BMW 325Ci Coupe 2004- Manuals

7 Notes Reporting safety defects The following only applies to vehicles owned and operated in the US. If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately inform the National High-way Traffic Safety Administration NHTSA in add...

Contents Notes About this Owner's Manual 4 Additional sources of information 4 Symbols used 4 Your individual vehicle 5 Status at time of printing 5 For your own safety 5 Service and warranty 6 Reporting safety defects 7 Overview Cockpit 14 Instrument cluster 16 Indicator and warning lamps 18 Button...

Contents 9 Passenger safety systems: Airbags 51 Transporting children safely 54 Vehicle Memory, Key Memory 58 Driving: Ignition lock 59 Starting the engine 59 Switching off the engine 61 Parking brake 61 Manual transmission 62 Sequential manual gearbox SMG* 63 Automatic transmission with Steptronic*...

Contents Operation, maintenance Special operating instructions: Break-in procedures 112 General driving notes 113 Antilock Brake System (ABS) 115 Wheels and tires: Tire inflation pressure 116 Tire code 118 Tire condition 119 Run Flat tires* 120 New wheels and tires 121 Snow chains* 122 In the engine...

Contents 11 Index Everything from A to Z 160 Online Edition for Part-No. 01 41 0 158 112 - © 03/04 BMW AG

14 Cockpit Online Edition for Part-No. 01 41 0 158 112 - © 03/04 BMW AG

16 Instrument cluster Online Edition for Part-No. 01 41 0 158 112 - © 03/04 BMW AG

18 Indicator and warning lamps Technology that monitors itself Indicator and warning lamps that are identified by ● are tested for proper functioning whenever the ignition key is turned. They each light up once for dif-ferent periods of time. If a fault should occur in one of these systems, the corr...

19 Brake warning lamp for Cana-dian models. Please fasten safety belts ● Comes on together with an acoustic signal until the safety belts are fastened.For additional information on safety belts, refer to page 46 . Airbags ● Have the system checked as soon as possible. For additional information, ref...

20 Dynamic Brake Control (DBC) ● Malfunction in the DBC system. Conventional braking efficiency is available and unrestricted.Have the system checked as soon as possible.For additional information, refer to page 115 . Dynamic Brake Control (DBC) warning lamp for Canadian models. Add washer fluidThe ...

21 Buttons in steering wheel* These buttons let you operate the fol-lowing functions quickly and without being distracted from traffic conditions: > Selected radio functions > The cruise control > Selected telephone functions > The voice recognition system. The controls are active only w...

22 Hazard warning triangle* The hazard warning triangle is stored in a storage case on the left side of the luggage compartment. Always observe all legal regula-tions requiring a warning triangle to be carried in the vehicle. < First-aid kit* The first-aid kit is located under the passenger seat....

23 Refueling Fuel filler door Always switch off the engine before refueling, as it is not possi- ble to add fuel with the engine running, and attempts may also trigger the SERVICE ENGINE SOON lamp. < Press on the rear edge of the fuel filler door to open and close it. If an electrical malfunction...

24 Closing the gas cap Place the cap in position and turn it until a clearly audible click is heard. Close the gas cap carefully after refueling until a click is heard. While closing, be sure not to squeeze the strap which is fastened to the cap. A loose or missing cap will activate the CHECK GAS CA...

28 Opening and closing Keys The key set 1 Master keys with remote control. They govern the functions of the Key Memory. Certain functions in your vehicle may operate differently depending on the key, refer to page 58 . To distinguish between keys, you can mark each key with remote control by applyin...

29 Opening and closing – via the remote control The concept The remote control also provides two additional functions beyond the central locking feature: > To switch on interior lamps, refer to page 30 . With this function you can also search for your vehicle when parked in an underground garage,...

31 Opening and closing – via the door lock One turn of the key in the driver's door lock unlocks the driver's door only. Turning the key a second time unlocks the passenger-side door, the luggage compartment lid and the fuel filler door. You can have a signal set to con-firm that the vehicle's locks...

32 Opening and closing – from the inside You can use this button to control the central locking system whenever the doors are closed. The doors and lug-gage compartment lid are unlocked or locked only. The anti-theft system is not activated. If only the driver's door was unlocked from the outside an...

33 Luggage compartment lid The lock Only the master keys fit in the lock for the luggage compartment lid, refer to page 28 . To secure separately Turn the master key to the right past the resistance point and then pull it out in the horizontal position. This locks the luggage compartment lid and dis...

35 Emergency release This lever releases the luggage com-partment lid from the luggage compart-ment's interior. Luggage compartment Floor panel Lift the floor panel with the ring, then use the tab to suspend it from the weather-stripping on the drip rail. Luggage compartment lid Overview Controls Ma...

37 Indicator lamp displays > The indicator lamp below the interior rearview mirror flashes continuously: the system is armed > The indicator lamp flashes immedi-ately after the vehicle is locked: doors or luggage compartment lid are not completely closed. Even if you do not close the alerted a...

38 Electric power windows To open and close windows With the ignition key in position 1 or higher: > Press the switch to the resistance point: the window retracts, or respec-tively the tilt-out window moves out-ward; it remains in motion for as long as you maintain pressure on the switch > Pre...

39 Glass sunroof, electric* To prevent injuries, exercise care when closing the glass sunroof and keep it in your field of vision until it is shut.When leaving the vehicle, always remove the ignition key from the lock and remember to close the doors to prevent children from operating the glass sunro...

40 Trap protection If the glass sunroof encounters resis-tance when closing from approximately the half-closed position or when closing from the raised position, the closing operation is interrupted and the glass sunroof reopens slightly. Despite trap protection, always make sure that the sunroof ca...

41 Adjustments Safe seating position For driving that is relaxed and less likely to cause fatigue, you should select a sitting position that reflects your per-sonal requirements. In combination with the safety belts and airbags, the correct seating position also plays an important role in enhancing ...

42 Seats When adjusting your seat, always observe the following precautions Never try to adjust your seat while operating the vehicle. The seat could respond with an unexpected movement, and the ensuing loss of vehicle control could lead to an acci-dent. Never ride with the backrest reclined to an e...

43 BMW sports seat* adjustment You can also adjust the tilt angle and the thigh support: 1 To tilt up: Pull the lever up repeatedly, continu-ing until the seat reaches the desired tilt angle 2 To tilt down: Push the lever down repeatedly, con-tinuing until the seat reaches the desired tilt angle 3 T...

44 Power seat adjustment* Seat adjustment 1 Tilt angle 2 Forward/backward adjustment 3 Cushion height 4 Backrest angle The head restraint is adjusted manually, refer to page 45 . With the BMW sports seat you can also adjust the thigh support, refer to page 43 . Please refer to the adjustment instruc...

45 Head restraints Adjustments Height: adjust by pulling up or pressing down. Press button to retract to the lowest position – see arrow 1. < Adjust the angle of the front head restraints by tilting them manually. You can reduce the risk of spinal injury and whiplash by adjusting the head restrai...

46 Safety belts Always wear your safety belt Always fasten your safety belt before starting off. As supplemental restraint devices, the airbags are designed to enhance the effectiveness of the safety belts, and not to replace them. To close Make sure you hear the catch engage in the belt buckle. The...

47 Seat and mirror memory* You can store and recall three different driver's seat and exterior mirror posi-tions. Memory will not retain the adjust-ment made to the lumbar sup- port. < To store 1. Ignition key position 1 or 22. Adjust your seat and exterior mirrors to the desired position 3. Pres...

49 Mirrors To adjust exterior mirrors 1 Switch for 4-way adjustment 2 Switch to select between mirrors To adjust manually The mirrors can also be adjusted by hand: press against the edges of the lens. For storing mirror settings, refer to Seat and mirror memory on page 47 . The mirror on the passeng...

50 Interior rearview mirror with automatic dimming feature* While the vehicle is being driven for-ward, this mirror dims light through an infinitely variable range depending on the light's incidence. Two photocells in the interior rearview mirror serve this purpose. One is positioned in the mir-ror,...

51 Passenger safety systems Airbags 1 Front airbags on the driver and pas- senger sides 2 Head airbags for driver and front pas- senger 3 Side airbags on the driver and pas- senger sides – front and rear * Protective effect The front airbags supplement the three-point safety belts by providing addi-...

53 This is the right way a larger child should sit wearing the seat belt when rear side airbags are provided. Indicator lamp The indicator lamp indicates the operational status of the airbag system when the ignition key is in position 1 or higher. System operational: > The indicator lamp comes on...

54 Transporting children safely Commercially available child-restraint systems are designed to be secured with a lap belt or with the lap belt por-tion of a combination lap/shoulder belt. Improperly or inadequately installed restraint systems can increase the risk of injury to children. Always read ...

56 The belt cannot be extracted further. Always observe the installation instruc-tions provided by the manufacturer of the child-restraint system. To unlock the safety belt Release the safety belt, remove the child seat and retract the safety belt to its end position on the belt retractor. LATCH chi...

58 Vehicle Memory, Key Memory How the system functions No doubt you have reflected at one time or another on how great it would be if you could permanently configure your vehicle's various features and adjustments to mirror your own individ-ual preferences. In engineering your vehicle, BMW has provi...

59 Driving Ignition lock Ignition key positions 0 Steering locked 1 Steering unlocked 2 Ignition switched on 3 Starting the engine Vehicles with automatic transmis-sion: Do not move the selector lever from position P until the engine is running – ignition key position 2.Your vehicle is equipped with...

60 If the engine does not start on the first attempt – if it is very hot or cold, for instance: > Press the accelerator pedal halfway down while engaging the starter. Cold starts at extremely low tempera-tures below +5 7 /–15 6 and at alti- tudes of over approx. 3,300 ft/1,000 m: > On the firs...

61 Switching off the engine You should never remove the igni-tion key when the vehicle is in motion, as the steering lock could engage.When you leave the vehicle, always remove the ignition key and engage the steering lock.Always engage the parking brake when parking on slopes and inclined sur-faces...

62 If exceptional circumstances make it necessary to engage the parking brake while the vehicle is in motion, do not pull it with excessive pressure. Keep your thumb pressed against the release button while care-fully pulling the lever up.Excessive pressure can lead to over-braking and loss of tract...

63 Sequential manual gearbox SMG* The concept The sequential manual gearbox SMG is an automated manual gearbox with which clutching and shifting is assumed by an electro-hydraulic system. The SMG is operated via the selector lever in the center console and two shift paddles on the steering wheel. It...

67 Automatic transmission with Steptronic* In addition to the fully automatic opera-tion, you can also shift gears manually with Steptronic, refer to page 68 . When you move the selector lever from the D position to the left into the M/S range, the performance-oriented shift programs of the automati...

68 Kickdown You can achieve maximum road perfor-mance using kickdown. Depress the accelerator pedal past the increased resistance point at the full-throttle position. M/S manual operation and Sport program When you move the selector lever from the D position to the left into the M/S range, the sport...

69 Available displays P R N D SD M1 M2 M3 M4 M5 The selector lever position or gear cur-rently engaged in the manual mode is displayed. Electronic transmission control module If the indicator lamp comes on, there is a malfunction in the transmission system. Bring the vehicle to a stop. Move the tran...

70 Turn signal indicator/Headlamp flasher 1 High beams 2 Headlamp flasher 3 Turn signal indicators To signal briefly Press the lever up to the detent but not beyond. It then returns to the center position when released. If the flashing of the indicator lamp and the clicking from the relay are both f...

73 The speed stored in memory is deleted. To store and maintain speed or to accelerate Press button + briefly: The system registers and maintains the current vehicle speed. Every time you tap the button, the speed increases by approx. 0.6 mph / 1 km/h. Press and hold button +: The vehicle accelerate...

74 Everything under control Odometer 1 Odometer 2 Trip odometer Odometer You can activate the displays shown in the illustration with the ignition key in position 0 by pressing the left button in the instrument cluster. Trip odometer To reset the trip odometer to zero, press the left button with the...

75 Fuel gauge Once the indicator lamp stays on con-tinuously, there are still approx. 2 gallons/8 liters of fuel in the fuel tank. Fuel tank capacity approx. 16.6 gallons/63 liters. Certain operating conditions, such as those encountered in mountainous areas, may cause the needle to fluctu-ate sligh...

77 Clock If you wish to have a permanent time display, you can make this adjustment in the radio display, refer to the Owner's Manual for Radio. You can adjust the clock and the time display in the car radio as follows. Setting Before the clock can be set, the time must be showing in the instrument ...

78 Computer Mode selection With the ignition key in position 1 or higher, you can use the onboard com-puter button BC in the turn signal lever to retrieve information from the com-puter for display in the instrument clus-ter. Every time you tap the onboard com-puter button BC, the display changes to...

79 After giving an ice warning, the display returns to the previous setting. < The ice warning does not alter to the fact that surface ice can form at temperatures above 37.5 7 /+3 6 , on bridges or shaded road surfaces, for instance. < Average fuel consumption If you press the onboard compute...

84 Because the sides of Run Flat tires are reinforced, a drop in infla- tion pressure usually cannot be detected from the outside, refer to Run Flat tires, page 120 . < 2. To continue driving, follow the instructions under Driving with a damaged tire on page 120 . System malfunction The indicator...

85 Lamps Parking lamps/Low beams Parking lamps The front, rear and side vehicle lighting is switched on. You can use the parking lamps to signal the position of the vehicle when it is parked. For lighting on one side for parking as an additional feature, refer to page 87 . Low beams When the ignitio...

86 Adaptive headlights* The concept Adaptive headlights is a variable head-lamp control system for dynamically illuminating the road. Depending on the steering angle and other factors the light from the headlamps follows the course of the road. Activating Adaptive headlights With the ignition key in...

87 High beams/Standing lamps 1 High beams 2 Headlamp flasher 3 Standing lamps Standing lamps, left or right As an additional feature, you can illumi-nate your vehicle on either side for parking: With the ignition key in position 0, engage the lever in the appropriate turn-signal position. Front fog ...

88 Interior lamps The interior lamps operate automati-cally. To switch the interior lamps on and off manually Press button 1 briefly: If you want the interior lamps to remain off all the time, press and hold the but-ton for approx. 3 seconds. Press the button briefly to revert to nor-mal operation. ...

90 Controlling the climate for pleasant driving Air conditioning Online Edition for Part-No. 01 41 0 158 112 - © 03/04 BMW AG

92 Air supply/Blower You can select blower speeds from 1 to 4. The heating and ventilation become more and more effective as the air sup- ply settings are increased. In position 0, the blower and the heater are switched off. The outside air supply is blocked in position 0. Temperature In order to in...

94 Automatic climate control* Online Edition for Part-No. 01 41 0 158 112 - © 03/04 BMW AG

99 Interior conveniences Premium sound system* Harman Kardon premium sound system The system creates the acoustic impression of a much larger passenger compartment accompanied by improved stereophonic sound at all seating positions. The system responds to poor reception conditions by repeatedly alte...

100 If – for example for valet parking – you turn over only your spare key, refer to page 28 , then access to the locked glove compartment is not possi-ble. < Rechargeable flashlight The flashlight is located on the left side of the glove compartment. It features integral overload protection, so ...

103 Clothes hooks To open, press on the upper edge. For additional information: refer to page 113 . When hanging clothing on the hooks, be sure that it will not obstruct the driver's vision. Do not hang heavy objects on the hooks. If you do, they could injure occupants, for exam-ple during braking o...

104 Loading and transporting Through-loading system 1. Pull the corresponding lever to release 2. The backrest moves forward slightly when released. Reach into the gap and fold it down. When folding the backrest back into its original position always ensure that the detent engages securely. A loose ...

105 Ski bag* The ski bag allows the safe and clean transport of up to 4 pairs of standard skis or up to two snowboards. The length of the ski bag and the addi-tional space provided in the luggage compartment make it possible to carry skis up to 6 ft 10 in / 2.10 m long. Because of the tapered shape ...

106 Cargo loading Avoid overloading the vehicle so that the permitted load on the tires is not exceeded. Overloading can lead to overheating and internal tire damage. The ultimate result can assume the form of a sudden air loss. < Determining the maximum load 1. Locate the following statement on ...

109 Roof-mounted luggage rack* A special roof-rack system is available as an optional extra for your BMW. Please observe the precautions included with the installation instruc-tions. Anchorages Access to the anchorages: To fold up the covers, please use the tool provided with the roof-rack system. L...

112 Special operating instructions Break-in procedures To ensure that your vehicle provides maximum economy throughout a long service life, we request that you comply with the following information. Engine and differential The first 1,250 miles/2,000 km: Drive at varying engine and road speeds, but ...

113 General driving notes Hot exhaust system High temperatures occur with every vehicle equipped with a cat- alytic converter. Heat shields are installed adjacent to some sections of the exhaust system. Never remove these shields; do not apply undercoat-ing to their surfaces. When driving, standing ...

116 Wheels and tires Tire inflation pressure Information for your safety It is not merely the tire's service life, but also driving safety and driving comfort that greatly depend on the condition of the tires and the maintenance of the specified tire inflation pressure. Check tire inflation pressure...

118 Tire code Knowing the tire code on the tire side-wall makes it easier to correctly choose and identify your tires. Tire size E.g. 205/60 R 15 91 W 205 = Nominal width in mm 60 = Cross-sectional ratio in % R = Radial belt construction 15 = Rim diameter in inches 91 = Load index, not on ZR tires W...

119 Those grades represent the tire's ability to stop on wet pavement as measured under controlled conditions on speci-fied government test surfaces of asphalt and concrete. A tire marked C may have poor traction performance. The traction grade assigned to this tire is based on straight- ahead braki...

121 If there is a total loss of tire inflation pressure, 0 psi/0 kPa, or obvious tire damage, you can determine the dis-tance you may continue driving based on the following values: > With a light load: 1 to 2 persons without luggage: approx. 155 miles/250 km > With a medium load: 2 persons, l...

122 tire center, preferably your BMW cen-ter. Observe any country-specific regu-lations, e.g. on making a corresponding entry in the vehicle documents. The factory-approved radial belt tires are matched to your vehicle and pro-vide optimum safety and driving com-fort when used properly. Run Flat tir...

123 In the engine compartment Hood To release Pull the lever located under the left-hand side of the instrument panel. Do not attempt to service your vehicle if you do not have the required technical background. If you are not familiar with the regulations to be observed, have your vehicle ser-viced...

124 Engine compartment essentials Online Edition for Part-No. 01 41 0 158 112 - © 03/04 BMW AG

126 Washer fluids Headlamp* and windshield washer system Capacity approx. 5.6 US quarts/5.3 liters Fill with water and, if required, with a washer antifreeze additive according to manufacturer's recommendations. We recommend that you mix the washer fluid before adding it to the reservoir. < Antif...

127 Adding engine oil Only add engine oil when the oil level has dropped to just above the lower mark on the dipstick. Continuous exposure to used oil has caused cancer in laboratory testing. For this reason, any skin areas that come into contact with oil should be thoroughly washed with soap and wa...

128 Coolant Do not add coolant to the cooling system when the engine is hot. If you attempt to do so, escaping coolant can cause burns. < Coolant consists of water as well as an additive such as antifreeze with corro-sion inhibitor. Not all commercially available additives are suitable for your B...

129 Adding brake fluid For adding brake fluid or for determin-ing and correcting the cause of brake fluid loss, consult your BMW center. Your BMW center is familiar with the specifications for factory-approved brake fluids – DOT 4. Brake fluid loss may result in extended brake pedal travel. Brake fl...

130 Maintenance BMW Maintenance System The BMW Maintenance System helps maintain your vehicle's road safety and operational safety. Comfort-related aspects, such as the timely change of filters for the air inside the vehicle, are taken into consideration. The goal is to optimize maintenance with res...

131 Have your BMW center perform maintenance and repair. Be sure that all maintenance work is recorded in the Service and Warranty Information Booklet for US models, or in the Warranty and Service Guide Booklet for Canadian models. These entries are your verification of regular maintenance on your v...

132 Laws and regulations California laws Proposition 65 warning California laws require us to state the following warning: Engine exhaust and a wide variety of automobile components and parts, including components found in the interior furnishings in a vehicle, con-tain or emit chemicals known to th...

136 Replacement procedures Onboard tool kit The onboard tool kit is located in the luggage compartment lid. Loosen the wingnut to open. Windshield wiper blades 1. Switch off the engine2. Fold the wiper arm completely out from the windshield 3. Position the wiper blade at an angle and pull the releas...

137 Lamps and bulbs The lamps and bulbs make essential contributions to the safety of your vehi-cle. Therefore, proceed carefully when handling bulbs. BMW recommends that you have such work performed by your BMW center if you are not familiar with the procedures. Do not touch the glass portion of a ...

138 High beams H7 bulb, 55 watt Engine compartment, left side: The H7 bulb is pressurized. There-fore, wear safety glasses and pro- tective gloves. Failure to comply with this precaution could lead to injury if the bulb is damaged. < 1. Turn the cover to the left and remove2. Pull off the plug3. ...

140 Bulbs in the luggage compartment lid:1. Using a screwdriver, loosen the clip 2. Swing trim panel down – see arrow 1. Release the bulb holder – see arrow 2 – and remove it 3. Applying light pressure, turn the bulb to the left. Remove and replace the bulb 4. Press the bulb holder into place, conti...

141 License plate lamps 5 watt bulb 1. Place a screwdriver in the slot and press toward the left to release the lens 2. Replace the bulb. Light-emitting diodes Light-emitting diodes (LEDs) installed behind translucent lenses serve as the light sources for many of the controls and displays in your ve...

144 14. Wheels with full wheel covers * : place the wheel cover with the valve opening over the valve. Use both hands to press the cover securely onto the rim 15. Check and correct the tire inflation pressure at the earliest opportunity.Vehicles with Flat Tire Monitor: after mounting the spare tire ...

145 Battery Maintenance The battery is completely maintenance-free. This means that the original bat-tery acid will normally last for the ser-vice life of the battery under moderate climate conditions. Your BMW center will be glad to advise you if you have any questions concerning the battery. Charg...

146 Giving and receiving assistance Receiving assistance The BMW Group's Mobile Service offers you 24-hour assistance in the event of a breakdown, even on week-ends and holidays. The telephone numbers of the Mobile Service control center in your country are listed in the BMW Dealer Directory. If you...

147 Mobile Service* To establish contact with the BMW Group's Mobile Service: Press button 2 for at least 2 seconds. The indicator lamp above the buttons lights up. As soon as a telephone con-nection has been set up with the Mobile Service, the indicator lamp flashes. Depending on the country you ar...

149 Towing and tow-starting the vehicle Always observe all applicable towing laws and regulations. < Using the towing eyelet The screw-in towing eyelet is located in the luggage compartment under the floor panel; be sure that it remains with the vehicle at all times. It can be attached at the fro...

154 Engine data 325Ci 330Ci DisplacementNumber of cylinders cu in/cm 3 152.2/2,4946 181.8/2,9796 Maximum power outputat engine speed hprpm 1846,000 2255,900 Maximum torque at engine speed lb ft/Nmrpm 175/2373,500 214/2903,500 Online Edition for Part-No. 01 41 0 158 112 - © 03/04 BMW AG

155 Dimensions Overview Controls Maintenance Repairs Data Index Online Edition for Part-No. 01 41 0 158 112 - © 03/04 BMW AG

156 Weights 325Ci 330Ci Curb weight with manual transmission/SMGwith automatic transmission lbs/kglbs/kg 3,197/1,4503,285/1,490 3,285/1,4903,362/1,525 Approved gross vehicle weightwith manual transmission/SMGwith automatic transmission lbs/kglbs/kg 4,255/1,9304,343/1,970 4,343/1,9704,420/2,005 Appro...

157 Capacities Notes Fuel tankReserve gal./litersgal./liters approx. 16.6/63approx. 2.1/8 Fuel specification, refer to 24 Windshield/Headlamp washer reservoir quarts/liters approx. 5.6/5.3 Specifications, refer to page 126 Engine with oil filter change quarts/liters approx. 6.9/6.5 BMW High Performa...

Refueling To ensure that you always have conve-nient access to all essential information when you stop for fuel, we recommend that you fill out the adjoining chart by entering the data that apply to your vehicle. Consult the index for individual specifications. Fuel Please enter your preferred fuel ...