Page 2 - DANGERS AND WARNINGS
2 DANGERS AND WARNINGS DANGER Failure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manual may result in serious bodily injury or death, or in a fi re or an explosion causing damage to property. WARNINGS Do not store a spare or disconnected liquid propane cylinder under or n...
Page 3 - WARRANTY
3 WARRANTY Weber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber ® gas grill that it will be free of defects in material and workmanship from the date of purchase as follows: when assembled and operated in accordance with the printed instructions accompanying it....
Page 4 - GENERAL INSTRUCTIONS; FOR INSTALLATION IN CANADA; gas barbecue shall not be; STORAGE AND/OR NONUSE
4 GENERAL INSTRUCTIONS Your Weber ® gas barbecue is a portable outdoor cooking appliance. With the Weber ® gas barbecue you can grill, barbecue, roast and bake with results that are diffi cult to duplicate with indoor kitchen appliances. The closed lid and Flavorizer ® Bars produce that “outdoor” fl...
Page 5 - CLEANING
5 GENERAL INSTRUCTIONS CLEANING WARNING: Turn your Weber ® gas barbecue OFF and wait for it to cool before cleaning. CAUTION: Do not clean your Flavorizer ® bars or cook- ing grates in a self-cleaning oven. For availability of replacement cooking grates and Flavorizer ® bars contact the Customer Ser...
Page 6 - GAS INSTRUCTIONS; IMPORTANT LP CYLINDER INFORMATION; CHECK THAT ALL BURNER VALVES ARE OFF; DANGER; CONNECTING THE LIQUID PROPANE CYLINDER; WARNING: Make sure that the LP cylinder valve is
6 GAS INSTRUCTIONS IMPORTANT LP CYLINDER INFORMATION Failure to follow these DANGER statements exactly may result in a fi re causing death or serious injury. CHECK THAT ALL BURNER VALVES ARE OFF Valves are shipped in the OFF position, but you should check to be sure that they are turned OFF. Check b...
Page 7 - WARNING: Do not use a wrench to tighten the; CHECK FOR GAS LEAKS; WARNING : The gas connections of your Summit; REMOVE CONTROL PANEL
7 GAS INSTRUCTIONS Note: This connection tightens clockwise and will not allow gas to fl ow unless the connection is tight. The connection requires tightening by hand only. WARNING: Do not use a wrench to tighten the connection. Using a wrench could damage the regulator coupling and could cause a le...
Page 9 - turn OFF the gas. DO NOT OPERATE THE GRILL.; Contact; SUMMIT
9 (8) (2) (4) (6) (7) (1) (3) GAS INSTRUCTIONS (5) (3) (2) (1) (4) Check: 1) Hose connection. 2) Gas line to manifold connections. WARNING: If there is a leak at connection (1, or 2), retighten the fi tting with a wrench and recheck for leaks with soap and water solution. If a leak persists after re...
Page 10 - REINSTALL CONTROL PANEL
10 GAS INSTRUCTIONS REINSTALL CONTROL PANEL Parts required: control panel, screws, and burner control knobs. Place the control panel back onto the control panel brackets on either side of the front of the cooking box. Line up screws with screw holes on both the control panel and control panel bracke...
Page 11 - REFILLING THE LIQUID PROPANE CYLINDER; WARNING: We recommend that your LP cylinder be; CHECKING THE FUEL LEVEL IN YOUR TANK
11 GAS INSTRUCTIONS REFILLING THE LIQUID PROPANE CYLINDER We recommend that you refi ll the LP cylinder before it is completely empty. Removal of the LP cylinder 1) Close cylinder valve (turn clockwise). 2) Unscrew regulator coupling by turning counterclockwise, by hand only. 3) Loosen cylinder lock...
Page 13 - OPERATING INSTRUCTIONS; GRILLING METHODS; WARNING: Check the bottom tray and catch pan for; DIRECT COOKING
13 OPERATING INSTRUCTIONS GRILLING METHODS NOTE: If grill looses heat while cooking refer to the troubleshooting section of this manual. You can adjust the Left and Right burners in each burner set as desired. The control settings are High (H), Medium (M), Low (L), or Off (O). If burners go out duri...
Page 14 - INDIRECT COOKING; GRILLING TIPS & HELPFUL HINTS
14 INDIRECT COOKING The Indirect Method is similar to roasting, but with the added benefi ts of that grilled texture, fl avor, and appearance you can’t get from an oven. To set up for Indirect cooking, gas burners are lit on either side of the food but not directly beneath it. Heat rises, refl ects ...
Page 15 - LIGHTING; authorized replacement; MAIN BURNER LIGHTING
15 1 3 6 4,5,8 7 2 2 OPERATING INSTRUCTIONS LIGHTING Summary lighting instructions are on the control panel. DANGER Failure to open the lid while igniting the barbecue’s burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive fl ame-up w...
Page 16 - MANUAL LIGHTING; TO EXTINGUISH
16 OPERATING INSTRUCTIONS DANGER When the “excess gas fl ow control” feature is activated, a small amount of gas is still fl owing to the burners. After turning OFF the cylinder knobs, wait at least 5 minutes for the gas to clear before attempting to light the barbecue. Failure to do so may result i...
Page 17 - WARNING: If the burner does not light, turn the LEFT
17 DANGER When the “excess gas fl ow control” feature is activated, a small amount of gas is still fl owing to the burners. After turning OFF the cylinder and burner control knobs, wait at least 5 minutes for the gas to clear before attempting to light the barbecue. Failure to do so may result in an...
Page 18 - SIDE BURNER LIGHTING INSTRUCTIONS; LIGHTING WITH IGNITER
18 OPERATING INSTRUCTIONS SIDE BURNER LIGHTING INSTRUCTIONS DANGER Failure to open the lid while igniting the side burner, or not waiting 5 minutes to allow the gas to clear if the side burner does not light, may result in an explosive fl ame-up which can cause serious bodily injury or death. Lighti...
Page 19 - USING THE SMOKER
19 OPERATING INSTRUCTIONS USING THE SMOKER The smoker uses presoaked wood chips. For best results with faster cooking foods like steaks, burgers and chops, etc., we recommend using fi ner wood chips because they ignite and create smoke faster. For longer cooking foods such as roasts, chicken and tur...
Page 20 - LIGHTING THE SMOKER BURNER; WARNING: The burner control knobs must be in
20 OPERATING INSTRUCTIONS LIGHTING THE SMOKER BURNER WARNING: Check hose before each use of grill for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the grill. Replace using only Weber ® authorized replacement hose. Contact the Customer Service Represen...
Page 21 - WARNING: Do not lean over the open grill while; MANUALLY LIGHTING THE SMOKER BURNER; WARNING: Check hose before each use of grill for
21 OPERATING INSTRUCTIONS 5) Turn the cylinder on by turning the cylinder valve counterclockwise. WARNING: Do not lean over the open grill while lighting. 6) Push smoker burner control knob down and turn to START/HI. 7) Push and hold down the Igniter button until burner ignites. You will hear the ig...
Page 23 - ROTISSERIE ASSEMBLY
23 OPERATING INSTRUCTIONS ROTISSERIE ASSEMBLY Parts required: rotisserie motor bracket(1), rotisserie motor(1), rotisserie shaft(1), spit forks(4) and fork screws (4). 1) Install the motor bracket Attach the stainless steel motor bracket to the left side of the cooking box, using the 1/4-20 fastener...
Page 24 - USING THE ROTISSERIE
24 OPERATING INSTRUCTIONS USING THE ROTISSERIE Note - Before using your rotisserie, measure your food at the widest point. If it exceeds 9 1/2” (241.8mm), it is too large to fi t the rotisserie. If it is too large, food can be prepared using a roast holder and the Indirect Cooking Method. IMPORTANT ...
Page 25 - LIGHTING THE ROTISSERIE BURNER; ATTENTION: READ BEFORE
25 OPERATING INSTRUCTIONS LIGHTING THE ROTISSERIE BURNER ATTENTION: READ BEFORE LIGHTING ROTISSERIE BURNER After a period of non-use, before lighting the Rotisserie Burner, a few seconds must pass for the gas supply line to fi ll.When holding the ignition button you will see a fl ash of fl ames movi...
Page 26 - WARNING: The burner control knobs must be in the
26 OPERATING INSTRUCTIONS 3) Make sure all burner control knobs are turned OFF. (Push control knob down and turn clockwise to ensure that it is in the OFF position.) WARNING: The burner control knobs must be in the OFF position before turning on the liquid propane cylinder tank valve. If they are no...
Page 27 - MANUALLY LIGHTING THE ROTISSERIE BURNER
27 OPERATING INSTRUCTIONS MANUALLY LIGHTING THE ROTISSERIE BURNER ATTENTION: READ BEFORE LIGHTING ROTISSERIE BURNER After a period of non-use, before lighting the Rotisserie Burner, a few seconds must pass for the gas supply line to fi ll.When holding a match to the Rotisserie Burner you will see a ...
Page 28 - WARNING: Do not lean over the open grill.
28 OPERATING INSTRUCTIONS WARNING: The burner control knobs must be in the OFF position before turning on the liquid propane cylinder tank valve. If they are not in the OFF position, when you turn on the LP cylinder valve, the "excess gas fl ow control" feature will activate, limiting the fl...
Page 29 - MAIN AND SMOKER TROUBLESHOOTING; PROBLEM; CAUTION: Do not line the bottom
29 MAIN AND SMOKER TROUBLESHOOTING PROBLEM CHECK CURE Burners burn with a yellow or orange fl ame, in conjunction with the smell of gas. Inspect Spider / Insect Screens for possible obstructions. (Blockage of holes.) Clean Spider / Insect Screens. (See Section “Annual Maintenance”) Burners do not li...
Page 30 - SIDE BURNER TROUBLESHOOTING; SIDE BURNER MAINTENANCE; WARNING: All gas controls and supply valves should; Side Burner does not light.; Is the fuel hose bent or kinked?
30 SIDE BURNER TROUBLESHOOTING SIDE BURNER MAINTENANCE WARNING: All gas controls and supply valves should be in the OFF position. Make sure black wire is connected between the igniter and electrode (1) . Make sure white wire is connected between the igniter and grounding clip (2) . Spark should be a...
Page 31 - Burner does not light.; Is the igniter sparking?; ROTISSERIE TROUBLESHOOTING
31 PROBLEM CHECK CURE Burner does not light. Did you hold the burner control knob down and hold down for 20 seconds until after burner ignited? Try to relight burner by holding burner control knob down and continue holding down until 20 seconds after burner has ignited. Did you wait to see the entir...
Page 32 - MAINTENANCE; ANNUAL MAINTENANCE
32 WEBER ® SPIDER /INSECT SCREENS Your Weber ® gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section(1) of the burner tubes. This blocks the normal gas fl ow, and can cause the gas to fl ow back out of the air shutter. Thi...
Page 33 - REPLACE MAIN BURNERS
33 MAIN BURNER FLAME PATTERN The Weber ® gas barbecue burners have been factory set for the correct air and gas mixture. The correct fl ame pattern is shown.1) Burner tube 2) Tips occasionally fl icker yellow 3) Light blue 4) Dark blue If the fl ames do not appear to be uniform throughout the burner...
Page 35 - WARNING: After reinstalling the gas lines, they should
35 12. Lift and twist the burner assembly slightly, to separate the Crossover ® tube (a) from the burners (b). (a) (b) (b) 13. Remove the Crossover ® tube. 14. Pull the selected burner(s) tube(s) from manifold frame and replace with a new burner tube. 15. To reinstall the manifold assembly, reverse ...
