Empire Comfort Systems CHBR-16-3 - Manuals

Page 2 - TABLE OF CONTENTS

Page 2 16934-3-0806 Section Page Important Safety Information .........................................................................................................................3Safety Information for Users of LP Gas ................................................................................

Page 4 - SAFETY INFORMATION FOR USERS OF LP-GAS

Page 4 16934-3-0806 Some people cannot smell well. Some people cannot smell the odor of the chemical put into the gas. You must ﬁnd out if you can smell the odorant in propane. Smoking can decrease your ability to smell. Being around an odor for a time can affect your sensitivity or ability to detec...

Page 5 - INTRODUCTION

Page 5 16934-3-0806 Qualiﬁed Installing Agency Installation and replacement of gas piping, gas utilization equipment or accessories and repair and servicing of equipment shall be performed only by a qualiﬁed agency. The term "qualiﬁed agency" means any individual, ﬁrm, corporation, or compan...

Page 6 - GENERAL INFORMATION; WATER VAPOR: A BY-PRODUCT OF UNVENTED ROOM HEATERS

Page 6 16934-3-0806 GENERAL INFORMATION WATER VAPOR: A BY-PRODUCT OF UNVENTED ROOM HEATERS Water vapor is a by-product of gas combustion. An unvented room heater produces approximately one (1) ounce (30ml) of water for every 1,000 BTU’s (.3KW’s) of gas input per hour. Unvented room heaters must be u...

Page 7 - PROVISIONS FOR ADEQUATE COMBUSTION & VENTILATION AIR

Page 7 16934-3-0806 PROVISIONS FOR ADEQUATE COMBUSTION & VENTILATION AIR Provisions for Adequate Combustion and Ventilation Air This heater shall not be installed in a conﬁned space or unusually tight construction unless provisions are provided for adequate combustion and ventilation air.The Nat...

Page 9 - GAS SUPPLY

Page 9 16934-3-0806 GAS SUPPLY Check all local codes for requirements, especially for the size and type of gas supply line required. Note: Never use plastic pipe. Check to conﬁrm whether your local codes allow copper tubing or galvanized. Note: Since some municipalities have additional local codes, ...

Page 11 - PLACEMENT OF GLOWING EMBERS AND LAVA ROCK

Page 11 16934-3-0806 PLACEMENT OF GLOWING EMBERS AND LAVA ROCK Placement of the glowing embers (rock wool) is very individual and light coverage of the areas indicated will provide your best effects. We recommend separation of the rock wool by hand and make your coverage as light and ﬂuffy as possib...

Page 13 - FOR YOUR SAFETY READ BEFORE LIGHTING; LIGHTING INSTRUCTIONS

Page 13 16934-3-0806 HI/LO REGULATOR CONTROL KNOB PIEZO IGNITOR FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not follow these instructions exactly, a ﬁre or explosion may result caus- ing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lighted...

Page 14 - PILOT FLAME CHARACTERISTICS

Page 14 16934-3-0806 Figure 7 shows a correct pilot ﬂame pattern. The correct ﬂame will be blue and will extend beyond the thermocouple. The ﬂame will surround the thermocouple just below the tip. A slight yellow ﬂame may occur where the pilot ﬂame and main burner ﬂame meet. Figure 8 shows an incorr...

Page 15 - CLEANING AND SERVICING

Page 15 16934-3-0806 Annual inspection and cleaning by your dealer or qualified service technician is recommended to prevent malfunction and/or sooting. TURN OFF HEATER AND ALLOW TO COOL BEFORE CLEANING. Remove logs, handling carefully by holding gently at each end. Gloves are recommended to prevent...

Page 16 - WIRING

Page 16 16934-3-0806 WIRING Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. Verify proper operation after servicing. Control Panel Installation 1. Disconnect black and green wire from TH/TP and TH terminal on valve. 2. Insert ...

Page 17 - TROUBLESHOOTING

Page 17 16934-3-0806 If the gas quality is bad, your pilot may not stay lit, the burners may produce soot and the heater may backﬁre when lit. If the gas quality or pressure is low, contact your local gas supplier immediately. 1. When ignitor button is pressed, there is no spark at ODS/ pilot. a. Ig...

Page 18 - HOW TO ORDER REPAIR PARTS; PARTS LIST

Page 18 16934-3-0806 Parts can be ordered only through your service person or dealer. For best results, the service person or dealer should order parts through the distributor. Parts can be shipped directly to the service person/dealer.All parts listed in the Parts List have a Part Number. When orde...

Page 19 - PARTS VIEW

Page 20 - SERVICE NOTES

Page 20 16934-3-0806 SERVICE NOTES Empire Comfort Systems, Inc. 918 Freeburg Ave. Belleville, IL 62220 PH: 618-233-7420 or 800-851-3153 FAX: 618-233-7097 or 800-443-8648 [email protected] www.empirecomfort.com