Page 2 - Complete this page for quick reference when service is required:; Date of Installation:; Information found on the data label:; Voltage; 001 Carrier Commercial Refrigeration, Inc.; Taylor Company; a division of Carrier Commercial Refrigeration, Inc.
Complete this page for quick reference when service is required: Taylor Distributor: Address: Phone: Fax: E- mail: Service: Parts: Date of Installation: Information found on the data label: Model Number: Serial Number: Electrical Specs: Voltage Cycle Phase Maximum Fuse Size: A Minimum Wire Ampacity:...
Page 3 - Table of Contents
Table of Contents Models 345, 346, 349, 355 Table of Contents Section 1 To the Installer 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Air Cooled Units 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ...
Page 4 - Table of Contents - Page 2; During Cleaning and Sanitizing
Models 345, 346, 349, 355 Table of Contents Table of Contents - Page 2 Section 7 Important: Operator Checklist 38 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . During Cleaning and Sanitizing 38 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Troublesho...
Page 5 - To the Installer; Section 1; Installer Safety; Note: All repairs must be performed by an; Site Preparation; Air Cooled Units; NOT
1 Models 345, 346, 349, 355 To the Installer 131122 Section 1 To the Installer The following information has been included in the manual as safety and regulatory guidelines. For complete installation instructions, please see the Installation Checklist. Installer Safety In all areas of the world, equ...
Page 6 - FOLLOW YOUR LOCAL ELECTRICAL CODES!
2 Models 345, 346, 349, 355 To the Installer 120828 Water Cooled Refrigeration Units (Water Cooled Units Only) Failure to use adequate size water lines may cause the unit to go off on high head pressure and shut down. Depending on local water conditions, it may be advisable to install a water strain...
Page 8 - Syrup System Connections
4 Models 345, 346, 349, 355 To the Installer 131122 Use only R404A refrigerant that conforms to the AHRI standard 700 specification. The use of any other refrigerant may expose users and operators to unexpected safety hazards. Refrigerant liquid sprayed onto the skin may cause serious damage to tiss...
Page 11 - Compressor Warranty Disclaimer
7 Models 345, 346, 349, 355 To the Operator 131122 Section 2 To the Operator The freezer(s) you have purchased has been carefully engineered and manufactured to give you dependable operation. This unit(s), when properly operated and cared for, will produce a consistent quality product. Like all mech...
Page 14 - Operator Parts Identification; Section 4; Item
10 Models 345, 346, 349, 355 Operator Parts Identification Section 4 Operator Parts Identification 17 5 7 11 10 6 8 12 9 16 4 1 3 2 15 14 13 18 Model 345 Item Description Part No. 1 Panel A.-Side Left X45136 2 Hood 044618 3 Panel-Rear 044921-SP1 4 Panel A.-Side Right X44919 5 Caster-Swivel 3/4-10 St...
Page 18 - Door Assembly; ITEM
14 Models 345, 346, 349, 355 Operator Parts Identification 120828 Door Assembly ITEM DESCRIPTION PART NO. 1 DOOR 1a CAP-SPOUT-DOOR-FCB-BLK 046191-BLA 1b SPRING-COMP.480X.072X3.0 039320 1c VALVE-DRAW-DOOR-PRESS. 039324 1d O-RING-9/16 OD X .103W 016369 1e SPOUT-DOOR-FCB-BLACK 046190-BLA 1f HANDLE-DRAW...
Page 19 - Accessories
15 Models 345, 346, 349, 355 Operator Parts Identification Accessories KAY-5 Sanitizer/Cleaner ® CAUTION KEEP OUT OF REACH OF CHILDREN FOR INSTITUTIONAL USE ONLY 1 OZ (28.4 g) 2 1 3 4 5 8 7 6 048260 R ITEM DESCRIPTION PART NO. 1 PAIL-MIX 10 QT 013163 2 BRUSH-MIX PUMP BODY-3”X7” 023316 3 BRUSH-DOUBLE...
Page 20 - Important: To the Operator; Section 5; Symbol Definitions
16 Models 345, 346, 349, 355 Important: To the Operator Section 5 Important: To the Operator Figure 8 Item Description 1 Control Switch 2 Liquid Crystal Display 3 Keypad- Left 4 Keypad- Right 5 Product Light- Left Side 6 Product Light- Right Side Symbol Definitions To better communicate in the Inter...
Page 21 - Liquid Crystal Display; and water are satisfied.; Operator Menu Display; OPERATOR MENU; Operator Menu Timeout
17 Models 345, 346, 349, 355 Important: To the Operator Liquid Crystal Display The Liquid Crystal Display (LCD) is located on the front control panel. The LCD is used to show the current operating mode of the freezing cylinders. The LCD also indicates whether there is enough syrup, CO 2 , and water ...
Page 22 - Finding Current Fault Conditions; Fault Messages
18 Models 345, 346, 349, 355 Important: To the Operator 060801 Finding Current Fault Conditions Screen B is FAULT DESCRIPTION . The fault description will indicate if there is a fault in one of the freezing cylinders. When the actual fault is corrected, the warning tone will stop. Only items 9 and 1...
Page 26 - Syrup Out Indicator
22 Models 345, 346, 349, 355 Important: To the Operator 060522 DEFROST TIME RIGHTCYCLE 1 SUN 10:00 < - - - - - - > + + + - - - SEL Press the SEL key to return to the OPERATOR MENU. Screen F is CURRENT CONDITIONS. This screen displays the current viscosity and product temperature for each freez...
Page 28 - Assembly
24 Models 345, 346, 349, 355 Operating Procedures Section 6 Operating Procedures The Models 345, 346 and 355 contain two 7 quart (6.6 liter) freezing cylinders. The Model 349 contains four 7 quart (6.6 liter) freezing cylinders. CAUTION: This unit is pressurized when in operation. The control switch...
Page 30 - Operating Procedures
26 Models 345, 346, 349, 355 Operating Procedures Note: The scraper blades on the beater assembly should be in the 6 and 12 o’clock positions. This will enable freezer door installation. Figure 15 Step 3 Install the draw valve. Slide the two o-rings into the grooves on the draw valve. Lubricate the ...
Page 33 - Sanitizing; the sanitizer is completely dissolved.
29 Models 345, 346, 349, 355 Operating Procedures Step 9 Install the center drip pan through the front of the machine. Figure 30 Sanitizing Note: If a unit is sanitized, and will not be used for an extended period of time, clean water should be used to flush all sanitizer from the lines prior to sto...
Page 39 - 0 Day Closing Procedure; ALWAYS FOLLOW LOCAL HEALTH CODES; Draining Product From the; Repeat Steps 1 and 2; Cleaning; Important: Make sure the cleaner is completely
35 Models 345, 346, 349, 355 Operating Procedures Step 9 Replace the side panels and close the lighted display. Install the hood in position on top of the freezer. 90 Day Closing Procedure We recommend that the machine be completely disassembled and cleaned at least every ninety days using the follo...
Page 40 - Disassembly
36 Models 345, 346, 349, 355 Operating Procedures Step 6 Raise the prime plug. Place an empty pail under the door spout. When cleaning solution begins to exit the relief port opening in the freezer door, lower the prime plug. Press the OFF key. Open the draw valve and relieve all pressure from the f...
Page 42 - Important: Operator Checklist; Section 7; WE RECOMMEND CLEANING AND SANITIZING; Troubleshooting Bacterial Count; monthly
38 Models 345, 346, 349, 355 Important: Operator Checklist Section 7 Important: Operator Checklist During Cleaning and Sanitizing ALWAYS FOLLOW LOCAL HEALTH CODES Cleaning and sanitizing schedules are governed by your State or local regulatory agencies and must be followed accordingly. The following...
Page 43 - Winter Storage
39 Models 345, 346, 349, 355 Important: Operator Checklist Winter Storage If the place of business is to be closed during the winter months, it is important to protect the freezer by following certain precautions, particularly if the building is subject to freezing conditions. Disconnect the freezer...
Page 44 - Troubleshooting Guide; Section 8; PROBLEM
40 Models 345, 346, 349, 355 Troubleshooting Guide Section 8 Troubleshooting Guide PROBLEM PROBABLE CAUSE REMEDY PAGE REF. 1. Product is too stiff. a. Too much water to syrup ratio. Improper brix adjustment. a. Adjust the brix accordingly. 33 b. Consistency control needs adjustment. b. Contact a ser...
Page 46 - Parts Replacement Schedule; Section 9; PART DESCRIPTION
42 Models 345, 346, 349, 355 Parts Replacement Schedule Section 9 Parts Replacement Schedule PART DESCRIPTION EVERY 3 MONTHS EVERY 6 MONTHS ANNUALLY Scraper Blade X Minimum Drive Shaft Seal X Drive Shaft O-Ring X Freezer Door O-Ring X Draw Valve O-Ring X Door Spout O-Ring X Hopper Cover O-Ring X Fro...
Page 47 - Limited Warranty on Equipment
43 Models 345, 346, 349, 355 Limited Warranty on Equipment 131122 Section 10 Limited Warranty on Equipment TAYLOR COMPANY LIMITED WARRANTY ON FREEZERS Taylor Company, a division of Carrier Commercial Refrigeration, Inc. (“Taylor”) is pleased to provide this limited warranty on new Taylor-branded fre...
Page 49 - Limited Warranty on Parts; TAYLOR COMPANY LIMITED WARRANTY ON TAYLOR GENUINE PARTS; No warranty; LIMITED WARRANTY CONDITIONS; location in the unit of original installation.
45 Models 345, 346, 349, 355 Limited Warranty on Parts 131122 Section 11 Limited Warranty on Parts TAYLOR COMPANY LIMITED WARRANTY ON TAYLOR GENUINE PARTS Taylor Company, a division of Carrier Commercial Refrigeration, Inc. (“Taylor”) is pleased to provide this limited warranty on new Taylor genuine...
Page 51 - The owner; must
47 Models 345, 346, 349, 355 Limited Warranty on Parts LIMITATION OF WARRANTY THIS LIMITED WARRANTY IS EXCLUSIVE AND IS IN LIEU OF ALL OTHER WARRANTIES, CONDITIONS AND/OR REMEDIES UNDER THE LAW, INCLUDING ANY IMPLIED WARRANTIES OR CONDITIONS OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE. TH...
Page 52 - Parts List
Section 12 Parts List + Available Separately 48 Parts List Models 345, 346, 349 & 355 DE S CRI P T IO N PART NUM BE R 345 QTY . 346 QTY . 349 QTY . 355 QTY . W ARR. CL AS S RE M ARKS PART S UP DA T E Ac cu m ula to r A .- In su la te d X 50261 1 103 P rior to J9067375 144 +A cc umulator -S uc ti...
Page 72 - REMOTE
+ Available Separately 68 Parts List Models 345, 346, 349 & 355 DE S CRI P T IO N PART S UP DA T E RE M ARKS W ARR. CL AS S 355 QTY . 349 QTY . 346 QTY . 345 QTY . PART NUM BE R +V alv e- C hec k 030386 2 103 +V alv e- S olenoid 047496 - 2 103 V ideo -T ra in F ilm -F C B P res su re 046914 -V 1...
Page 73 - TER
69 + Available Separately Models 345, 346, 349 & 355 Parts List DE S CRI P T IO N PART NUM BE R 345 QTY . 346 QTY . 349 QTY . 355 QTY . W ARR. CL AS S RE M ARKS PART S UP DA T E C apac itor -R un 023606 1 103 C O P E LA N D - J9053838/ U p 142 C apac itor -S ta rt -145 -175U F /220V 012901 1 2 C...
