Swisher LS12534D, LS622, LS57525, LS928, LS11534 Manual

Page 2 - . Some states do not allow the limitation of; LIMITED WARRANTY; Engine Warranty

2 In the event you have a claim under this warranty, you must return the product to an authorized service dealer.All transportation charges, damage, or loss incurred during transportation of parts submitted for replacement orrepair under this warranty shall be borne by the purchaser. Should you have...

Page 3 - SAFETY PRECAUTIONS; Read the manual. Learn to operate this equipment in a safe manner.

SAFETY PRECAUTIONS WARNING: The engine exhaust from this product contains chemicals known to the state of California to cause cancer, birth defects or other reproductive harm. DANGER: Your log splitter was built to be operated according to the rules for safe operation in this manual. As with any typ...

Page 4 - IF injured by escaping fluid, see a doctor at once. Serious; When splitter is in the return mode, keep hands off the machine.

Fluid escaping from a very small hole can be almost invisible. Do not check for leaks with yourhand. Escaping fluid under pressure can have sufficient force to penetrate skin, causing seriouspersonal injury. Leaks can be located by passing a piece of cardboard or wood over the suspectedleak and look...

Page 5 - TOWING SAFETY

TOWING SAFETY • Do not allow persons to ride on splitter. Do not carry any cargo or wood on yoursplitter. It may fall off and endanger vehicles that are following you. • Be sure jack stand is in the travel position and coupling secure. This must also beretracted so not to interfere while towing. Ret...

Page 6 - OPERATION; ASSEMBLY INSTRUCTIONS

OPERATION Intended use: This log splitter is intended and designed to only split wood. NEVER use for any other purposes. Doing so can cause injury or VOID THE WARRANTY. ASSEMBLY INSTRUCTIONS This log splitter has been partially assembled at the factory. Refer to the drawings and partlists should it ...

Page 7 - to read warnings about coupling.

OPERATION FILLING THE HYDRAULIC RESERVOIR Fill the hydraulic reservoir with at least five gallons of Dextron III Automatic Transmission fluid or10W AW hydraulic fluid. After the hydraulic reservoir and the engine crankcase are filledcorrectly with their respective oils, start the engine. Remember to...

Page 8 - should always be on the lower side of the log splitter.; OPERATING POSITIONS; See your local engine dealer.; MAINTENANCE & STORAGE

OPERATION 1. Set up the log splitter in a clear, level area and block the wheels. The suction port on the tank should always be on the lower side of the log splitter. 2. Place a log on the beam, against the foot plate. Make sure the log is securely on the foot plate and up against the beam. 3. Depre...

Page 9 - REPAIR PARTS

Do not operate your splitter in poor mechanical condition or when needing repair. Repair andreplace worn or broken parts immediately. Periodically tighten nuts, bolts, and hydraulic fittings. The hydraulic system of your log splitter requires careful inspection, along with the mechanicalparts. Be su...

Page 10 - SAFETY DECALS; Replace decals immediately if damaged.

OD12 – HYDRAULIC FILL PLUG DECAL OD09 – DANGER/POSITION LOCK DECAL OD08 – OPERATOR INSTRUCTION DECAL OD16 – FUEL SHUT OFF DECAL OD07 – COLD WEATHER DECAL SAFETY DECALS Replace decals immediately if damaged. OD22 – POSITION LOCK DECAL OD23 – TOW POSITION DECAL 10

Page 11 - NOT ALL PARTS ARE ON ALL MODELS

ASSEMBLY DETAIL LS622, LS67525, LS928, LS11534 MODELS SEE DETAIL 1 2 3 B 4 5 6 7 8 9 10 A A 11 16 15 14 13 12 18 17 8 20 25 21 23 24 26 27 22 22 22 28 29 6 25 39 31 33 34 32 35 35 36 30 42 41 40 38 37 43 44 45 46 4748 49 50 42 16 51 55 18 52 54 53 52 58 57 56 49 6 5 SEE DETAIL NOT ALL PARTS ARE ON A...

Page 12 - SERVICE PARTS; Please have Model and Serial Numbers ready when ordering parts.

SERVICE PARTS Please have Model and Serial Numbers ready when ordering parts. Color cannot be guaranteed upon service parts. ITEM NUMBER DESCRIPTION PART NUMBER 1 RETURN HOSE 54" 7290 2 PRESSURE HOSE 48" 7289 3 #12 HOSE CLAMP LS5001 4 HYDRAULIC RESERVOIR 7319 5 1/2-13 X 3 1/2 GR5 BOLT NB577 ...

Page 15 - ENGINE DETAIL

ENGINE DETAIL LS622, LS67525 MODELS ITEM # DESCRIPTION PART # 89 ENGINE N/A 90 5/16-18 X 1 1/4 GR5 BOLT NB504 91 5/16-18 2-W AY LOCK NUT NB558 92 UPPER SPACER BB105SL 93 ENGINE PULLEY BB105 94 LOW ER SPACER BB105S 95 BELLEVILLE W ASHER 699 96 7/16-20 X 1 GR5 BOLT W / NYLOCK NB452N 106 KEYSTOCK 9031 ...

Page 16 - ASSEMBLY DETAIL

127 127 113 126 112 110 129 107 124 108 127 110 114 110 107 126 124 109 122 124 128 110 134 130 146 128 128 131 112 117 125 131 128 145 131 149 116 128 147 124 148 115 129 113 113 129 123 119 133 132 130 121 120 123 135 136 137 138 140 139 142 151 150 144 143 141 See Detail 152 153 154 155 156 157 1...

Page 19 - NOTES

19 NOTES : _________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________________...

Page 23 - SPECIFICATIONS

LS622 LS67525 LS928 LS11534 LS12534D Splitting Force 22 Tons 25 Tons 28 Tons 34 Tons 34 Tons Engine 6 Hp Briggs and Stratton Quantum 6.75 HP Briggs and Stratton 9 HP Briggs and Stratton I/C 11.5 HP Briggs and Stratton 12.5 HP Briggs and Stratton Splitting Positions Horizontal and Vertical Horizontal...

Page 24 - LOG SPLITTER

OWNER’S MANUAL MODEL NO.LS622LS67525LS928LS11534LS12534D HOW TO ORDERREPAIR PARTS : LOG SPLITTER Each Log Splitter has its own serial number. Each engine hasits own serial number. The serial number for the Log Splitterwill be found on the right hand side of the hydraulic oilreservoir. The serial num...