Bosch SHP878ZD5N/01 Installation Manual

Page 3 - Safety Definitions; NOTICE; WARNING; This indicates that minor or moderate injuries may occur as a; CAUTION

3 Safety Definitions This indicates that damage to the appliance or property may occur as a result of non-compliance with this advisory. NOTICE This indicates that death or serious injuries may occur as a result of non-observance of this warning. WARNING ! Note: This alerts you to important informat...

Page 4 - dishwasher performance.; IMPORTANT; 3′′ (84 cm) off the cabinet floor otherwise the dishwasher may not; Important Safety Instructions:

4 To avoid possible injury or property damage, OBSERVE ALL WARNINGS AND CAUTIONS. WARNING: These instructions are intended for use by qualified installers only. The dishwasher must be installed by a qualified service technician or installer.• In addition to these instructions, the dishwasher shall b...

Page 5 - Avoiding General Hazards; to tip over and result in serious injury.; Proposition 65 Warning:; product may bear the following label as required by California:; Inspect the Dishwasher; Cancer and Reprodutive Harm -

5 Avoiding General Hazards To reduce the risk of electric shock, fire, or injury to persons, the installer must ensure that the dishwasher is completely enclosed at the time of installation. Do not use the dishwasher until it is completely installed. When opening the door on an uninstalled dishwashe...

Page 6 - Tools and Materials Needed; Flat Screwdriver

6 Elbow connection with 3/4” female hose threads on one end and fits your water supply line (copper tubing, compression fitting, or braided hose) on the other. Hot Water Supply Line - Minimum 3/8 ″ O.D. copper tubing or metal braided dishwasher supply line. Only needed if house water supply line is ...

Page 7 - Materials Supplied; Power Cord; For fully integrated models only:

7 Materials Supplied Screw Clamp (for drain hose) Power Cord Mounting Brackets Mounting Bracket Screws Ø 4x13 mm D E B A C Installation Guide for Fully Integrated Door Panel Vapor Barrier (included with some models) For fully integrated models only:

Page 8 - Toe Panel Kits; Slotted Toe Panel; Plastic Toe Panel

8 Toe Panel Kits (Model Dependent; your dishwasher is supplied with one of the toe panel kits shown below) Slotted Toe Panel 2 - Screws Ø 4x16 mm Non-Slotted Toe Panel 2- Screws Ø 4.2x12.7 mm Toe Panel Mounting Brackets (used with non- slotted toe panel shown above) G H I J K L Plastic Toe Panel M S...

Page 9 - Enclosure Requirements; To Avoid Scalding or Electrical Shock Hazard!; Make sure the water supply and electrical supply are shut off

9 Enclosure Requirements To Avoid Scalding or Electrical Shock Hazard! Make sure the water supply and electrical supply are shut off before installation or service. To Avoid Electrical Shock/Fire Hazard! Do not allow the electrical and supply lines to touch. Note: This dishwasher is designed to be e...

Page 13 - • Remove the hose clip at the back of the dishwasher as shown. The; Scan here for video instructions on

13 • Remove the hose clip at the back of the dishwasher as shown. The hose clip may be used later to hold the drain hose inside your cabinet. 7 Avoid cross-threading! It will cause leaks. After attaching hose, temporarily hook up the water supply then turn on water to check for leaks. NOTICE DO NOT ...

Page 14 - Electrical Connection; Avoid Electrical Shock Hazard!; WARN; ING

14 Electrical Connection Avoid Electrical Shock Hazard! Do not work on an energized circuit. Doing so could result in serious injury or death. Only qualified electricians should perform electrical work. Do not attempt any work on the dishwasher electric supply circuit until you are certain the circu...

Page 15 - Note: Installations requiring hard wiring and terminal block

15 Dishwasher Electrical Rating Volts Hertz Amperes Watts 120 60 12 1,440 (max) Electrical Supply The customer has the responsibility of ensuring that the dishwasher electri- cal installation is in compliance with all national and local electrical codes and ordinances. The dishwasher is designed for...

Page 16 - • Plug the end of the supply cord into the back of the dishwasher. Be

16 Strap Alternate cable ro uting 8 • Plug the end of the supply cord into the back of the dishwasher. Be sure it goes through the strap on either the right or left side of the dishwasher. • The outlet for the power supply cord should be located in a cabinet or wall adjacent to the dishwasher cabine...

Page 17 - Installation of Mounting Brackets; Avoid Tip Over Hazard!; them is difficult and will damage the mounting brackets and the

17 Installation of Mounting Brackets Avoid Tip Over Hazard! Do not use the dishwasher until it is completely installed. When opening the door on an uninstalled dishwasher, carefully open the door while supporting the rear of the unit. Failure to follow this warning can result in serious injury. WARN...

Page 19 - Positioning the Dishwasher; Scan here for video instructions on the

19 • If your sink is to the right side of where you are installing the dishwasher, you will need to reposition the hoses and power cord behind the dishwasher before installing. • To do so, unhook the strap that the hoses are running through on the back of the dishwasher base and position them per yo...

Page 22 - in

22 • Adjust the legs as shown. Make sure the top of the door is no less than 6mm from the underside of the counter. • Use a level to check that your dishwasher is level. • Level side to side by turning feet clockwise to raise or counter- clockwise to lower front of the unit as shown. • Level front t...

Page 23 - • Center the; Securing the Dishwasher; • Drive the mounting screws (E) through the holes in the mounting; Top Mount

23 • Center the dishwasher in the opening before securing it to your cabinet or counter top as shown. 16 Securing the Dishwasher 17 18 • Drive the mounting screws (E) through the holes in the mounting brackets as shown for Top ( figure 17) or Side Mount (figure 18). • If the dishwasher came with a p...

Page 24 - Hot Water Supply; Water Inlet Connection; water supply is shut off.

24 Hot Water Supply The hot water heater should be set to deliver approximately 120° F (49° C) water to the dishwasher. Water that is too hot can cause some detergents to lose effectiveness. Lower water temperatures will increase run times. The hot water supply pressure must be between 15 - 145 psi ...

Page 26 - least 33” (84 cm) off the floor otherwise the dishwasher may not drain; Drain Connection

26 • You may use the piece you removed in Step 7 to attach to the inside of the adjacent cabinet and hang the drain hose from as shown (screws are not supplied) in place of using a Nonmetallic Tie as pictured in the next illustrations. Do not exceed 43” in drain hose height. • The dishwasher drain h...

Page 28 - the drain hose to the house plumbing

28 • Use the clamp provided (C) to attach the drain hose to the house plumbing as shown. 22 C

Page 29 - If the dishwasher came with a non-slotted toe panel (I) and toe panel; • Plug metal brackets (K) into openings on both sides of the base as; Attaching the Toe Panel; • Attach using screws (H) as shown. Use only the supplied screws to

29 If the dishwasher came with a non-slotted toe panel (I) and toe panel brackets (K) follow these instructions;otherwise skip to 27 now. • Plug metal brackets (K) into openings on both sides of the base as shown. • Use screw (H) to mount metal brackets to the base as shown. 24 H K Attaching the Toe...

Page 32 - Custom Door Panel; Please see the included instructions and template for

32 Custom Door Panel Please see the included instructions and template for installing a custom door panel. Below are the measurements for making a custom door panel from the template. Measure the screw holes from the center line and the top of the panel. 9 ⁷⁄8 " - 251mm 10 ¼" - 261mm 11 ¹⁄8 ...

Page 33 - Customer Service

Your dishwasher requires no special care other than that described in the Care and Maintenance section of the Use and Care Manual. If you are having a problem with your dishwasher, before calling for service please refer to the Troubleshooting section in the Use and Care Manual. If service is necess...