Troy-Bilt 630C - Manual

Troy-Bilt 630C

Troy-Bilt 630C – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
Page: / 23

Table of Contents:

  • Page 3 – Safety Alert Symbol; WARNING
  • Page 4 – Maintenance and Storage
  • Page 5 – Decals; TO AVOID SERIOUS INJURY:; Operating Symbols
  • Page 6 – STEP 1: UNPACKING INSTRUCTIONS; Loose Parts List; Description; STEP 2: ATTACH HANDLEBAR; to the outside of; to the outside; STEP 3: MOVE TILLER OFF CRATE
  • Page 9 – FF
  • Page 10 – INTRODUCTION; ENGINE CONTROLS; SECTION 3: FEATURES AND CONTROLS
  • Page 11 – FORWARD CLUTCH BAIL
  • Page 12 – Starting the Engine; SECTION 4: OPERATION
  • Page 13 – OPERATING THE TILLER; Do not till while in
  • Page 14 – TILLING TIPS & TECHNIQUES
  • Page 15 – Tilling On Slopes; Read the following recommendations before tilling on slopes:; Tilling Up and Down Slopes (Vertical Tilling); Power Composting
  • Page 16 – Clearing the Tines
  • Page 17 – MAINTENANCE SCHEDULE; PROCEDURE; TILLER LUBRICATION; CHECK HARDWARE; CHECK FOR OIL LEAKS; SECTION 5: MAINTENANCE
  • Page 18 – BOLO TINES
  • Page 19 – Replacement Belt Information
  • Page 20 – ENGINE CLEANING; A B
  • Page 22 – TROUBLESHOOTING; PROBLEM
  • Page 23 – TROY-BILT TILLER LIFETIME LIMITED WARRANTY
Loading the manual

Rear-tine Tiller Models

630C—Tuffy

®

634F—Bronco

TM

634A—Super Bronco

TM

Model 634A Shown

Operator’s Manual

PRINTED IN U.S.A.

770-10594D.fm

11/19/03

FORM NO.

IMPORTANT: Read safety rules and instructions carefully before operating equipment.

Warning:

This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-covered, brush-

covered or grass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if
any). If a spark arrester is used, it should be maintained in effective working order by the operator. In the State of California the above is required
by law (Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands. A spark
arrester for the muffler is available through your nearest engine authorized service dealer or contact the service department, P.O. Box 361131
Cleveland, Ohio 44136-0019.

Troy-Bilt LLC, P.O. BOX 361131 CLEVELAND, OHIO 44136-0019

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 3 - Safety Alert Symbol; WARNING

3 Training 1. Carefully read this Own- er’s Manual, the separate Engine Owner’s Manual, and any other literature you may receive. Be thoroughly familiar with the controls and the proper use of the tiller and its en-gine. Know how to stop the unit and disen-gage the controls quickly. 2. Never allow c...

Page 4 - Maintenance and Storage

4 4 . Exercise caution to avoid slipping or fall- ing. 5 . If the unit should start to vibrate abnor- mally, stop the engine, disconnect the spark plug wire and prevent it from touch-ing the spark plug, and check immediately for the cause. Vibration is generally a warning of trouble. 6 . Stop the en...

Page 5 - Decals; TO AVOID SERIOUS INJURY:; Operating Symbols

5 Decals For your safety and the safety of others, vari-ous safety and operational decals are located on your unit (see Figure 1-2). Keep the decals clean and legible at all times. Contact your local service dealer or the factory for replacements if any decals are damaged or missing. Refer to the Pa...

Other Troy-Bilt Models

All Troy-Bilt Other