BENDPAK 5150018 - User Manual

Page 2 - Installation and Operation Manual; Owner Responsibility.

Manual. Cool Boss™ Portable Evaporative Air Cooler with Swing Louvers, Installation and Operation Manual , P/N 5900274, Manual Revision A1, August 2022. Copyright. Copyright © 2022 by BendPak Inc. All rights reserved. No part of this manual may be reproduced, adapted, translated, or transmitted by a...

Page 3 - Table of Contents; DANGER; . You may also contact Cool Boss for

Cool Boss Evaporative Air Cooler 3 P/N 5900274 — August 2022 — Rev. A1 Table of Contents Introduction 3 Operation 22 Shipping Information 4 Maintenance 25 Safety Considerations 4 Troubleshooting 28 Frequently Asked Questions 6 Parts Diagram 29 Specifications 7 Labels 31 Components 9 Maintenance Log ...

Page 4 - Shipping Information; before; Do not sign the bill of lading until; you have inspected the shipment.; after; Safety Considerations; Read this manual carefully before using your new product.; WARNING; Safety Information; not; Never

Cool Boss Evaporative Air Cooler 4 P/N 5900274 — August 2022 — Rev. A1 Shipping Information Your equipment was carefully checked before shipping. Nevertheless, you should thoroughly inspect the shipment before you sign to acknowledge that you received it. When you sign the bill of lading, it tells t...

Page 5 - Symbols; Liability Information

Cool Boss Evaporative Air Cooler 5 P/N 5900274 — August 2022 — Rev. A1 • Only connect the power cord to a grounded, three-prong GFCI protected receptacle. • Lock at least two Casters before turning on the fan. • Make a visual inspection of the product before using it. Check for damaged or missing pa...

Page 6 - Frequently Asked Questions; Question; the desired direction.; Model; : What’s the best way to set up my Cool Boss?; Maintenance; , then clean it as per the procedure found there.

Cool Boss Evaporative Air Cooler 6 P/N 5900274 — August 2022 — Rev. A1 Frequently Asked Questions Question : Is the Cool Boss an air conditioner? Answer : No. it is an evaporative air cooler, sometimes called a swamp cooler. The fan pulls in hot outdoor air, a water drip spray system releases water ...

Page 7 - Specifications

Cool Boss Evaporative Air Cooler 7 P/N 5900274 — August 2022 — Rev. A1 Specifications

Page 9 - Components; The Cool Boss Unit

Cool Boss Evaporative Air Cooler 9 P/N 5900274 — August 2022 — Rev. A1 Components The Cool Boss Unit CB-14 pictured below.

Page 10 - This figure Details the interior of the unit, from the back.

Cool Boss Evaporative Air Cooler 10 P/N 5900274 — August 2022 — Rev. A1 This figure Details the interior of the unit, from the back.

Page 11 - The Cool Boss Control Panel; The figure below details the Cooler Control Panel.; Water Pump; Bar which then distributes it over the Cooling Media.; Fan Speed; – Rotary Switch on-off and three speed settings.

Cool Boss Evaporative Air Cooler 11 P/N 5900274 — August 2022 — Rev. A1 The Cool Boss Control Panel The figure below details the Cooler Control Panel. Control Functions Swing Control – Rocker switch on-off. Initiates the Swing Louver left right movement Water Pump – Rocker switch on-off. Applies pow...

Page 12 - Setup; Tools required for Assembly:; Unboxing the Cool Boss

Cool Boss Evaporative Air Cooler 12 P/N 5900274 — August 2022 — Rev. A1 Setup There are six basic steps in the Cool Boss set-up. 1. Unbox 2. Install the Casters. 3. Install the Media. 4. Determine the Cool Boss location. 5. Fill the reservoir or connect to water. 6. Connect to power. Tools required ...

Page 13 - Installing the Casters; Bottom View

Cool Boss Evaporative Air Cooler 13 P/N 5900274 — August 2022 — Rev. A1 Installing the Casters The Cool Boss is shipped with heavy-duty locking casters to both support and allow easy movement of the Cooler around your facility. The Casters are shipped in a separate box with the Remote Control. Locat...

Page 14 - Installing the Media; must; be installed toward the warm air side. Refer to the figure below.; To install the Media:; Unplug the unit from power

Cool Boss Evaporative Air Cooler 14 P/N 5900274 — August 2022 — Rev. A1 Installing the Media The Cooler pulls warm air through a Media saturated with water. This Media incorporates a Moisture Lock on one side made of a black nonabsorbent resin which reduces evaporation and increases the efficiency. ...

Page 15 - Not to scale, components removed for clarity.; toward the Warm Air Intake side; of the Cool Boss. Slide the first Media as

Cool Boss Evaporative Air Cooler 15 P/N 5900274 — August 2022 — Rev. A1 Remove and retain the three screws securing the Media Holder Splash Guard. Refer to the figure below. Not to scale, components removed for clarity. Insert one Media section into the Cool Boss. Verify the Moisture Lock Black Resi...

Page 18 - Find a location for your Cool Boss; full; To choose a location for the Cool Boss Cooler:; minimum; Fill the Water Reservoir.

Cool Boss Evaporative Air Cooler 18 P/N 5900274 — August 2022 — Rev. A1 Find a location for your Cool Boss : Find a suitable location for the Cool Boss (hot air to the rear, cooling area to the front). The Cool Boss should be indoors, near an appropriate power and water source, and in a low-traffic ...

Page 19 - supplied; Do; clean; CAUTION; Use only cold clean water. No detergents or additives of any kind.

Cool Boss Evaporative Air Cooler 19 P/N 5900274 — August 2022 — Rev. A1 To fill the Reservoir: You may connect to the Water Inlet Connector on the side of the unit using the standard 3/4 inch Hose fitting and a Hose that is rated to 72 psi / 0.5 MPa maximum water pressure at your location. Turn on t...

Page 20 - Connecting to Power; Before; It is recommended that a separate electrical circuit servicing; All; electrical work must be accomplished by a; licensed, certified Electrician

Cool Boss Evaporative Air Cooler 20 P/N 5900274 — August 2022 — Rev. A1 Connecting to Power Before connecting this unit to a power source, verify the required voltage by studying the model nameplate affixed to your machine. Cool Boss models marked CB-12SL and CB-14 SL indicates 110 VAC operation; mo...

Page 21 - troubleshooting or maintenance; Minimum

Cool Boss Evaporative Air Cooler 21 P/N 5900274 — August 2022 — Rev. A1 Information about color code conventions in other regions and countries is available online. Make sure your Electrician installs the Plug in accordance with all applicable national and local electrical codes. Plug the Cool Boss ...

Page 22 - Operation

Cool Boss Evaporative Air Cooler 22 P/N 5900274 — August 2022 — Rev. A1 Operation This section describes how to operate your Cool Boss Evaporative Cooler. ⚠ WARNING The Cool Boss should only be operated by authorized, trained personnel. That training includes reviewing and understanding the Operatio...

Page 24 - To shut down the Cool Boss

Cool Boss Evaporative Air Cooler 24 P/N 5900274 — August 2022 — Rev. A1 The Swing Louvers are controlled by an on-off Rocker Switch on the Control Panel. 1. Manually adjust the horizontal Louvers to direct the cool air up or down. The vertical Louvers are Motor-driven and will swing to the left and ...

Page 25 - Disconnect the unit from its power source; performing any maintenance!; Monthly

Cool Boss Evaporative Air Cooler 25 P/N 5900274 — August 2022 — Rev. A1 Maintenance ⚠ DANGER Disconnect the unit from its power source before performing any maintenance! Verify the unit is locked out from power and cannot be energized while maintenance is being performed. If your organization has Lo...

Page 26 - To clean the Reservoir; To clean the Media

Cool Boss Evaporative Air Cooler 26 P/N 5900274 — August 2022 — Rev. A1 To clean the Reservoir : The Media must be dry before removing. If the Media is wet, run the Fan without running the Cooling Pump until dry. Turn off and then unplug the Cool Boss. ⚠ WARNING Disconnect the unit from its power so...

Page 27 - To store the Cool Boss

Cool Boss Evaporative Air Cooler 27 P/N 5900274 — August 2022 — Rev. A1 To store the Cool Boss : 1. Dry the Media or verify it is dry. 2. Drain the Reservoir and wipe clean and dry. 3. Unplug or disconnect from power and secure the electrical cord. 4. Cover the Cool Boss to prevent dust build-up and...

Page 28 - Troubleshooting

Cool Boss Evaporative Air Cooler 28 P/N 5900274 — August 2022 — Rev. A1 Troubleshooting ⚠ WARNING This Evaporative Cooler uses electrical energy; if your organization has Lockout/Tagout policies, make sure to implement them before performing any Troubleshooting. Issue Probable Cause Action to Take C...

Page 29 - Parts Diagram; Item Qty. Description

Cool Boss Evaporative Air Cooler 29 P/N 5900274 — August 2022 — Rev. A1 Parts Diagram Item Qty. Description 1 32 Screw 2 Grill, Protective Fan Blade 3 Internal Electrical Cord; CB-12, CB-14 (connects internal components). 4 1 Swing Louver Assembly 5 1 Fill Cap 6 1 set Casters Set; CB-12SL/SLH, CB-14...

Page 31 - Labels

Cool Boss Evaporative Air Cooler 31 P/N 5900274 — August 2022 — Rev. A1 Labels

Page 33 - Maintenance Log

Cool Boss Evaporative Air Cooler 33 P/N 5900274 — August 2022 — Rev. A1 Maintenance Log

BENDPAK 5150018 - User Manual

Table of Contents:

Summary

Other BENDPAK Evaporative Coolers Models