Empire Comfort Systems CIBV-30-2 - Manuals

Page 2 - THIS IS A HEATING APPLIANCE; DO NOT OPERATE THIS APPLIANCE WITHOUT FRONT PANEL INSTALLED.

Page 2 R-3450 IntroductionAlways consult your local Building Department regarding regulations,codes or ordinances which apply to the installation of a vented fireplaceheater.Instructions to Installer1. Installer must leave instruction manual with owner after installation.2. Installer must have owner...

Page 3 - occur if there is rust inside the storage tank or in iron gas pipes.; SAFETY INFORMATION FOR USERS OF LP-GAS; Close all gas tank or cylinder supply valves.; SOME POINTS TO REMEMBER; That's your signal to go into immediate action!

R-3450 Page 3 Some people cannot smell well. Some people cannot smell theodor of the chemical stench put into the gas. You must findout if you can smell the odorant in propane. Smoking candecrease your ability to smell. Being around an odor for a timecan affect your sensitivity or ability to detect ...

Page 4 - Figure 1

Page 4 R-3450 Figure 2 Figure 3 Qualified Installing AgencyInstallation and replacement of gas piping, gas utilization equipment oraccessories and repair and servicing of equipment shall be performed onlyby a qualified agency. The term "qualified agency" means any individual,firm, corporatio...

Page 6 - Figure 6; Figure 5

Page 6 R-3450 Figure 6 8. Position the completed portion of the casing in the approximate location for installation as the completed assembly will be heavy. 9. Refer to Figure 7, removing protective packing foam from casing front and window. Remove the (1) 3/4" bolt and (1) 1/4" washerfrom t...

Page 12 - PLEASE NOTE

Page 12 R-3450 Electric (120 volt) Operated Remote Control, FREC-1Connect the green and red, stripped and bare, wires on the ON/OFF/REMOTE switch wire harness to the wires on remote receiver that is acomponent in the FREC-1. Turn the ON/OFF/REMOTE switch on thewiring chase to the REMOTE position. Fo...

Page 13 - Installation of Logs (Figure 19 and Figure 20 )

R-3450 Page 13 General Glass InformationOnly glass approved for use in Empire Comfort Systems, Inc. fireplacesmay be used for replacement. The glass replacement should be done bya licensed or qualified service person. WARNING:1. The use of substitute glass will void all product warranties.2. Care mu...

Page 14 - • DO NOT put anything around the heater that will obstruct the flow

Page 14 R-3450 12. Replace and attach the (2) 1" x 13-3/4" divider brackets onto the glass frame assembly with the (6) screws and (6) nuts from Step 7. 13. Grasp bottom of glass frame, push upward and insert glass frame into glass frame support top, push inward and insert glass frameinto gla...

Page 15 - FOR YOUR SAFETY READ BEFORE LIGHTING; causing property damage, personal injury or loss of life.; TO TURN OFF GAS TO APPLIANCE

R-3450 Page 15 FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lighted by hand. When lighting the pilot, follow these in...

Page 16 - How To Order Repair Parts; Heater Model Number; STANDING PILOT-TROUBLE SHOOTING; Spark ignitor will not light pilot after repeated depressing of; The pilot and main burner extinguish while in operation.

Page 16 R-3450 Empire Comfort Systems, Inc. Nine Eighteen Freeburg Ave. Belleville, Illinois 62222-0529 How To Order Repair Parts ... Parts can be ordered only through your service person or dealer. For best results, the service person or dealer should order parts throughthe distributor. Parts can b...

Page 18 - Parts List for Stove Casting

Page 18 R-3450 Index Part No. Number Description Index Part No. Number Description 1 R-3436 REMOTE/OFF/ON SWITCH 2 CI-326 SWITCH BOX 3 CI-328 WIRE CHANNEL 4 CI-336 REAR COVER WELDED ASSEMBLY 5 11228 DIVERTER OUTLET ASSEMBLY 6 CI-370 DIVERTER BODY ASSEMBLY 7 CI-043 DIVERTER BACK ASSEMBLY 8 CI-369 INN...

Page 20 - Installing Optional CIB-2 Blower; Position the blower assembly at the rear of the appliance. The

Page 20 R-3450 OPTIONAL BLOWER CIB-2 Vented Fireplace Heater CIBV-30 Installing Optional CIB-2 Blower 1. Loosen, but do not remove, (4) hex-head screws located on the exterior, bottom of the appliance. 2. Position the blower assembly at the rear of the appliance. The blower assembly has (4) keyholes...

Page 22 - Service Notes

Page 22 R-3450 Service Notes Empire Comfort Systems, Inc. Nine Eighteen Freeburg Ave. Belleville, Illinois 62222-0529 PH: 1-800-851-3153 FAX: 1-800-443-8648 E-MAIL: [email protected] WEB SITE: www.empirecomfort.com