Wayne Dalton 9200 Foamcore - Manual
Wayne Dalton 9200 Foamcore – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – MAINTENANCE AND PAINTING
- Page 4 – START HERE; REMOVAL OF AN EXISTING DOOR CAN BE DANGEROUS. FOLLOW
- Page 5 – Jamb brackets are stamped for identification.; DO NOT RAISE DOOR UNTIL HORIZONTAL TRACKS ARE SECURED; TRUSS HEAD
- Page 7 – OF DOOR EDGE, OTHERWISE DOOR COULD FALL, RESULTING IN; LIFETIME LIMITED WARRANTY
- Page 8 – TYPICAL OPERATOR INSTALLATION
PART NO. 248438
TOP BRACKET
FLAGANGLE
HORIZONTAL
TRACK
VERTICAL
TRACK
CENTER HINGE
#3 END HINGE
BOTTOM BRACKET
REAR SUPPORT ASSEMBLY
(NOT SUPPLIED)
HORIZONTAL
ANGLE
ROLLER
TL-2 JAMB
BRACKET
#2 END HINGE
#1 END HINGE
TORSION TUBE
CENTER BEARING
BRACKET
RIGHT HAND
CABLE DRUM
END BEARING
BRACKET
LEFT HAND CABLE
DRUM
COUNTERBALANCE
CABLE
ASTRAGAL
Parts List
TOP BRACKET BASE
# 158044
TOP BRACKET SLIDE
# 158046
ROLLER
# 154489
VERTICAL TRACK
1 PAIR
TL-1 JAMB BRACKET
# 261965
TL-2 JAMB BRACKET
# 261966
TL-3 JAMB BRACKET
# 261967
HORIZONTAL TRACK
1 PAIR
12 FLAGANGLE (LEFT)
# 240380
12 FLAGANGLE (RIGHT)
# 240381
15 FLAGANGLE (LEFT)
# 240382
15 FLAGANGLE (RIGHT)
# 240383
22-1/16 HORIZ. ANGLE
# 292536
80 HORIZ. ANGLE (RIGHT)
# 292539
80 HORIZ. ANGLE (LEFT)
# 292538
TORSION SPRING (RED)
AS REQUIRED
TORSION SPRING (BLACK)
AS REQUIRED
COUNTERBALANCE CABLES
1 PAIR
CABLE DRUM (RIGHT)
# 284653
CABLE DRUM (LEFT)
# 284654
END BEARING BRACKET (LEFT)
# 279134
END BEARING BRACKET (RIGHT)
# 103415
CENTER BEARING BRACKET
# 100298
NYLON CENTER BUSHING
# 103336
# 6 SCREW EYE
# 100362
60 PULL ROPE
# 274884
NOTE:
DEPENDING ON YOUR DOOR MODEL, SOME PARTS
LISTED MAY NOT BE SUPPLIED IF NOT NECESSARY.
INSIDE STEP PLATE
OUTSIDE STEP PLATE
© Copyright 2002 Wayne-Dalton Corp.
Rev.2 02/02
PULL ROPE &
SCREW EYE
9900 Thermowayne 9600 Thermogard
®
9200 Foamcore
Torsion Spring
Installation Instructions and Owners Manual
TL-1 JAMB
BRACKET
NYLON CENTER
BUSHING
RIGHT HAND WOUND
TORSION SPRING (RED)
END BEARING
BRACKET
LEFT HAND WOUND
TORSION SPRING (BLACK)
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
IMPORTANT SAFETY NOTICES Read these instructions carefully before attempting installation. If in question about any of the proce- dures, do not perform the work. Instead, have a qualified door agency do the installation or repairs. 1. Wear protective gloves during installation to avoid possible cuts...
FLAGANGLE (2) 5/16 x 1-5/8 LAG SCREW TOP SECTION NOTE: CABLE SHOULD BE BETWEEN TRACK AND DOOR AND BEHIND ROLLERS 10 8 TOP BRACKET (4) 1/4-20 x 5/8 SELF TAPPING SCREWS 1 ST SET OF HOLES ON 9900 THERMOWAYNE 2 ND SET OF HOLES ON 9600 THERMOGARD ® 3 RD SET OF HOLES ON 9200 FOAMCORE 3 U-BAR TOP SEC...
T H G I E H R O O D 1 - L T 2 - L T 3 - L T " 0 ' 6 K C A R T " 4 6 ) m m 6 2 6 1 ( M O T T O B M O T T O B A / N " 5 ' 6 K C A R T " 9 6 ) m m 3 5 7 1 ( E L D D I M M O T T O B A / N " 6 ' 6 K C A R T " 0 7 ) m m 8 7 7 1 ( E L D D I M M O T T O B A / N " 8 ' 6 K C A R T ...
