Weber 55768 - Manual

A-5 General Instructions Your Weber ® gas barbecue is a portable outdoor cooking appliance. With the Weber ® gas barbecue you can grill, barbecue, roast and bake with results that are difficult toduplicate with indoor kitchen appliances. The closed lidand Flavorizer ® bars produce that “outdoor” fla...

A-6 General Instructions Cooking WARNING: Do not move the Weber ® gas barbecue when operating or while barbecue is hot. You can adjust the FRONT and BACK burners as desired.The control settings: High (H), Medium (M), Low (L), or Off(O) are described in your Weber ® cookbook. The cookbook uses these ...

A-7 Exploded View 12 Genesis ® Silver C PremHD NG 102203 5 6 7 8 9 10 11 13 16 17 20 21 22 23 24 25 26 33 3435363738 39 40 41 424344 45 34 46 47 50 52 53 18 15 14 48 54 1 2 3 4 27 28 30 31 29 32 19 49 51

A-8 Exploded View List 1. Hinge Pin 2. Left Endcap 3. Shroud 4. Handle 5. Warm-Up ™ Basket 6. Warming Rack 7. Cooking Grates 8. Flavorizer ® Bars 9. Cooking Box 10. 1/4-20 keps nut 11. Slide Out Bottom Tray 12. Work Surface 13. Catch Pan Holder 14. Left Rear Trim Assembly Arm 15. 1/4 - 14 x 5/8 inch...

A-9 Parts List Cooking Box Assembly - 1 Caster Frame - 1 Wheel Frame - 1 Bottom Rack - 1 Left Trim Assembly - 1 Right Swing Up Table - 1 Side Table - 1 Flavorizer ® Bars - 5 War m-Up ™ Basket - 1 War ming Rack - 1 Hose - 1 Bottom Tray - 1 Catch-Pan Holder - 1 Catch-Pan - 1 Disposable Drip Pans - 2 1...

C-1 Gas Instructions Install Gas Supply General Specifications for PipingNote - Contact your local municipality for buildingcodes regulating outdoor gas barbecue installations.In absence of Local Codes, you must confirm to thelatest edition of ANSI Z223.1. WE RECOMMEND THATTHIS INSTALLATION BE DONE ...

C-3 Gas Instructions Check for gas leaks  DANGER Do not use an open flame to check for gas leaks. Besure there are no sparks or open flames in the areawhile you check for leaks. Sparks or open flames willresult in a fire or explosion which can cause seriousbodily injury or death and damage to prope...

D-1 Operating Instructions Lighting Summary lighting instructions are on the control panel. DANGER Failure to open the lid while igniting thebarbecue’s burners, or not waiting 5 minutesto allow the gas to clear if the barbecue doesnot light, may result in an explosive flame-upwhich can cause serious...

D-2 Operating Instructions Manual Lighting DANGER Failure to open lid while igniting thebarbecue’s burners, or not waiting 5 minutesto allow the gas to clear if the barbecue doesnot light, may result in an explosive flame-upwhich can cause serious bodily injury ordeath. 1) Open the lid.2) Make sure ...

D-4 Troubleshooting Problem Check Cure Burners burn with a yellow ororange flame, in conjunction withthe smell of gas. Inspect Weber ® Insect/Spider Screens for possible obstructions.(Blockage of holes.) Clean Weber ® Insect/Spider Screens. (See Section “AnnualMaintenance”) Burner does not light, or...

D-5 Side Burner maintenance WARNING: All gas controls and supply valves should be in the OFF position. Check igniter: Remove side burner cover. To remove sideburner cover, remove control knob and screws that holdcover to bottom(1). Problem Check Cure Side Burner does not light. Flame is low in HIGH ...

E-1 Maintenance (1) (1) Main Burner Flame Pattern The Weber ® gas barbecue burners have been factory set for the correct air and gas mixture. The correct flamepattern is shown.1) Burner tube2) Tips occasionally flicker yellow3) Light blue4) Dark blue If the flames do not appear to be uniform through...

E-2 Maintenance Replacing Main Burners 1) Your Weber ® gas barbecue must be OFF and cool. 2) Turn gas OFF at source.3) To remove control panel: take off the burner control knobs. Remove the screws holding the control panel inplace. Lift off the control panel. 4) Unhook the manifold bracket(1) and un...