Weber 42373 - Manual

55 GAS INSTRUCTIONS Check for gas leaks DANGER Do not use an open fl ame to check for gas leaks. Be sure there are no sparks or open fl ames in the area while you check for leaks. Sparks or open fl ames will result in a fi re or explosion which can cause serious bodily injury or death and damage to ...

66 GAS INSTRUCTIONS Remove the Front Panel by sliding the panel up and out of the slots. Check: 1) Gas line-to-manifold connections. WARNING: If there is a leak at connection (1), retighten the fi tting with a wrench and recheck for leaks with soap and water solution. If a leak persists after re-tig...

77 OPERATING INSTRUCTIONS The most important thing to know about grilling is which cooking method to use for a specifi c food, Direct or Indirect. The difference is simple: place the food directly over the fi re, or arrange the fi re on either side of it. Using the right method is the shortest route...

88 OPERATING INSTRUCTIONS Indirect cooking The Indirect Method is similar to roasting, but with the added benefi ts of that grilled texture, fl avor, and appearance you can’t get from an oven. To set up for Indirect cooking, gas burners are lit on either side of the food but not directly be-neath it...

99 OPERATING INSTRUCTIONS *The grill illustrated may have slight differences than the model purchased. To Extinguish Push down and turn each burner control knob clock-wise to the OFF position. Turn gas supply OFF at the source. 1 2 2 3 6 4,5,8 7 Lighting Summary lighting instructions are on the cont...

10 10 OPERATING INSTRUCTIONS Manual Lighting *The grill illustrated may have slight differences than the model purchased. To Extinguish Push down and turn each burner control knob clock-wise to the OFF position. Turn gas supply OFF at the source. 2 1 2 4,5,7 6 3 DANGER Failure to open lid while igni...

11 Problem Check Cure Burners burn with a yellow or orange fl ame, in conjunction with the smell of gas. Inspect Spider / Insect Screens for possible obstructions. (Blockage of holes.) Clean Spider / Insect Screens. (See Section “Annual Maintenance”) Burner does not light, or fl ame is low in HIGH p...

12 12 MAINTENANCE WEBER ® SPIDER /INSECT SCREENS Your Weber ® gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section(1) of the burner tubes. This blocks the normal gas fl ow, and can cause the gas to fl ow back out of the a...

13 13 MAINTENANCE Replacing Main Burners 1. Your Summit ® gas grill must be OFF and cool. 2. Turn gas OFF at source. 3. Disconnect regulator. 4. Remove cooking grates. 5. Remove Smoker box. 6. Remove Flavorizer ® bars. 7. To remove control panel refer to “Remove the control panel” under “Check for G...

15 15 MAINTENANCE Crossover ® Ignition System Operations If the Crossover ® ignition system fails to ignite the LEFT burner in a burner set, light the LEFT burner with a match. If the LEFT burner lights with a match, then check the Crossover ® ignition system. • Check that both ignition wires (1,2) ...