Empire Comfort Systems DV-55IP - Manuals

Page 2 - SECTION; TABLE OF CONTENTS

Page 2 12432-9-0107 SECTION PAGE Important Safety Information ......................................................................................................................3Safety Information for Users of LP Gas ...................................................................................

Page 3 - THIS IS A HEATING APPLIANCE; DO NOT OPERATE THIS APPLIANCE WITHOUT FRONT PANEL INSTALLED.; IMPORTANT SAFETY INFORMATION

12432-9-0107 Page 3 THIS IS A HEATING APPLIANCE DO NOT OPERATE THIS APPLIANCE WITHOUT FRONT PANEL INSTALLED. • Due to high temperatures the appliance should be located out of trafﬁc and away from furniture and draperies. • Children and adults should be alerted to the hazards of high surface temperat...

Page 4 - SOME POINTS TO REMEMBER; SAFETY INFORMATION FOR USERS OF LP-GAS

Page 4 12432-9-0107 Some people cannot smell well. Some people cannot smell the odor of the chemical put into the gas. You must ﬁnd out if you can smell the odorant in propane. Smoking can decrease your ability to smell. Being around an odor for a time can affect your sensitivity or ability to detec...

Page 5 - REQUIREMENTS FOR MASSACHUSETTS

12432-9-0107 Page 5 REQUIREMENTS FOR MASSACHUSETTS For all side wall horizontally vented gas fueled equipment installed in every dwelling, building or structure used in whole or in part for residential purposes, including those owned or operated by the Commonwealth and where the side wall exhaust ve...

Page 6 - INTRODUCTION

Page 6 12432-9-0107 Always consult your local Building Department regarding regulations, codes or ordinances which apply to the installation of a direct vent wall furnace. Instructions to Installer 1. Installer must leave instruction manual with owner after installation. 2. Installer must have owner...

Page 8 - CLEARANCES

Page 8 12432-9-0107 Figure 3 Checking Manifold Pressure Both Propane and Natural gas valves have a built-in pressure regulator in the gas valve. Natural gas models will have a mani- fold pressure of approximately 3.5" w.c. at the valve outlet with the inlet pressure to the valve from a minimum o...

Page 12 - FOR YOUR SAFETY READ BEFORE OPERATING; causing property damage, personal injury or loss of life.; OPERATING INSTRUCTIONS; LIGHTING INSTRUCTIONS

Page 12 12432-9-0107 FOR YOUR SAFETY READ BEFORE OPERATING WARNING: If you do not follow these instructions exactly, a ﬁre or explosion may result causing property damage, personal injury or loss of life. A. This appliance is equipped with an ignition device which automatically lights the pilot. Do ...

Page 13 - PILOT FLAME CHARACTERISTICS

12432-9-0107 Page 13 Figure 11 Electrode and pilot burner must be kept clean. Clean through pilot access hole with a small brush (toothbrush) and water. The pilot ﬂame (Figure 11) going to the spark must be large enough to completely cover the sparking area. With the proper ﬂame, only 2 or 3 sparks ...

Page 15 - SERVICE & MAINTENANCE SUGGESTIONS

12432-9-0107 Page 15 GENERAL: All furnaces have been ﬁre-tested to check for proper operation. This includes, main burner ﬂame, pilot ﬂame, fan operation, fan control, limit control and automatic valve operation. If the furnace fails to function on initial installation, it is advisable to re-check t...

Page 17 - TROUBLESHOOTING

12432-9-0107 Page 17 Important 1. The following service procedures are provided as a general guide. 2. Meter readings between gas control and ignition module must be taken within the trial for ignition period. Once the igni- tion module locks out, the system must be reset by setting the thermostat d...

Page 18 - S8600H TROUBLESHOOTING GUIDE

Page 18 12432-9-0107 START Check line voltage power, low voltage transformer, limit control, thermostat and wiring. Yes Note: Before troubleshooting, familiarize yourself with the startup and checkout procedure. Turn gas supply off Turn thermostat to call for heat. Power to module. (24 VAC nominal) ...

Page 19 - HOW TO ORDER REPAIR PARTS

12432-9-0107 Page 19 PLEASE NOTE: When ordering parts, it is very important that part number and description of part coincide. Index Part No. Number Description Index Part No. Number Description 33 712098 Gasket for Observation Hole Cover 34 DV-781 Lighting Hole Cover w/Mica 35 DV-064 Cover Plate fo...