Char-Broil 463270613 - Manuals

WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2. Turn all control knobs to the OFF position. 3. Turn ...

6. Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE...

7 ▲ ▲ ▲▲ ▲ ▲ ▲ ▲ ▲ ▲ ▲ ▲ Safety Tips Before opening LP cylinder valve, check the coupling nut for tightness. When grill is not in use, turn off all control knobs and LP cylinder valve. Never move grill while in operation or still hot. Use long-handled barbecue utensils and oven mitts to avoid burns ...

9 Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn gas OFF at control knobs and LP cylinder. 2. Remove cooking grates and flame tamers. 3. Remove carryover tubes and burners. 4. 5. Carefully lift each...

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated...

PARTS LIST NOTE: Some grill parts shown in the assembly steps may differ slightly in appearance from those on your particular grill model. However, the method of assembly remains the same. Ke y Qty De scription A 1 TOP LID B 1 HANDLE F/ TOP LID C 1 LOGO PLATE D 2 RUBBER BUMPER, RECTANGLE, F/ TOPLID ...

PARTS DIAGRAM MM A N E I C G K B F J D H L L M O P Q R S T U V W X Y Z AA BB CC DD EE FF GG HH II JJ KK KK LL LL NN 12

1 2 Bottom shelf Non-lock caster Locking caster Rear Front Left side panel Magnet (with a hole) Right side panel Front Caster pin A A S S E M B LY Place bottom shelf upside down. Insert Caster Pin into the caster mounting plate to lock it in place, shown A . Spin the caster clockwise into the thread...

Fascia, right side shelf Back of main control panel # 8 x 3 / 8 " s e l f - t a p p i n g 1 / 4 " n u t 1 / 4 " n u t s c r e w Igniter switch Main control panel Fla nge i nto b rac ket Bracket Right side shelf 1/4-20x1 ½" screw 1/4-20x1/2" screw 1/4-20x1/2" screw A B C D E I...

Slide into slots Back of firebox Front of firebox Flame tamers Pin 14 13 Install flame tamers by sliding one end of each flame tamer into slots at front of firebox and resting opposite end on pins in back of firebox. Connect each of the wires from main burner electrodes into the back of Electronic I...

DANGER: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder. Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire comin...

Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also) Burner(s) will notmatch light. Sudden drop in gasflow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback...(fire in burner tube(s)). Unable to fill LP c...

Troubleshooting - Electronic Ignition Problem (Ignition) SECTION I No sparks appear at any electrodes when Electronic Ignition Button is pressed; no noise can be heard from spark module. SECTION II SECTION III Sparks are present but not at all electrodes and/or not at full strength Possible Cause • ...

THANK YOU FOR YOUR RECENT PURCHASE FROM REGISTER YOUR PRODUCT TO RECEIVE A SPECIAL OFFER CHARBROIL.COM/REGISTER CHECK OUT THESE GREAT FEATURES ON OUR WEBSITE • Valuable product information • Inspiring grilling accessories • Reliable customer support • Delicious recipes and tips from chefs • Exciting...