Page 2 - I. GENERAL OPERATION; SAFETY RULES; SAFE OPERATION PRACTICES FOR RIDE-ON MOWERS
2 • Avoid starting or stopping on a slope. If tires lose trac- tion, disengage the blades and proceed slowly straight down the slope. DO NOT:• Do not turn on slopes unless necessary, and then, turn slowly and gradually downhill, if possible. • Do not mow near drop-offs, ditches, or embankments. The ...
Page 3 - WARNING
3 WARNING: In order to prevent ac- ci den tal starting when setting up, trans port ing, ad just ing or making re-pairs, al ways dis con nect spark plug wire and place wire where it can not contact spark plug. WARNING: Do not coast down a hill in neutral, you may lose control of the tractor. WARNING:...
Page 4 - TABLE OF CONTENTS; CUSTOMER RESPONSIBILITIES; PRODUCT SPECIFICATIONS
4 TABLE OF CONTENTS SAFETY RULES ......................................................... 2-3PRODUCT SPECIFICATIONS ....................................... 4CUSTOMER RESPONSIBILITIES ................................. 4ASSEMBLY ................................................................. 6-8OPE...
Page 5 - CONTENTS OF HARDWARE PACK
5 CONTENTS OF HARDWARE PACK Steering Wheel Seat Keys Slope Sheet (1) Oil Drain Tube (1) Bolt (1) Washer 17/32 x 1-3/16 x 12 Gauge (1) Lock Washer 1/2 (1) Large Flat Washer (1) Hex Bolt 1/4-28 x 1-1/4 (1) Locknut 1/4-28 (1) Locknut 1/2-20 (2) Keys Steering Wheel Adapter Steering Wheel Insert Steering...
Page 6 - ASSEMBLY; TOOLS REQUIRED FOR ASSEMBLY; UNPACK CARTON
6 ASSEMBLY TOOLS REQUIRED FOR ASSEMBLY A socket wrench set will make assembly easier. Stan dard wrench sizes are listed.(2) 7/16" wrenches Utility knife (2) 3/4" wrench Tire pres sure gauge PliersWhen right or left hand is mentioned in this man ual, it means when you are in the operating po ...
Page 7 - HOW TO SET UP YOUR TRACTOR
7 ASSEMBLY FIG. 2 TO ROLL TRACTOR OFF SKID (See Op- er a tion section for location and func tion of con trols) • Press lift lever plunger and raise attachment lift lever to its highest po si tion. • Release parking brake by depressing clutch/brake ped al. • Place gearshift lever in neutral (N) po si...
Page 8 - CHECKLIST; CHECK TIRE PRESSURE
8 ASSEMBLY ✓ CHECKLIST BEFORE YOU OPERATE AND ENJOY YOUR NEW TRAC- TOR, WE WISH TO ASSURE THAT YOU RECEIVE THE BEST PER FOR MANCE AND SATISFACTION FROM THIS QUALITY PROD UCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: ✓ All assembly instructions have been completed. ✓ No remaining loose parts in carton....
Page 9 - OPERATION
9 OPERATION These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their mean-ing. DANGER, KEEP HANDS AND FEET AWAY FREE WHEEL (Automatic Models only) OVER TEMP LIGHT KEEP AREA CLEAR SLOPE HAZARDS 15 15 15 (SEE SAFETY RULES SECTION) BATTERY REVERSE ...
Page 10 - KNOW YOUR TRACTOR
10 OPERATION KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and ad just ments. Save this manual for future reference. ATTACHMENT CLUTCH LEVER - Used t...
Page 11 - HOW TO USE YOUR TRACTOR
11 NOTE: Under certain conditions when tractor is standing idle with the engine running, hot engine exhaust gases may cause “brown ing” of grass. To eliminate this possibility, al-ways stop engine when stopping tractor on grass areas. CAUTION: Always stop tractor com- plete ly, as described above, b...
Page 12 - BEFORE STARTING THE ENGINE
12 TO OPERATE ON HILLS WARNING: Do not drive up or down hills with slopes great er than 15° and do not drive across any slope. • Choose the slowest speed before starting up or down hills. • Avoid stopping or changing speed on hills.• If slowing is necessary, move throttle control lever to slower pos...
Page 13 - MOWING TIPS
13 OPERATION TO START ENGINE (See Fig. 5) When starting the engine for the fi rst time or if the engine has run out of fuel, it will take extra cranking time to move fuel from the tank to the engine.• Sit on seat in operating position, depress clutch/brake pedal and set parking brake. • Place gear s...
Page 14 - MAINTENANCE; GENERAL RECOMMENDATIONS; BEFORE EACH USE
14 MAINTENANCE BEFO RE EAC H USE T RAC T 0 R Inspect Muffler/Spark Arrester Lubrication Chart Check Brake Operation Clean Air Filter Change Engine Oil (with oil filter) Replace Air Filter Paper Cartridge Replace Spark Plug Check Battery Level Check Tire Pressure Clean Battery and Terminals FILL IN D...
Page 15 - BATTERY; TRACTOR; BRAKE OPERATION
15 MAINTENANCE FIG. 9 FIG. 8 BATTERY Your tractor has a battery charging system which is suf fi cient for normal use. However, periodic charging of the battery with an automotive charger will extend its life.• Keep battery and terminals clean.• Keep battery bolts tight.• Keep small vent holes open.•...
Page 16 - ENGINE
16 MAINTENANCE V-BELTS Check V-belts for deterioration and wear after 100 hours and replace if necessary. The belts are not adjustable. Re place belts if they begin to slip from wear. TRANSAXLE COOLING Keep transaxle free from build-up of dirt and chaff which can restrict cooling. FIG. 11 FIG. 10 TO...
Page 17 - CLEANING; MUFFLER
17 MAINTENANCE CLEANING • Clean engine, battery, seat, fi nish, etc. of all foreign matter. • Keep fi nished surfaces and wheels free of all gasoline, oil, etc. • Protect painted surfaces with automotive type wax. We do not recommend using a garden hose or pressure washer to clean your tractor unles...
Page 18 - SERVICE AND ADJUSTMENTS
18 SERVICE AND ADJUSTMENTS WARNING: TO AVOID SE RI OUS IN JU RY, BEFORE PERFORMING ANY SERVICE OR ADJUST- MENTS: • Depress clutch/brake pedal fully and set parking brake. • Place gearshift lever in neutral (N) position. • Place attachment clutch in “DISENGAGED” position. • Turn ignition key to “STOP...
Page 19 - TO LEVEL MOWER HOUSING
19 TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 18) The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL -• Remove mower from tractor (See “TO REMOVE MOW ER” in this section of this manual). • Work belt off both mandrel pulley...
Page 22 - TO REPLACE HEADLIGHT BULB
22 FIG. 23 SERVICE AND ADJUSTMENTS REPLACING BATTERY (See Figs. 24 and 25) WARNING: Do not short battery ter mi nals by allowing a wrench or any other object to contact both terminals at the same time. Before connect-ing battery, remove metal bracelets, wristwatch bands, rings, etc.Positive terminal...
Page 23 - TO AD JUST THROTTLE CON TROL CABLE
23 SERVICE AND ADJUSTMENTS ENGINE TO AD JUST THROTTLE CON TROL CABLE The throttle control has been preset at the factory and ad just ment should not be necessary. If adjustment is nec- es sary, see engine manual. TO AD JUST CHOKE CON TROL The choke control has been preset at the factory and ad- just...
Page 24 - STORAGE; FUEL SYSTEM; ENGINE OIL; OTHER
24 STORAGE Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. WARNING: Never store the trac tor with gas o line in the tank inside a building where fumes may reach an open fl ame or spark. Allow the engine to cool before stor...
Page 25 - TROUBLESHOOTING POINTS
25 TROUBLESHOOTING POINTS Will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “CHOKED” properly. 2. See “TO START ENGINE” in Operation section. 3. Engine fl ooded. 3. Wait several minutes before attempting to start. 4. Bad spark plug. 4. Replace spark plug. 5. Dirty air fi lter. 5. Clean...
Page 27 - REPAIR PARTS; SCHEMATIC
27 REPAIR PARTS TRACTOR - - MODEL NUMBER WET2242STC SCHEMATIC BATTERY FUSE IGNITION SWITCH RED RED RED BLACK IGNITION UNIT HEADLIGHTS REMOVABLE CONNECTIONS BLACK BLACK BLACK WHITE WHITE WHITE RED BLACK ORANGE BLACK BROWN BLACK BLACK BLACK STARTER M SEAT SWITCH (NOT OCCUPIED) GROUNDING CONNECTOR ATT'...
Page 28 - ELECTRICAL
28 REPAIR PARTS TRACTOR - - MODEL NUMBER WET2242STC ELECTRICAL 28 29 26 24 42 43 27 27 25 41 27 27 40 33 90 30 8 2 1 27 16 16 52 48 22 21
Page 30 - CHASSIS AND ENCLOSURES
30 REPAIR PARTS TRACTOR - - MODEL NUMBER WET2242STC CHASSIS AND ENCLOSURES 26 25 58 64 208 13 208 11 1 3 2 9 208 209 209 209 5 5 207 3 3 3 142 3 3 3 142 17 29 28 12 51 57 53 52 54 55 145 37 3 37 24 26 25 31 24 30 35 3 26 33 10 26 34 35 18 14 38 14 206 212 219 20 219 chassis-pl.lt_stlt_48
Page 32 - DRIVE
32 REPAIR PARTS TRACTOR - - MODEL NUMBER WET2242STC DRIVE 29 28 112 14 41 38 39 57 51 74 75 78 76 77 1 25 19 24 2 53 35 34 37 36 35 62 36 59 212 55 77 61 22 27 26 6 113 18 51 5 18 6 85 52 30 32 32 30 52 11 85 80 4 3 13 81 84 82 64 65 145 79 16 96 26 27 51 48 150 151 202 49 47 50 120 21 8 10 156 165 ...
Page 34 - STEERING ASSEMBLY
34 REPAIR PARTS TRACTOR - - MODEL NUMBER WET2242STC STEERING ASSEMBLY 44 51 54 5 9 5 7 7 9 4 3 32 43 6 43 8 10 40 11 8 6 9 46 46 8 6 9 2 47 47 26 30 28 1 41 42 37 36 37 38 12 39 68 67 67 67 13 65 85 85 68 15 15 15 29 29 82 88 71 17 29 43 91
Page 36 - OPTIONAL EQUIPMENT
36 REPAIR PARTS TRACTOR - - MODEL NUMBER WET2242STC ENGINE 2 1 OPTIONAL EQUIPMENT Spark Arrester 29 26 25 4 23 45 8 10 62 6 5 72 13 14 38 105 16 105 3 81 engine-tecumseh_16 33 37 33 44 46 32 31 41 112 40
Page 38 - SEAT ASSEMBLY
38 REPAIR PARTS TRACTOR - - MODEL NUMBER WET2242STC SEAT ASSEMBLY KEY PART NO. NO. DESCRIPTION KEY PART NO. NO. DESCRIPTION 14 72050412 Bolt Rdhd Sht Nk 1/4-20 x 1-1/215 134300 Spacer Split 28 x 96 Yel Zinc16 121250X Spring Cprsn 1 27 Blk Pnt 17 123976X Nut Lock 1/4 Lge Flg Gr 5 Zinc21 171852 Bolt S...
Page 39 - DECALS
39 5 11 16 6 9 12 3 10 7 8 14 WHEELS & TIRES KEY PART NO. NO. DESCRIPTION KEY PART NO. NO. DESCRIPTION 6 2 1 5,8 4,10 3,9 11 7 REPAIR PARTS TRACTOR - - MODEL NUMBER WET2242STC DECALS 20 1 4 4 KEY PART NO. NO. DESCRIPTION 1 59192 Cap Valve Tire 2 65139 Stem Valve 3 106222X Tire F Ts 15 X 6 0 - 6 ...
Page 40 - MOWER LIFT
40 REPAIR PARTS TRACTOR - - MODEL NUMBER WET2242STC MOWER LIFT 15 20 16 17 18 20 20 15 20 4 5 6 2 3 1 6 5 4 7 8 12 11 31 32 31 32 19 19 13 13 13 13
Page 42 - MOWER DECK
42 REPAIR PARTS TRACTOR - - MODEL NUMBER WET2242STC MOWER DECK 15 14 13 11 10 9 8 16 68 37 184 30 31 32 33 146 148 145 150 45 144 147 147 142 149 142 54 52 53 55 56 34 1 46 44 21 24 25 26 27 2 28 29 23 21 21 21 18 18 20 2 48 59 19 4 3 5 6 21 40 143 36 40 37 40 159 42_deck_man-t-path_3 152 151 153 15...
Page 44 - SERVICE NOTES
Page 45 - LIMITED WARRANTY
45 LIMITED WARRANTY The Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materi-als and work man ship. For a period of two (2) years from date of purchase by the original consumer purchaser, we will repair or replace, at our option, w...
Page 46 - SERVICE; POLICY; WARRANTY; LIMITED WARRANTIES; A. Products Warranted
46 T E C U M S E H ® Issued January 1980Revised January 1991 T E C U M S E H ® SERVICE POLICY POLICY WARRANTY LIMITED WARRANTIES FOR NEW PEERLESS GEAR POWER TRAIN COMPONENTS A. Products Warranted Peerless Gear and Machine Division of Tecumseh Products Company (“Tecumseh”), subject to the limitations...
Page 47 - SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION
47 15 DEGREES MAX. FOLD ALONG DOTTED LINE THIS IS A 15 DEGREE SLOPE ONLY RIDE UP AND DOWN HILL,NOT ACROSS HILL SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mowslopes greater...
