Troy-Bilt RZT 50- User Manual

Troy-Bilt RZT 50

Troy-Bilt RZT 50– User Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
Page: / 36

Table of Contents:

  • Page 2 – TRACTOR PREPARATION; INSTALL THE OPERATOR’S SEAT; The seat is partially inserted into the slots of the; Figure 1; TABLE OF CONTENTS
  • Page 3 – Spacer
  • Page 4 – WARNING; IMPORTANT; HEED ITS WARNING; SAFE OPERATION PRACTICES; GENERAL OPERATION; Never carry passengers.; DANGER
  • Page 7 – SAFETY DECALS AND LABELS; ON; W A R N I N G
  • Page 8 – SAFETY GRAPHIC – LOCATED ON
  • Page 9 – RECORDING MODEL AND SERIAL NUMBER; Before you start assembling your new equipment; CUSTOMER SUPPORT; engine
  • Page 10 – SLOPE GAUGE
  • Page 11 – SECTION 1: CONTROLS AND FEATURES; Figure 4; Deck Height Index
  • Page 13 – right; Follow the oil change; Battery Indicator
  • Page 14 – If the LH and RH drive control levers; Figure 9; This symbol indicates the
  • Page 15 – GENERAL SAFETY; DO NOT direct the mower discharge at people.; BEFORE OPERATING YOUR TRACTOR; Purchase gasoline in small quantities. Do not; SAFETY INTERLOCK SYSTEM
  • Page 16 – STARTING THE ENGINE; Operator must be sitting in the tractor seat.; COLD WEATHER STARTING
  • Page 17 – STOPPING THE ENGINE; Place the PTO switch in the “OFF” position.; DRIVING THE TRACTOR; Release the parking brake.
  • Page 18 – Driving the Tractor Forward; Always maintain your grasp on the; Turning the Tractor While Driving Forward; - To turn to the left, move the left drive control; Neutral; DRIVING FORWARD; Slower; FORWARD LEFT TURN
  • Page 19 – Driving the Tractor In Reverse; Turning While Driving Rearward; - To turn to the left while traveling in reverse,; DRIVING REARWARD; REARWARD LEFT TURN
  • Page 20 – CLOCKWISE ZERO TURN
  • Page 21 – USING THE MOWER DECK; Do not engage the mower deck; CHECKING THE SAFETY INTERLOCK CIRCUITS
  • Page 22 – SECTION 3: ADJUSTMENTS; ADJUSTING THE OPERATORS SEAT; If the control lever is too tight to move, slightly
  • Page 23 – SECTION 4: MAINTENANCE; ENGINE MAINTENANCE; Oil Fill Tube; Hex Tapp Screw
  • Page 24 – Carefully lift the battery out of the tractor.; Full Charge
  • Page 25 – The tractor will not drive with the; TRACTOR CREEPING; Lower the tractor and remove the jack.; RH Transmission
  • Page 26 – TRACTOR HIGH SPEED TRACKING; If the stop bolt is adjusted too far, the; TRANSMISSION DRIVE BELT
  • Page 27 – Remove the battery if exposed to prolonged; REMOVING THE TRACTOR FROM STORAGE
  • Page 28 – SECTION 5: MOWER DECK; DECK REMOVAL; Remove the mower deck from the tractor as follows:; Releasing belt tension with the idler pulley.; If pulling the
  • Page 29 – DECK INSTALLATION; To install the mower deck, proceed as follows:; Using the idler pulley to tension the belt.; PTO Belt
  • Page 30 – Lower the deck to the middle height position.; Front to Back Leveling.; The deck front hanger rod should
  • Page 31 – Turn on the water supply.; Cleaning the Spindle Pulleys
  • Page 36 – MANUFACTURER’S LIMITED WARRANTY FOR:; HOW TO OBTAIN SERVICE:
Loading the manual

RZT 50 w/50" Mower Deck

O

PERATOR’S

M

ANUAL

IMPORTANT: READ SAFETY RULES AND INSTRUCTIONS CAREFULLY

Troy-Bilt LLC, P.O. BOX 361131 CLEVELAND, OHIO 44136-0019

PRINTED IN U.S.A.

Warning:

This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-

covered, brush-covered or grass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting
applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator.
In the State of California the above is required by law (Section 4442 of the California Public Resources Code). Other states may have
similar laws. Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized
service dealer or contact the service department, P.O. Box 361131 Cleveland, Ohio 44136-0019.

FORM NO. 769-02165D

ZERO TURN TRACTOR

Model Number

(1/07)

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Other Manuals for Troy-Bilt RZT 50

Summary

Page 2 - TRACTOR PREPARATION; INSTALL THE OPERATOR’S SEAT; The seat is partially inserted into the slots of the; Figure 1; TABLE OF CONTENTS

2 TRACTOR PREPARATION Remove the upper crating material from the shippingpallet, and cut any bands or tie straps securing the trac-tor to the pallet. Use the lift handle to raise the deck to its highest posi-tion; engage the transmission bypass rods (Refer toSECTION 1, CONTROLS AND FEATURES); and ca...

Page 3 - Spacer

3 • Slide the flat washer onto the hex screw. From the outside , insert the hex screw w/washer through the control lever slot and the hole of the pivot bracket. Secure with the flange lock nut. See Figure 2. Figure 2 • Note the relative position of the control lever to the pivot bracket, then repeat...

Page 4 - WARNING; IMPORTANT; HEED ITS WARNING; SAFE OPERATION PRACTICES; GENERAL OPERATION; Never carry passengers.; DANGER

4 WARNING • The engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals knownto the State of California to cause cancer, birth defects or other reproductive harm. • This unit is equipped with an internal combustion engine and should not be used on or near a...

Other Troy-Bilt Models

All Troy-Bilt Other