Trane YCZ035F1 - Manual
Trane YCZ035F1 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – GENERAL INFORMATION; IMPORTANT: Read this entire manual before; Check the unit’s nameplate to determine if the unit is correct; result in death or serious injury.; NOTICE
- Page 4 – DIMENSIONAL DATA; MODEL
- Page 7 – LOCATIONS AND RECOMMENDATIONS; HORIZONTAL AIRFLOW APPLICATION; PERSONAL INJURIES AND/OR DAMAGE TO EQUIPMENT; CLEARANCES
- Page 8 – INSTALLATION; UNIT SUPPORT
- Page 9 – PLACING THE UNIT ON A MOUNTING CURB
- Page 10 – TYPICAL ROOFTOP APPLICATION WITH FRAME
- Page 11 – TUBING AND FITTINGS; TYPICAL GROUND LEVEL APPLICATION
- Page 12 – ATTACHING HORIZONTAL DUCTWORK TO UNIT; NOTE: Do not draw the canvas taut between the solid ducts.; DUCTWORK; ATTACHING DOWNFLOW DUCTWORK TO ROOF CURB; This product contains; Avoid breathing fiberglass dust.; FIRST AID MEASURES; DOWNFLOW
- Page 13 – PIPE DELIVERY SCHEDULE; Furnace Input in BTUH; TABLE 1; GAS PIPING INSTALLATION; TABLE 2; GAS PRESSURE SETUP PRECAUTIONS
- Page 14 – MANIFOLD PRESSURE; GAS PIPING INSTALLATION; BURNER & VALVE ILLUSTRATION
- Page 15 – INPUT CHECK AND ADJUSTMENT; GAS FLOW IN CUBIC FEET PER HOUR; TABLE 3; HIGH ALTITUDE INSTALLATION
- Page 16 – ELECTRICAL WIRING; TABLE 4; WIRE SIZE; TABLE 5; THERMOSTAT WIRE SIZE AND MAXIMUM LENGTH; UNIT
- Page 17 – YCZ-F FIELD WIRING DIAGRAM
- Page 19 – SEQUENCE OF OPERATION; Call for 1st stage only:
- Page 20 – ICM FAN CONTROL
- Page 21 – TROUBLESHOOTING CHART; SYSTEM; CHECKOUT PROCEDURE; IGN LED DIAGNOSTIC INDICATOR
- Page 22 – MAINTENANCE; FLUE CLEANING; DO NOT OPERATE THE UNIT
- Page 23 – LIMITED WARRANTY; COMBINATION GAS ELECTRIC AIR CONDITIONER; Models Less Than 20 Tons for Residential Use*; failure to properly maintain; the combination gas
- Page 24 – Models Less Than 20 Tons for Commercial Use*
All phases of this installation must comply with the NATIONAL, STATE & LOCAL CODES. In the absence of local codes, the
installation must conform with National Electric Code -- ANSI/NFPA 70 or "LATEST REVISION."
Since Trane has a policy of continuous product and product data improvement,
it reserves the right to change design and specification without notice.
© 2002 American Standard Inc. All rights reserved
HAZARDOUS VOLTAGE - DISCONNECT POWER BEFORE SERVICING
WARNING:
INSTALLATION
OPERATION
MAINTENANCE
ALL phases of this installation must comply with
NATIONAL, STATE AND LOCAL CODES
IMPORTANT — This Document is customer property and is to remain with this unit. Please return to service information pack upon completion of work.
Single Package Two Stage
Gas/Electric 16 SEER
Convertible 3, 4, 5 Ton
Model:
YCZ036F1/3M0B, 4MOA
YCZ050F1/3HOA, 4H0A
YCZ060F1/3M0B, 4M0A
BAYLIFT002A
LIFTING LUG KIT
18-EB21D4-7
Library
Product Section
Product
Model
Literature Type
Sequence
Date
File No.
Supercedes
Service Literature
Unitary
Packaged Gas/Electric
YCZ
Installation, Operation, Maintenance
1F
December 2002
SV-UN-RT-YCZ-IOM-1F 12/02
New
YCZ-
IOM
-1F
12/02
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
Page 2 GENERAL INFORMATION IMPORTANT: Read this entire manual before beginning installation procedures. ▲ WARNING: BODILY INJURY CAN RESULT FROM HIGH VOLTAGE ELECTRICAL COMPONENTS, FAST MOVING FANS, AND COMBUSTIBLE GAS. FOR PROTECTION FROM THESE INHERENT HAZARDS DURING INSTALLATION AND SERVICING, TH...
Page 4 DIMENSIONAL DATA 3 YCZ036,050,060F OUTLINE – BACK MODEL CORNER WEIGHT (LBS) NET UNIT WEIGHT (LBS) A B C D E F G H J K L M N P W1 W2 W3 W4 YCZ036F 161 106 104 157 528 64 36 29-3/16 18-9/16 11-1/16 6-9/16 11-1/8 17 18-1/2 25-1/2 17-1/2 10 3 8-3/4 YCZ050F 172 121 137 196 626 65-1/8 45 33-3/8 21-...
Page 7 LOCATIONS AND RECOMMENDATIONS HORIZONTAL AIRFLOW APPLICATION 1. These units are design certified for outdoor installations. These units may be installed directly on wood flooring or on Class A,Class B, or Class C roof covering material. The discharge airfrom the condenser fans must be unrestr...
