Weber D6 - Manual

5 GENERAL INSTRUCTIONS CLEANING WARNING: Turn your Weber ® gas barbecue OFF and wait for it to cool before cleaning. CAUTION: Do not clean your Flavorizer ® bars or cooking grates in a self-cleaning oven. For availability of replacement cooking grates and Flavorizer ® bars contact the Customer Servi...

6 CHECK FOR GAS LEAKS DANGER Do not use an open fl ame to check for gas leaks. Be sure there are no sparks or open fl ames in the area while you check for leaks. Sparks or open fl ames will result in a fi re or explosion which can cause serious bodily injury or death and damage to property. WARNING:...

9 1 = Grounding Wire2 = Solid Red Wire3 = Green Tab with Black Wire4 = White Tab with Black Wire5 = Yellow Tab with Black Wire6 = Blue Tab with Black Wire - + 5 - + 6 4 2 3 1 1 = Solid Blue Wire2 = White Tab with Black Wire3 = Yellow Tab with Black Wire4 = Blue Tab with Black Wire - + - + 2 3 4 1 D4...

10 OPERATING INSTRUCTIONS GRILLING METHODS NOTE: If grill looses heat while cooking refer to the troubleshooting section of this manual. You can adjust the Left and Right burners in each burner set as desired. The control settings are High (H), Medium (M), Low (L), or Off (O). If burners go out duri...

11 OPERATING INSTRUCTIONS INDIRECT COOKING The Indirect Method is similar to roasting, but with the added benefi ts of that grilled texture, fl avor, and appearance you can’t get from an oven. To set up for Indirect cooking, gas burners are lit on either side of the food but not directly beneath it....

12 OPERATING INSTRUCTIONS LIGHTING Summary lighting instructions are on the control panel. *The grill illustrated may have slight differences than the model purchased. TO EXTINGUISH Push down and turn each burner control knob clockwise to the OFF position. Turn gas supply OFF at the source. DANGER F...

13 OPERATING INSTRUCTIONS MANUAL LIGHTING 6 D4 2 1 2 4,5,7 3 6 D6 1 4,5,7 2 3 2 *The grill illustrated may have slight differences than the model purchased. TO EXTINGUISH Push down and turn each burner control knob clockwise to the OFF position. Turn gas supply OFF at the source. DANGER Failure to o...

14 OPERATING INSTRUCTIONS USING THE SMOKER The smoker uses presoaked wood chips. For best results with faster cooking foods like steaks, burgers and chops, etc., we recommend using fi ner wood chips because they ignite and create smoke faster. For longer cooking foods such as roasts, chicken and tur...

15 OPERATING INSTRUCTIONS LIGHTING THE SMOKER BURNER WARNING: Check hose before each use of grill for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the grill. Replace using only Weber ® authorized replacement hose. Contact the Customer Service Represen...

16 OPERATING INSTRUCTIONS MANUALLY LIGHTING THE SMOKER BURNER WARNING: Check hose before each use of grill for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the grill. Replace using only Weber ® authorized replacement hose. Contact the Customer Service...

17 OPERATING INSTRUCTIONS ROTISSERIE ASSEMBLY Parts required: rotisserie motor bracket(1), rotisserie motor(1), rotisserie shaft(1), spit forks(4) and fork screws (4). 1) Install the motor bracket Attach the stainless steel motor bracket to the left side of the cooking box, using the 1/4-20 fastener...

19 LIGHTING THE ROTISSERIE BURNER  ATTENTION: READ BEFORE LIGHTING ROTISSERIE BURNER After a period of non-use, before lighting the Rotisserie Burner, a few seconds must pass for the gas supply line to fi ll.When holding the ignition button you will see a fl ash of fl ames moving from right to left...

20 OPERATING INSTRUCTIONS MANUALLY LIGHTING THE ROTISSERIE BURNER ATTENTION: READ BEFORE LIGHTING ROTISSERIE BURNER After a period of non-use, before lighting the Rotisserie Burner, a few seconds must pass for the gas supply line to fi ll.When holding a match to the Rotisserie Burner you will see a ...

PROBLEM CHECK CURE Burners burn with a yellow or orange fl ame, in conjunction with the smell of gas. Inspect Spider / Insect Screens for possible obstructions. (Blockage of holes.) Clean Spider / Insect Screens. (See Section “Annual Maintenance”) Burner does not light, or fl ame is low in HIGH posi...

22 ROTISSERIE TROUBLESHOOTING PROBLEM CHECK CURE Burner does not light. Did you hold the burner control knob down and hold down for 20 seconds until after burner ignited? Try to relight burner by holding burner control knob down and continue holding down until 20 seconds after burner has ignited. Di...

23 MAINTENANCE WEBER ® SPIDER /INSECT SCREENS Your Weber ® gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section (1) of the burner tubes. This blocks the normal gas fl ow, and can cause the gas to fl ow back out of the com...

24 REPLACE MAIN BURNERS 1. Your Summit ® gas grill must be OFF and cool. 2. Turn gas OFF at source. 3. Disconnect regulator. 4. Remove cooking grates. 5. Remove Smoker box. 6. Remove Flavorizer ® bars. 7. To remove control panel refer to “Remove the control panel” under “Check for Gas Leaks.” 8. Dis...

27 15. To reinstall the manifold assembly, reverse steps 7 through 14. CAUTION: The burner openings (1) must be positioned properly over the valve orifi ces (2). Check proper assembly before fastening manifold in place. WARNING: After reinstalling the gas lines, they should be leak checked with a so...