Weil-McLain CGA5PIDN - User Manual
Weil-McLain CGA5PIDN Boiler – User Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Please read this page first; How to use this
- Page 3 – User’s Information Manual; Boiler water
- Page 4 – Boiler components; CGs
- Page 5 – PFG
- Page 6 – Maintain boiler using schedule below; Service technician; Owner maintenance
- Page 7 – User maintenance procedures; Component information; Boiler area; Boiler must be serviced & maintained
- Page 8 – Figure 3
- Page 9 – Figure 4; Pilot burner flame; Figure 5; Figure 6; Clean vent termination & air; — CGs boilers only; Check condensate drain
- Page 10 – Probe type— See Figure 8; Test low water cutoff (all steam boilers); Figure 7; Figure 8; Float type — See Figure 7
- Page 11 – Operate boiler relief valve; Figure 9; Clean gauge glass; Service periodically; continued
- Page 12 – Follow boiler shutdown procedure; Propane gas odorant; Lighting instructions
- Page 13 – FOR YOUR SAFETY READ BEFORE LIGHTING; TO TURN OFF GAS TO THE APPLIANCE
- Page 14 – Gas valve
- Page 16 – Operating instructions; FOR YOUR SAFETY READ BEFORE OPERATING
- Page 23 – Common problems and solutions; Symptom
- Page 24 – Weil-McLain Limited Warranties; Ultra
Do not store or use
gasoline or other flammable vapors and liquids
in the
vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS
•
Do not try to light any appliance
.
•
Do not touch any electrical switch
;
do not use any phone
in your
building.
•
Immediately
call your gas supplier from a neighbor’s phone
. Follow
the gas supplier’s instructions.
•
If you cannot reach your gas supplier, call the fire department
.
Installation and service must be performed by a qualified installer, service
technician or the gas supplier.
If the information in this manual is not followed exactly, a fire or
explosion may result, causing property damage, personal injury or
loss of life.
CGa, CGi, CGs, EG,
EGH, LGB, PEG, PFG
Gas-Fired Boilers
User’s
Information
Manual
Part Number 550-110-592/0408
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
CGa, CGi, CGs, EG, EGH, LGB, PEG, PFG Boilers Part Number 550-110-592/0408 Please read this page first How to use this manual . . . The Boiler manual is for use only by a qualified heating installer/service technician. Refer only to this User’s Information Manual for your reference. Improper install...
User’s Information Manual Part Number 550-110-592/0408 Failure to adhere to the guidelines on this page can result in severe personal injury, death or substantial property damage. S T O P ! ! — Read before proceeding Products to avoid Spray cans containing chloro/fluorocar-bons Permanent wave soluti...
CGa, CGi, CGs, EG, EGH, LGB, PEG, PFG Boilers Part Number 550-110-592/0408 Boiler components 1 Gas valve 2 Pilot burner 3 Main burner 4 Gas manifold/orifices 5 Control module 6 Inducer (CGi and CGs only) 7 Vent damper (CGa only) 8 Water temperature limit switch 9 Transformer 10 Spill switch (CGa onl...