Page 2 - I. GENERAL OPERATION; SAFETY RULES; Safe Operation Practices for Ride-On Mowers
2 • Avoid starting or stopping on a slope. If tires lose trac- tion, disengage the blades and proceed slowly straight down the slope. DO NOT:• Do not turn on slopes unless necessary, and then, turn slowly and gradually downhill, if possible. • Do not mow near drop-offs, ditches, or embankments. The ...
Page 4 - PRODUCT SPECIFICATIONS; CUSTOMER RESPONSIBILITIES; TABLE OF CONTENTS
4 PRODUCT SPECIFICATIONS Gasoline Capacity 1.25 Gallons and type: Unleaded Regular Oil Type (API-SF-sj): SAE 30 (above 32°F) SAE 5W-30 (below 32°F) Oil Capacity: 55 OZ. Spark Plug: Champion RN4C (GAP: .030")Ground Speed (MPH): Forward: 1st 1.1 2nd 2.2 3rd 3.3 4th 4.4 5th 4.9 Reverse: 1.4 Tire Pr...
Page 5 - UNASSEMBLED PARTS; Steering Wheel
5 UNASSEMBLED PARTS Steering Wheel Steering Wheel Insert Steering Boot Steering Wheel Adapter (1) Bolt (1) Washer 17/32 x 1-3/16 x 12 Gauge Seat (2) Keys Slope Sheet Keys (1) Lock Washer 1/2 Steering Extension Shaft (1) Large Flat Washer (1) Oil Drain Tube For Future Use (1) Hex Bolt 1/4-28 x 1-1/4 ...
Page 6 - ASSEMBLY; TOOLS REQUIRED FOR ASSEMBLY; UNPACK CARTON
6 ASSEMBLY TOOLS REQUIRED FOR ASSEMBLY A socket wrench set will make assembly easier. Stan dard wrench sizes are listed. (2) 1/2" wrenches Pliers (1) 9/16" wrench Tire pressure gauge Utility knife When right or left hand is mentioned in this man ual, it means when you are in the operating po...
Page 7 - HOW TO SET UP YOUR TRACTOR
7 ASSEMBLY TO R O L L T R AC TO R O F F S K I D ( S e e Op er a tion section for location and function of con trols) • Press lift lever plunger and raise attachment lift lever to its highest po si tion. • Release parking brake by depressing clutch/brake ped al. • Place gearshift lever in neutral (N)...
Page 8 - CHE CKLIST; CHECK TIRE PRESSURE
8 ASSEMBLY ✓ CHE CKLIST BEFORE YOU OPERATE AND ENJOY YOUR NEW TRAC- TOR, WE WISH TO ASSURE THAT YOU RE CEIVE THE BEST PER FORM ANCE AND SATISFACTION FROM THIS QUAL ITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: ✓ All assembly instructions have been completed. ✓ No remaining loose parts in carto...
Page 9 - OPERATION
9 OPERATION These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. DANGER, KEEP HANDS AND FEET AWAY FREE WHEEL (Automatic Models only) OVER TEMP LIGHT KEEP AREA CLEAR SLOPE HAZARDS 15 15 15 (SEE SAFETY RULES SECTION) BATTERY REVERSE F...
Page 10 - KNOW YOUR TRACTOR
10 OPERATION KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and ad just ments. Save this manual for future reference. Our tractors conform to the safe...
Page 11 - HOW TO USE YOUR TRACTOR
11 OPERATION The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye dam age. Always wear safety glass es or eye shields while op-erating your tractor or per form ing any adjustments or repairs. We rec om mend a wide vision safety mask over spe...
Page 12 - BEFORE STARTING THE ENGINE
12 OPERATION TO OPERATE MOWER (See Fig. 6) Your tractor is equipped with an operator presence sens ing switch. Any attempt by the operator to leave the seat with the engine running and the attachment clutch engaged will shut off the engine.• Select desired height of cut.• Start mower blades by engag...
Page 13 - MOWING TIPS
13 OPERATION MOWING TIPS • Tire chains cannot be used when the mower hous ing is attached to tractor. • Mower should be properly leveled for best mowing per- for mance. See “TO LEVEL MOWER HOUSING” in the Service and Adjustments section of this manual. • The left hand side of mower should be used fo...
Page 14 - MAINTENANCE; MAINTENANCE SCHEDULE; GENERAL RECOMMENDATIONS; BEFORE EACH USE
14 MAINTENANCE BEFORE EACH USE T R A C T 0 R Inspect Muffler/Spark Arrester Lubrication Chart Check Brake Operation Clean Air Filter Change Engine Oil (with oil filter) Replace Air Filter Paper Cartridge Replace Spark Plug Check Battery Level Check Tire Pressure Clean Battery and Terminals FILL IN D...
Page 15 - TRACTOR; BRAKE OPERATION
15 MAINTENANCE BLADE REMOVAL (See Fig. 8) • Raise mower to highest position to allow access to blades. • Remove blade bolt, lock washer and fl at washer se cur ing blade. • Install new or resharpened blade with trailing edge up towards deck as shown. IMPORTANT: TO ENSURE PROPER ASSEMBLY, CENTER HOLE...
Page 16 - ENGINE; LUBRICATION; TRANSAXLE COOLING; BATTERY
16 MAINTENANCE ENGINE LUBRICATION Only use high quality detergent oil rated with API service classifi cation SF-SJ. Select the oil’s SAE viscosity grade according to your expected operating temperature. TEMPERATURE RANGE ANTICIPATED BEFORE NEXT OIL CHANGE SAE VISCOSITY GRADES -20 0 30 40 80 100 -30 ...
Page 17 - CLEAN AIR SCREEN
17 MAINTENANCE FIG. 13 CLEAN AIR SCREEN Air screen must be kept free of dirt and chaff to prevent engine dam age from overheating. Clean with a wire brush or compressed air to re move dirt and stubborn dried gum fi bers. FIG. 12 AIR CLEANER COVER SCREWS GASKETS BREATH ERTUBE CAR BU RE TORTUBE MUFFLE...
Page 18 - MUFFLER; CLEANING
18 MAINTENANCE MUFFLER Inspect and replace corroded muffl er and spark arrester (if equipped) as it could create a fi re hazard and/or dam-age. SPARK PLUGS Replace spark plugs at the beginning of each mowing season or after every 100 hours of operation, whichever occurs fi rst. Spark plug type and g...
Page 19 - SERVICE AND ADJUSTMENTS
19 SERVICE AND ADJUSTMENTS WARNING: TO AVOID SE RI OUS IN JU RY, BEFORE PERFORMING ANY SERVICE OR ADJUST- MENTS: • Depress clutch/brake pedal fully and set parking brake. • Place gearshift lever in neutral (N) position. • Place attachment clutch in “DISENGAGED” position. • Turn ignition key to “STOP...
Page 20 - TO LEVEL MOWER HOUSING
20 TO REPLACE MOWER BLADE DRIVE BELT(See Fig. 20) The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL -• Place attachment clutch in “DIS EN GAGED” po si tion.• Move at tach ment lift lever forward to lower mower to its lowes...
Page 21 - TO A D
21 SERVICE AND ADJUSTMENTS FIG. 21 FIG. 22 TO A D J U S T S T E E R I N G W H E E L A L I G N - MENT If steering wheel crossbars are not horizontal (left to right) when wheels are positioned straight forward, remove steer- ing wheel and reassemble per instructions in the Assembly section of this man...
Page 24 - STORAGE; FUEL SYSTEM; ENGINE OIL; OTHER
24 STORAGE Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. WARNING: Never store the trac tor with gas o line in the tank inside a building where fumes may reach an open fl ame or spark. Allow the engine to cool before stor...
Page 25 - TROUBLESHOOTING POINTS
25 TROUBLESHOOTING POINTS Will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “CHOKED” properly. 2. See “TO START ENGINE” in Operation section. 3. Engine fl ooded. 3. Wait several minutes before attempting to start. 4. Bad spark plug. 4. Replace spark plug. 5. Dirty air fi lter. 5. Clean...
Page 27 - SCHEMATIC
27 TRACTOR - - MODEL NUMBER WET1338A SCHEMATIC BATTERY FUSE IGNITION SWITCH RED RED RED BLACK IGNITION UNIT HEADLIGHTS REMOVABLE CONNECTIONS BLACK BLACK BLACK WHITE WHITE WHITE RED BLACK ORANGE BLACK BROWN BLACK BLACK BLACK STARTER M SEAT SWITCH (NOT OCCUPIED) GROUNDING CONNECTOR ATT'MENT CLUTCH (CL...
Page 28 - REPAIR PARTS; ELECTRICAL
28 28 29 26 24 42 43 27 27 25 41 27 27 40 33 90 30 8 2 1 27 48 16 22 21 REPAIR PARTS TRACTOR - - MODEL NUMBER WET1338A ELECTRICAL 52 16
Page 30 - CHASSIS
30 REPAIR PARTS TRACTOR - - MODEL NUMBER WET1338A CHASSIS 3 2 35 3 26 3 35 26 33 10 34 1 208 11 17 29 28 208 13 12 51 57 53 52 54 55 24 26 25 26 25 31 24 30 209 8 209 6 16 9 15 209 209 209 5 5 145 37 37 18 205 205 38 38 206 212 chassis-pl.lt_23
Page 32 - DRIVE
32 REPAIR PARTS TRACTOR - - MODEL NUMBER WET1338A DRIVE 29 28 112 14 41 38 39 57 51 74 75 78 76 77 25 26 19 24 2 53 35 34 37 36 35 62 36 64 65 59 56 212 55 63 116 70 77 61 22 27 26 6 113 18 51 5 18 6 52 30 32 32 30 52 11 21 4 3 13 10 8 12 12 7 250 250 1 145 96 26 79 16 66 27 51 48 151 202 49 47 50 1...
Page 34 - STEERING
34 44 51 54 5 9 5 7 7 9 4 3 32 43 6 43 8 10 40 11 8 6 9 46 46 8 6 9 2 47 47 26 30 28 1 41 42 37 36 37 38 12 39 68 67 67 67 13 65 85 85 68 15 15 15 29 29 82 88 71 17 29 43 91 steering_pl.lt_42 REPAIR PARTS TRACTOR - - MODEL NUMBER WET1338A STEERING
Page 38 - SEAT
38 REPAIR PARTS TRACTOR - - MODEL NUMBER WET1338A SEAT KEY PART NO. NO. DESCRIPTION 1 127426X Seat2 140551 Bracket Seat Pivot 3 71110616 Bolt Hex 3/8 - 16 x 14 19131610 Washer 13/32 x 1 x10Ga.5 145006 Clip Push-In Hinged6 73800600 Nut Lock Hex w/Ins 3/8 - 167 124181X Spring Seat Cprsn 2 250 Blk Zi8 ...
Page 39 - DECALS
39 REPAIR PARTS TRACTOR - - MODEL NUMBER WET1338A DECALS KEY PART NO. NO. DESCRIPTION 1 181249 Decal, Clutch/Brake Eng2 162392 Decal, Grille3 64-1726-29 Decal, Engine HP5 164424 Decal, Side Panel6 157002 Decal, Fender Danger English7 162398 Decal Ins Str Wh9 171448 Decal Fender 12 164578 Decal, Hood...
Page 40 - MOWER LIFT
40 REPAIR PARTS TRACTOR - - MODEL NUMBER WET1338A MOWER LIFT 15 20 16 17 18 20 20 15 20 4 5 6 2 3 1 6 5 4 7 8 12 11 3132 3132 19 19 13 13 13 13 lift-rh.1piece_3
Page 42 - MOWER DECK
42 REPAIR PARTS TRACTOR - - MODEL NUMBER WET1338A MOWER DECK 19 86 38 42 2 15 14 13 11 10 98 1 21 2 96 97 29 27 23 26 28 25 24 21 87 88 21 146 31 40 150 45 32 33 69 55 56 36 36 89 123 113 53 30 109 89 122 40 89 108 107 68 4 3 5 6 2 21 149 16 21 2 110 54 148 152 151 153 154 157 158 67 153 156 155 38_...
Page 44 - SERVICE NOTES
Page 45 - LIMITED WARRANTY
45 LIMITED WARRANTY The Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materi-als and work man ship. For a period of two (2) years from date of purchase by the original consumer purchaser, we will repair or replace, at our option, w...
Page 46 - T E C U M S E H; SERVICE; P O L I C Y; WARRANTY; LIMITED WARRANTIES
46 T E C U M S E H ® 00661-te cumseh Issued January 1980Revised January 1991 T E C U M S E H ® 00661-tecumseh SERVICE P O L I C Y WARRANTY LIMITED WARRANTIES FOR NEW PEERLESS GEAR POWER TRAIN COMPONENTS A. Products Warranted Peerless Gear and Machine Division of Tecumseh Products Company (“Tecumseh”...
Page 47 - SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION
47 15 DEGREES MAX. FOLD ALONG DOTTED LINE THIS IS A 15 DEGREE SLOPE ONLY RIDE UP AND DOWN HILL,NOT ACROSS HILL SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION WARNING: To avoid serious injury, operate your tractor up and down the face of slopes, never across the face. Do not mowslopes greater...
