Cornelius ICE FROST - Manuals

Cornelius ICE FROST – Manual in PDF format online.

Manuals:

Manual

Manual Cornelius ICE FROST

Summary

Page 2 - OPERATOR’S MANUAL

ICE FROST POST-MIX AND PRE-MIX INSTALLATION, SERVICE, AND OPERATOR’S MANUAL The products, technical information, and instructions contained in this manual are subject to change without notice. These instructions are not intended to cover all details or varia-tions of the equipment, nor to provide fo...

Page 3 - TABLE OF CONTENTS

TABLE OF CONTENTS Important Warnings and Advice . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Technical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 Plate data . . . . . . . . . . . . . . ...

Page 5 - IMPORTANT WARNINGS AND ADVICE; LATE; TRANSPORTATION INDICATIONS

Ice Frost Operator’s Manual © 2004-2006, IMI Cornelius Inc. - 1 - Publication Number: M620919596OPR IMPORTANT WARNINGS AND ADVICE This instruction manual represents an integral part of the equipment and must be kept readily available for use. Read the warnings contained herein carefully before insta...

Page 6 - INSTALLATION; ONNECTING

Ice Frost Operator’s Manual Publication Number: M620919596OPR - 2 - © 2004-2006, IMI Cornelius Inc. INSTALLATION 1. Remove the equipment from the packing, then slide it off upwards (see FIGURE 1). 2. Checking the machine identification after removing the packing, you must check that the equipment yo...

Page 7 - ONNECTION; Inlet for CO; CO

Ice Frost Operator’s Manual © 2004-2006, IMI Cornelius Inc. - 3 - Publication Number: M620919596OPR C ONNECTION D IAGRAMS Ice Frost Generic (Pre-mix) The diagram shows the sequence for the connection between the ICE FROST GENERIC PRE to an existing pre-mix system. FIGURE 3 Description: 1. Pre-mix pr...

Page 9 - Alarms; CE; gas pressure reading function only.

Ice Frost Operator’s Manual © 2004-2006, IMI Cornelius Inc. - 5 - Publication Number: M620919596OPR Alarms Safety Probe Alarms (only for I CE F ROST G ENERIC Pre-mix) You will remember that the monitoring of the safety probes’ conditions (satisfied/ not satisfied) is only active during the bowl load...

Page 13 - ROGRAMMING

Ice Frost Operator’s Manual © 2004-2006, IMI Cornelius Inc. - 9 - Publication Number: M620919596OPR P ROGRAMMING E LECTRONIC T OUCH P AD To Enter Time Programming on Initial Installation or in the Event of Service 1. Turn the power switch OFF. 2. Press and hold the left “PRESS TO SELECT FUNCTION” bu...

Page 15 - Viewing the Bowl Temperature; ONSISTENCY

Ice Frost Operator’s Manual © 2004-2006, IMI Cornelius Inc. - 11 - Publication Number: M620919596OPR Viewing the Bowl Temperature 1. Turn ON the auger on the side that you want to display the bowl temperature (press the “AGER ON/ OFF” button). 2. Press the “PRESS TO SELECT FUNCTION” button until the...

Page 16 - QUARTERLY CLEANING AND SANITATION; OST

Ice Frost Operator’s Manual Publication Number: M620919596OPR - 12 - © 2004-2006, IMI Cornelius Inc. QUARTERLY CLEANING AND SANITATION P OST M IX S YSTEMS O PERATIONS ATTENTION: The cleaning operations must be performed with the machine disconnected from the power supply. 1. Empty the bowl of any re...

Page 20 - SPECIAL MAINTENANCE; ESTRICTED

Ice Frost Operator’s Manual Publication Number: M620919596OPR - 16 - © 2004-2006, IMI Cornelius Inc. SPECIAL MAINTENANCE ATTENTION: To guarantee peak cooling system performance level, the routine cleaning of the condenser filter is essential. As explained earlier, an audible signal accompanied by th...

Page 21 - ELECTRONIC MONITORING

Ice Frost Operator’s Manual © 2004-2006, IMI Cornelius Inc. - 17 - Publication Number: M620919596OPR ELECTRONIC MONITORING E LECTRONIC B OWL M ONITORING AND S AFETY S YSTEM P RESSURE AND L EVEL C ONTROL C ARD G ENERAL F EATURES The diagram shows the electronic pressures and levels management system:...

Page 22 - OFF C; ONDITION; st Filling Condition

Ice Frost Operator’s Manual Publication Number: M620919596OPR - 18 - © 2004-2006, IMI Cornelius Inc. OFF C ONDITION In this condition, the electronic control is not connected to the power supply. To connect the ECB to the power supply, the main system switch must be put in the ON position. 1st Filli...

Page 23 - Managing the Bowl Levels

Ice Frost Operator’s Manual © 2004-2006, IMI Cornelius Inc. - 19 - Publication Number: M620919596OPR Managing the Bowl Levels When one of the two level probes fails to detect the presence of liquid in the bowl, the Fill solenoid valve is activated to refill the correct level. The probes relating to ...

Page 24 - The

Ice Frost Operator’s Manual Publication Number: M620919596OPR - 20 - © 2004-2006, IMI Cornelius Inc. NOTE 1: the same intervention methods are applied when the safety probe is uncovered after the solenoid valve has been activated. NOTE 2: the 3-second software filter activated when it detects the sa...

Page 25 - WIRING DIAGRAM; RE

Page 29 - TROUBLESHOOTING

Ice Frost Operator’s Manual © 2004-2006, IMI Cornelius Inc. - 25 - Publication Number: M620919596OPR TROUBLESHOOTING NOTE: The following procedures must be performed by a qualified service technician. Problem Possible Cause Solution “Filt” or “Err” message appears on the touchpad LED readout • The f...