A.O. Smith 400A - Manual

A.O. Smith 400A

A.O. Smith 400A – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
Page: / 36

Table of Contents:

  • Page 2 – FOREWORD; GAS VALVE PIPING
  • Page 3 – WATER TEMPERATURE CONTROL; TABLE OF CONTENTS
  • Page 4 – QUICK INSTALLATION TIPS
  • Page 5 – CAUTION; If power is interrupted prior to completing one heat cycle, the; DISHWASHING MACHINE REQUIREMENT
  • Page 6 – CIRCULATING PUMP; INSTALLATION INSTRUCTIONS; REQUIRED ABILITY; Do not cover the temperature & pressure relief valve.; LOCATING THE HEATER; WARNING
  • Page 7 – Always disconnect electrical power before servicing the unit; See MAINTENANCE section for details of tank cleanout procedure.; /kW) of the total input of all appliances in the
  • Page 10 – VENT PIPE TERMINATION; DIRECT VENTING; DIRECT VENT TERMINAL INSTALLATION; IMPORTANT; The intake vent terminal and the exhaust vent terminal must
  • Page 11 – Vent terminals supplied with the heater must be used.; EXHAUST VENT TERMINAL; VERTICAL VENT TERMINAL INSTALLATION; INSTALLATION SEQUENCE
  • Page 12 – Table 2. VENT LENGTH TABLE
  • Page 13 – NOTE: LOW GAS IS LOCATED ON INLET SIDE OF GAS
  • Page 14 – DO NOT USE FLEXIBLE GAS PIPING.; CONNECTION OF GAS PIPE; When connecting gas pipe to unit, apply wrench to flange only.
  • Page 15 – SYSTEM CONNECTIONS
  • Page 16 – shall; NEVER; be introduced into this system.; HEATER WIRING; WHC1202 INTEGRATED WATER HEATER CONTROL
  • Page 17 – OPERATION; SEQUENCE OF OPERATION; Possible Cause; SELF DIAGNOSTIC CONTROLLER
  • Page 20 – OPERATING INSTRUCTIONS
  • Page 21 – FOR YOUR SAFETY READ BEFORE OPERATING; Clockwise to increase gas pressure and input rate.
  • Page 22 – To reduce the risk; GENERAL INFORMATION; The initial start-up procedure of the unit is provided on page 19.; MAINTENANCE; GAS SUPPLY SPECIFICATIONS; NATURAL GAS
  • Page 25 – INTERNAL CIRCULATING PUMP; Check for obstructions and/or deterioration of vent piping and
  • Page 26 – INSTALLATION DIAGRAMS; WITH OR WITHOUT BUILDING RECIRCULATION
  • Page 27 – TWO TEMPERATURE - ONE HEATER HIGH TEMPERATURE
  • Page 28 – : IF BUILDING COLD WATER SUPPLY HAS A BACK-; DANGER
  • Page 31 – MANIFOLD KITS; Space for the venting system and unit servicing must be added.
  • Page 32 – CHECKLIST AND SERVICE INFORMATION; VERIFY PROPER OPERATION AFTER SERVICING.; BURNER OPERATIONAL PROBLEMS; WATER IS TOO HOT; WATER LEAKAGE IS SUSPECTED
  • Page 34 – Model BTH Limited Warranty
  • Page 35 – NOTES
Loading the manual

1

A DIVISION OF A.O. SMITH CORPORATION

Mc BEE, SOUTH CAROLINA

STRATFORD (ONTARIO) CANADA

w w w. h o t w a t e r. c o m

PLACE THESE INSTRUCTIONS ADJACENT TO HEATER AND NOTIFY OWNER TO KEEP FOR FUTURE REFERENCE.

PRINTED IN U.S.A. 0306

PART NO. 197373-000

CYCLONE XHE

®

Model BTH 300A AND 400A

COMMERCIAL GAS WATER HEATER

GAS-FIRED POWER BURNER

FOR DOMESTIC HOT WATER

Thank you for buying this energy efficient water heater from
A.O. Smith Water Products Company. We appreciate your
confidence in our products.

CAUTION

TEXT PRINTED OR OUTLINED IN RED CONTAINS
INFORMATION RELATIVE TO YOUR SAFETY. PLEASE
READ THOROUGHLY BEFORE INSTALLING AND USING
THIS APPLIANCE.

• INSTALLATION • OPERATION • SERVICE • MAINTENANCE • LIMITED WARRANTY

WARNING: If the information in these
instructions is not followed exactly, a fire
or explosion may result causing property
damage, personal injury or death.

– Do not store or use gasoline or other

flammable vapors and liquids in the
vicinity of this or any other appliance.

– WHAT TO DO IF YOU SMELL GAS:

• Do not try to light any appliance.
• Do not touch any electrical switch;

d o n o t u s e a n y p h o n e i n y o u r
building.

• Immediately call your gas supplier

from a neighbor's phone. Follow the
gas supplier's instructions.

• If you cannot reach your gas supplier,

call the fire department.

– I n s t a l l a t i o n a n d s e r v i c e m u s t b e

performed by a qualified installer,
service agency or the gas supplier.

Series 970

Series 970

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - FOREWORD; GAS VALVE PIPING

2 These designs comply with the current edition of the AmericanN a t i o n a l St a n d a r d f o r G a s Wa t e r H e a t e r s , Vo l u m e I I I ,ANSI Z21.10.3 / CSA 4.3 as an automatic circulating tank waterheater, and automatic storage water heaters. Detailed installation diagrams are found in ...

Page 3 - WATER TEMPERATURE CONTROL; TABLE OF CONTENTS

3 DANGER THIS WATER HEATER IS EQUIPPED WITH AN ADJUSTABLETHERMOSTAT TO CONTROL WATER TEMPERATURE. HOTWAT E R T E M P E R AT U R E S R E Q U I R E D F O R A U T O M AT I CDISHWASHER AND LAUNDRY USE CAN CAUSE SCALD BURNSRESULTING IN SERIOUS PERSONAL INJURY AND/OR DEATH.THE TEMPERATURE AT WHICH INJURY ...

Page 4 - QUICK INSTALLATION TIPS

4 Horizontal Sidewall Venting Vertical Roof top Venting “AT A GLANCE” BTH 300/400 QUICK INSTALLATION TIPS

Other A.O. Smith Models

All A.O. Smith Other