Page 2 - TABLE OF CONTENTS; DANGER: Carbon monoxide poisoning may lead; Carbon Monoxide Poisoning:; Early signs of carbon monoxide; WARNINGS; WARNING: Any change to this heater or its controls
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 2 TABLE OF CONTENTS SAFETY INFORMATION ............................................................ 2 PRODUCT IDENTIFICATION .......
Page 3 - Continued; PRODUCT IDENTIFICATION; SAFETY INFORMATION; Piezo Ignitor
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 3 3 SAFETY INFORMATION Continued PRODUCT IDENTIFICATION Figure 2 - Fireplace (VYGF33PRB Shown) 1. This appliance is only for use ...
Page 4 - LOCAL CODES; The hood is located in the packing on; UNPACKING; CAUTION: Do not remove the data plates attached; PRODUCT FEATURES; OPERATION
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 4 LOCAL CODES Install and use fireplace with care. Follow all local codes. In theabsence of local codes, use the latest edition o...
Page 5 - Unusually Tight Construction; per kw) of the aggregate input rating; AIR FOR COMBUSTION AND VENTILATION
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 5 5 PROVIDING ADEQUATE VENTILATION The following are excerpts from National Fuel Gas Code, ANSIZ223.1/NFPA 54, Section 5.3, Air f...
Page 6 - Ventilation Air From Inside Building; Do not provide openings for inlet or outlet air into; WARNING: If the area in which the heater may be
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 6 AIR FOR COMBUSTION ANDVENTILATION Continued VENTILATION AIR Ventilation Air From Inside Building This fresh air would come from...
Page 7 - WARNING: A qualified service person must in-; INSTALLATION; Your fireplace is designed to be used in zero clearance; Figure 5 - Installing Hood to Firebox; CHECK GAS TYPE
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 7 7 INSTALLATION NOTICE: This heater is intended for use as supple-mental heat. Use this heater along with your primaryheating sy...
Page 8 - If you are recessing the firebox in a wall, do not; INSTALLATION CLEARANCES; Figure 8 - Minimum Clearance for Combustible to Wall; *Minimum 16 inches from Side Wall; MINIMUM CLEARANCE TO
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 8 INSTALLATION Continued INSTALLATION Assembling and Attaching Optional Brass TrimInstallation Clearances Figure 7 - Attaching Br...
Page 9 - Figure 10 - Installing Cabinet Mantel; CONVENTIONAL FIREPLACE INSTALLATION; Bushing may be; Figure 9 - Placing Hearth Base Accessory Against Wall; Electrical Outlet; Figure 11 - Location of Nailing Flanges
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 9 9 INSTALLATION Continued INSTALLATION Conventional Fireplace Installation Figure 10 - Installing Cabinet Mantel CONVENTIONAL FI...
Page 10 - WARNING: A qualified electrician must connect; Figure 13 - Rough Opening for Installing in Wall; Nailing Flanges
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 10 INSTALLATION Continued INSTALLATION Built-In Fireplace Installation Actual Framing Height 32 3 / 8 " 33" Front Width 3...
Page 11 - Blower; Figure 17 - Connecting Duplex Outlet; Shield
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 11 11 1. Frame in rough opening. Use dimensions shown in Figure 16for the rough opening. 2. If using blower, install wiring and p...
Page 12 - WARNING: A qualified service person must con-; Mantel Clearances for Built-In Installation; Figure 20 - Minimum Mantel Clearances for Built-In Installation; Installation Items Needed; • equipment shutoff valve *
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 12 WARNING: This appliance requires a 1/2" NPT (National Pipe Thread) inlet connection to the pres-sure regulator. WARNING: A...
Page 13 - Figure 22 - Gas Connection; Install equipment shutoff valve in an accessible; WARNING: Use pipe joint sealant that is resistant; Sediment Trap; • Phillips screwdriver; CONNECTING FIREPLACE TO GAS SUPPLY; CAUTION: Do not pick up log base assembly by
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 13 13 INSTALLATION Installing Gas Piping to Fireplace Location (Cont.) Connecting Fireplace to Gas Supply Figure 22 - Gas Connect...
Page 14 - Figure 23 - Removing Log Base Assembly From Fireplace; WARNING: Test all gas piping and connections; Pressure Testing gas Supply Piping system; Correct all leaks at once.; CHECKING GAS CONNECTIONS
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 14 INSTALLATION Continued Figure 23 - Removing Log Base Assembly From Fireplace NOTICE: Most building codes do not permit con-cea...
Page 15 - INSTALLING LOGS; Figure 25 - Equipment Shutoff Valve; Open; Pressure Testing Fireplace Gas Connections; Make sure control knob of fireplace is in the OFF position.; Figure 27 - Checking Gas Joints for Propane/LP; Figure 26 - Checking Gas Joints for Natural Gas; Gas Control Valve
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 15 15 CAUTION: Do not remove the data plates attached to the heater base assembly. The data plates containimportant warranty and ...
Page 16 - Make sure; WARNING: You must operate this fireplace with
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 16 INSTALLATION Continued It is very important to install the logs exactly as instructed. Do notmodify logs. Only use logs suppli...
Page 17 - Installing Remote Receiver Unit; INSTALLING 9-VOLT BATTERIES; Installing 9-Volt Battery in Receiver
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 17 17 INSTALLATION Optional Wireless Hand-Held Remote Control Accessories Installing 9-Volt Batteries INSTALLATION Continued OPTI...
Page 18 - FOR YOUR SAFETY; WARNING: Burner will come on automatically; Control Knob; CAUTION: Do not try to adjust heating levels by; LIGHTING INSTRUCTIONS; OPERATING FIREPLACE
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 18 O F F PIL O T O N L O I H AUTOOFFON WARNING: You must operate this fireplace with the fireplace screen in place. Make sure fir...
Page 19 - WARNING: Make sure the selector switch is in the; TO TURN OFF GAS TO APPLIANCE; Shutting Off Fireplace; Set selector switch; Shutting Off Burner Only (pilot stays lit); MANUAL LIGHTING PROCEDURE; Pilot Burner; Thermostat Control Operation; Do not leave the selector switch in the RE-; Flame Adjustment Knob
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 19 19 WARNING: Make sure the selector switch is in the OFF position when you are away from home for longperiods of time. Fireplac...
Page 20 - Figure 43 - Correct Pilot Flame Pattern; PILOT FLAME PATTERN; INSPECTING BURNERS; GHRC Series Operation:; The hand-held remote control unit must; Note for GA3700T Series Only:; OPTIONAL BLOWER OPERATION
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 20 Figure 43 - Correct Pilot Flame Pattern Figure 44 - Incorrect Pilot Flame Pattern Check pilot flame pattern and burner flame p...
Page 21 - CLEANING AND MAINTENANCE; BURNER PRIMARY AIR HOLES; WARNING: If yellow tipping occurs, your fireplace; BURNER FLAME PATTERN; If burner flame pattern is incorrect, as shown in Figure 46; Figure 45 - Correct Burner Flame Pattern; Yellow Tipping; Figure 46 - Incorrect Burner Flame Pattern; WARNING: Turn off fireplace and let cool before; Blow air through the ports/slots and holes in the burner.; Figure 47 - Injector Holder On Outlet Burner Tube
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 21 21 INSPECTING BURNERS Burner Primary Air Holes Main Burner Burner Flame Pattern CLEANING AND MAINTENANCE Cleaning Burner Injec...
Page 22 - Figure 48 - Pilot Inlet Air Hole; SPECIFICATIONS; WIRING DIAGRAM; Note
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 22 LOGS • If you remove logs for cleaning, refer to Installing Logs, pages 15 and 16, to properly replace logs. • Replace log(s) ...
Page 23 - TROUBLESHOOTING; WARNING: Turn off and let; POSSIBLE CAUSE
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 23 23 TROUBLESHOOTING TROUBLESHOOTING Note: All troubleshooting items are listed in order of operation. WARNING: Turn off and let...
Page 24 - OBSERVED PROBLEM
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 24 TROUBLESHOOTING TROUBLESHOOTING Continued OBSERVED PROBLEM Burner does not light after ODS/pilot is lit Delayed ignition of on...
Page 25 - IMPORTANT; REMEDY
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 25 25 TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply.• Do not try to light any appliance.• Do not touc...
Page 26 - ILLUSTRATED PARTS BREAKDOWN
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 26 ILLUSTRATED PARTSBREAKDOWN VYGF33PRBVYGF33NRB (Shown) 17 27 4 O F F P IL OT O N H I L O 8 12 26 7 6 4 3 2 1 5 9 28 14 13 25 15...
Page 27 - PARTS LIST; KEY
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 27 27 PARTS LIST This list contains replaceable parts used in your fireplace. Whenordering parts, follow the instructions listed ...
Page 29 - PART NUMBER
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 29 29 PARTS LIST FIREBOXVYGF33PRB & VYGF33NRB This list contains replaceable parts used in your fireplace. Whenordering parts...
Page 34 - ACCESSORIES; EQUIPMENT SHUTOFF VALVE - GA5010
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 34 CORNER HEARTH BASE G3008F Series - Walnut FinishedG3009U Series - UnfinishedG3010F Series - Oak Finished For models VYGF33PRB ...
Page 35 - LAMINATE TRIM FOR HEARTH OR MANTEL; For all models. Included with accessory mantels.; Hearth Base Trim
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 35 35 ACCESSORIES LAMINATE TRIM FOR HEARTH OR MANTEL G3002J Series - Jade Marble Laminate Mantel TrimG3003J Series - Jade Marble ...
Page 36 - REPLACEMENT PARTS; PARTS UNDER WARRANTY; SERVICE HINTS; When Gas Pressure Is Too Low; TECHNICAL SERVICE
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 36 REPLACEMENT PARTSTECHNICAL SERVICESERVICE HINTS REPLACEMENT PARTS Note: Use only original replacement parts. This will protect...
Page 37 - • ACCESSORIES; OWNER'S REGISTRATION FORM
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 37 37 • ACCESSORIES 1. Where will the product be used? ❍ Living/Family Room ❍ Office/Warehouse ❍ Utility Shed/Outbuilding ❍ Garag...
Page 38 - Postage
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 38 2701 Industrial DriveP.O. Box 90004Bowling Green, KY 42102-9004 TM Postage Required
Page 39 - NOTES
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 39 39 NOTES _______________________________________________________________________________________________ _____________________...
Page 40 - NOT A UPC; LIMITED WARRANTY; For information about this warranty write:; KEEP THIS WARRANTY; WARRANTY INFORMATION; Model
110148-01A F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m F o r m o r e i n f o r m a t i o n , v i s i t w w w . d e s a t e c h . c o m 40 2701 Industrial DriveP.O. Box 90004Bowling Green, KY 42102-9004 www.desatech.com TM 110148-01Rev. A04/02 NOT A UPC LIMITED WAR...
Desa CGD3924P
User Manual
Desa WMP10
Manual
Desa R115T
Manual
Desa CCL3018NR
Manual
Desa CSPBPT CSPINT
Manual
Desa 35
Manual
Desa RP30B
Manual
Desa BLP50VA
Manual
Desa CGP10A
Manual
Desa HD-9260
Manual
Desa GP30
Manual
Desa BLP375A
Manual
Desa VRL24NR
Manual
Desa RCP80
Manual
Desa VP1600E
Manual
Desa CSG3924PT
Manual
Desa 10
Manual
Desa REM110BT
Manual