AprilAire 5000 - Manuals - manualsarea.com

Page 2 - fIGURE 1 – Dimensions of the Model 5000 Electronic Air Cleaner; SPECIfICATIONS; TAblE 1 – Model 5000 Specifications; Replacement Media; Consumes less than 50 watts with high voltage active; Max. Equipment Weight; Cabinet will support 400 lb. static load; DIMENSIONS; Outlet Side

2 31" with Door 28-1/8" without Door 12" 24-5/8" 23-7/8" 15-1/2" 17-3/4" 18-3/8" 15-1/2" fIGURE 1 – Dimensions of the Model 5000 Electronic Air Cleaner 90-1346 SPECIfICATIONS TAblE 2 – Model 5000 Initial Airflow Resistance (inches w.c.) Airflow (CfM) 1000 1200 140...

Page 3 - COMPONENTS

3 Pleat Spacers (6) #501 Media Outer Housing with Door Retainers Inner Housing Assembly Inner Housing Ionizer frame Control Electrode Power Pack/Door Assembly On/Off Switch latches 90-1152 fIGURE 2 – Model 5000 Electronic Air Cleaner COMPONENTS

Page 4 - lOCATING THE AIR ClEANER; figure 1

4 lOCATING THE AIR ClEANER Airflow Airflow Airflow Airflow 30 max. 45 max. Minimize Angles Where Possible Airflow Plenum Box Airflow Plenum Box Size Plenum Box to fit outer housing without door: 17-3/4” x 28-1/8”. See figure 1 for complete dimensions. fIGURE 8 fIGURE 9 fIGURE 6 fIGURE 7 fIGURE 4 fIG...

Page 5 - INSTAllING THE OUTER HOUSING AND INNER HOUSING ASSEMbly; OR; WARNING

5 1. Turn the system OFF at the thermostat by changing the mode selector to OFF – this may be a switch or a pushbutton, depending on the type of thermostat. 2. Disconnect power service to the furnace or air handler. 3. Remove air cleaner power pack / door assembly and pull inner assembly out of the ...

Page 7 - Unit Off; Blue Light OFF; Unit ON; Blue Light ON

7 EAC NEUTRAL GND HVAC Equipment Control Center Circuit Board IT IS COMMON TO SEE SPADE TERMINALS ON THE HVAC EQUIPMENT CONTROL CENTER CIRCUIT BOARD. USE ONLY FULLY INSULATED FITTINGS (FEMALE QUICK DISCONNECTS SHOWN). 3-PRONG OUTLET WIRED TO HVAC SYSTEM EAC TERMINAL HVAC EQUIPMENT CONTROL CENTER GND...

Page 8 - TROUblESHOOTING GUIDE; PROblEM

8 TROUblESHOOTING GUIDE PROblEM POSSIblE CAUSE(S) SOlUTION(S) Light does not come on at all after 90 seconds ON/OFF switch not in ON position Turn switch ON. Air cleaner not plugged in Plug in air cleaner. Insufficient current to activate Model 51 relay Wrap blower common wire around relay bracket m...

Page 9 - MAINTENANCE RECOMMENDATIONS; before performing any maintenance item listed below:; ClEAN THE CONTROl ElECTRODE

9 MAINTENANCE RECOMMENDATIONS Whenever performing maintenance on the air cleaner, turn off the HVAC system, then turn off and unplug the air cleaner. before performing any maintenance item listed below: 1. At the thermostat, turn the Fan to Auto (this is done with a switch or a button on the thermos...

Page 10 - fIGURE 16 – Maintenance

10 Inner Housing Ionizer Frame Control Electrode Control Electrode Ionizer Frame Control Electrode Ground Contact Media Ground Contacts Ionizer Wires Bus Bar fIGURE 16 – Maintenance 90-1151

Page 11 - APPlICATIONS WITH A HUMIDIfIER; An Aprilaire; CAUTION

11 APPlICATIONS WITH A HUMIDIfIER An Aprilaire ® Automatic Humidifier can be mounted upstream from the air cleaner. CAUTION Do not install an atomizing humidifier upstream from the air cleaner.

AprilAire 5000 - Manuals

Manuals:

Manual AprilAire 5000

Summary

AprilAire Manuals