Devilbiss MG7-OFTWIN - Manuals

Page 2 - LIMITED WARRANTY; THIS WARRANTY DOES NOT COVER:

2 — ENG ❏ Retain original cash register sales receipt as proof of purchase for warranty work. ❏ Use reasonable care in the operation and maintenance of the product as described in the Owners Manual(s). ❏ Deliver or ship the product to the nearest DeVilbiss Air Power Authorized Warranty Service Cente...

Page 3 - IMPORTANT SAFETY INSTRUCTIONS

3 — ENG RISK OF BURSTING RISK OF EXPLOSION OR FIRE RISK OF ELECTRICAL SHOCK AIR TANK THE FOLLOWING CONDITIONS COULD LEAD TO A WEAKENING OF THE TANK, AND RESULT IN A VIOLENT TANK EXPLOSION: 1. FAILURE TO PROPERLY DRAIN CONDENSED WATER FROM THE TANK, CAUSING RUST AND THINNING OF THESTEEL TANK. 2. MODI...

Page 5 - DAMAGE; GLOSSARY

5 — ENG DAMAGE : Each air compressor outfit is carefully tested and checked before shipment. With improper handling, damage mayresult in transit and cause problems in compressor operation. Immediately upon arrival, check equipment for both concealed and visible damages to avoid expenses being incurr...

Page 7 - INSTALLATION AND BREAK-IN PROCEDURES

7 — ENG It may be necessary to brace or support one side ofthe outfit when removing the shipping boards be-cause the air compressor will have a tendency totip. 1. Remove all packaging such that only the compressor onthe pallet remains. Remove and discard the (4) screws andwashers that hold the compr...

Page 9 - OPERATING PROCEDURES

9 — ENG INSTALLATION AND BREAK-IN PROCEDURES (cont'd) RISK OF ELECTRICAL SHOCK. IMPROPERELECTRICAL GROUNDING CAN RESULT INELECTRICAL SHOCK. WIRING FOR THIS UNITSHOULD BE DONE BY A LICENSED ELECTRI-CIAN IN ACCORDANCE WITH NATIONAL ANDLOCAL CODES AND ORDINANCES. This unit was not designed to operate o...

Page 10 - SERVICE INSTRUCTIONS; MAINTENANCE; ALL MAINTENANCE AND REPAIR OPERATIONS NOT LISTED MUST BE DONE BY; ROUTINE MAINTENANCE SCHEDULE

10 — ENG Air Filter - Inspection and Replacement Keep the air filter clean at all times. Do not operate thecompressor with the air filter removed. A dirty air filter will not allow the compressor to operate at fullcapacity. Before you use the compressor, check the air filter tobe sure it is clean. I...

Page 11 - STORAGE

11 — ENG 2. Protect the electrical cord and air hose from damage (suchas being stepped on or run over). Wind them looselyaround the compressor handle. 3. Store the air compressor in a clean and dry location. Before you store the air compressor, make sure you do thefollowing: 1. Review the “Maintenan...

Page 12 - TROUBLESHOOTING GUIDE

12 — ENG PROBLEM CAUSE Move the pressure switch lever to the “OFF” posi-tion. If the outfit doesn’t shut off, unplug. If theelectrical contacts are welded together, replace thepressure switch. Contact an authorized service center to check andreplace pressure switch. Tighten fittings where air can be...

Page 16 - GENERAL MANUAL FOR; PERMANENTLY LUBRICATED; SERVICE NOTES

DeVilbiss Air Power Company • 213 Industrial Drive • Jackson, TN 38301-9615 GENERAL MANUAL FOR PERMANENTLY LUBRICATED TWIN CYLINDER AIR COMPRESSORS SERVICE NOTES