warranty.; How the Warranty Works; a) Is covered by the Limited Warranty or

29 Warranty Sherwood Industries Ltd. is the manufacturer of the Enviro line of heating products. At Sherwood Industries, our commitment to the highest level of quality and customer service is the most important thing we do. Each Enviro stove is built on a tradition of using only the finest materials...

Page 30 - and a description of the problem.; Exclusions and Limitations:; such is not covered under this warranty.

Warranty 6. If the problem is not covered by the Limited Warranty, the customer will be responsible for all repair costs, as well as all storage, shipping and the cost of removing and re-installing the stove. If you are not satisfied with the service provided by the Enviro dealer, write to Sherwood ...

Page 32 - Installation Data Sheet; INSTALLER’S SIGNATURE:

32 Installation Data Sheet The following information must be recorded by the installer for warranty purposes and future reference. NAME OF OWNER: _________________________________________ ADDRESS: _________________________________________ _________________________________________ ___________________...