Page 3 - HERE'S HOW TO GET HELP; PLEASE HAVE THE MODEL AND SERIAL; © COPYRIGHT 2004, STOW CONSTRUCTION EQUIPMENT; To find the latest revision of this
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 3 HERE'S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING STOW MAIN OFFICE Post Office Box 6254 888-252-STOW Carson, Ca 90749 FAX: 310-537-1986 Email: [email protected]: www.sto...
Page 4 - TABLE OF CONTENTS; NOTE
PAGE 4 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) TABLE OF CONTENTS S p e c i f i c a t i o n a n d p a r t number are subject to change without notice . ROBIN EX270D20110Engine (EPA) Crankcase Assembly ......................................... 56-57Crankshaft, P...
Page 5 - PARTS ORDERING PROCEDURES; please supply the following information:; STOW CONSTRUCTION EQUIPMENT; Place Your Parts Order Via Web or Fax; Direct TOLL-FREE access
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 5 PARTS ORDERING PROCEDURES When ordering parts, please supply the following information: ❒ ❒ ❒ ❒ ❒ Dealer account number ❒ ❒ ❒ ❒ ❒ Dealer name and address ❒ ❒ ❒ ❒ ❒ Shipping address (if different than billing addr...
Page 6 - Figure 1. Dimensions
PAGE 6 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) STOW G-4.5R — DIMENSIONS Figure 1. Dimensions
Page 7 - Effects of Altitude and Heat; fahrenheit above the standard temperature of 60
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 7 STOW G-4.5R — SPECIFICATIONS Effects of Altitude and Heat The maximum output of the engine listed above is applicable to supplying electrical power for continuous service at ambientconditions in accordance with S...
Page 8 - STOW G-4.5R — SAFETY MESSAGE ALERT SYMBOLS; FOR YOUR SAFETY AND THE SAFETY OF OTHERS!
PAGE 8 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) STOW G-4.5R — SAFETY MESSAGE ALERT SYMBOLS Safety precautions should be followeda t a l l t i m e s w h e n o p e r a t i n g t h i se q u i p m e n t . Fa i l u r e t o r e a d a n dunderstand the Safety Messages...
Page 9 - STOW G-4.5R — SAFETY MESSAGE ALERT SYMBOLS; wear approved eye and
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 9 STOW G-4.5R — SAFETY MESSAGE ALERT SYMBOLS ALWAYS wear approved eye and hearing protection. NEVER operate equipment with covers, or guards removed. Keep fingers, hands,hair and clothing away from all movingparts ...
Page 10 - NEVER; disconnect any
PAGE 10 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) STOW G-4.5R — RULES FOR SAFE OPERATION The following safety guidelines should always be used whenoperating the STOW G-4.5R Portable Generator: GENERAL SAFETY ■ D O N OT o p e r a t e o r s e r v i c e t h i s equ...
Page 11 - be sure the operator is familiar with proper safety; leave the generator unattended, turn off engine when; change or adjust the engine speed which has been; Power Cord Safety; ALWAYS; store equipment properly when it is not being used.
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 11 STOW G-4.5R — RULES FOR SAFE OPERATION ■ ALWAYS be sure the operator is familiar with proper safety precautions and operation techniques before using generator. ■ NEVER leave the generator unattended, turn off e...
Page 12 - In emergencies; always
PAGE 12 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) STOW G-4.5R — RULES FOR SAFE OPERATION Backfeed to a utility system can cause electrocution and or property damage. NEVER connect the generator to a building's electrical system without atransfer switch or other ...
Page 13 - NOTE PAGE
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 13 NOTE PAGE
Page 14 - Machine Safety Decals; WARNING; DANGER; OPERATE AT
PAGE 14 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) OPERATION AND SAFETY DECALS (S/N 5498030 AND BELOW) Machine Safety Decals The G-4.5R portable generator is equipped with a number of safety decals (Figures 2A and 2B). These decals are provided foroperator safety...
Page 16 - General Inspection Prior to Operation; AC Voltmeter; To protect the generator from an overload,
PAGE 16 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) STOW G-4.5R — GENERAL INFORMATION STOW G-4.5R Familarization General Inspection Prior to Operation This generator has been thoroughly inspected and acceptedprior to shipment from the factory. However, be sure to ...
Page 17 - Extension Cables
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 17 Single Phase Load Always be sure to check the nameplate on the generatorand equipment to insure the wattage, amperage andfrequency requirements are satisfactorily supplied by thegenerator for operating the equip...
Page 18 - Figure 3A. Generator Controls and Components
PAGE 18 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) STOW G-4.5R — CONTROLS AND INDICATORS Figure 3A. Generator Controls and Components
Page 19 - When the full; power switch; volt position, the 240V receptacle cannot
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 19 STOW G-4.5R — CONTROLS AND INDICATORS 1 . Idle Control Switch – This unit is provided with an automatic idle control for noise suppression and reducedfuel consumption. The automatic idle control automaticallyeng...
Page 21 - Applies to units
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 21 STOW G-4.5R — CONTROLS AND INDICATORS 14 . Choke Lever – Used for starting the engine. Close the choke lever when starting a cold engine or in cold weatherconditions. The choke enriches the fuel mixture. Open th...
Page 22 - attempt to start; REMOVE; generator from truck; fire; or; explosion; due to static electricity.
PAGE 22 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) STOW G-4.5R — GENERATOR REFUELING Figure 4. Generator Refueling Adding fuel to the tank should be done only whenthe engine is stopped and has had an opportunityto cool down. In the event of a fuel spill, DO NOT a...
Page 25 - u s e p o w e r t o o l s o r
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 25 ) n o i t a r e p O e s a h P e l g n i S , z H 0 6 ( n o i t c e l e S e l b a C . 3 e l b a T n i t n e r r u C s e r e p m A s t t a W n I d a o L h t g n e L e l b a C e l b a w o ll A m u m i x a M s t l o ...
Page 26 - fill the tank beyond capacity.
PAGE 26 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) STOW G-4.5R — PRE-INSPECTION (ENGINE) Figure 7. Engine Oil Dipstick (Removal) 3. Insert and remove the dipstick without screwing it into the filler neck. Check the oil level shown on the dipstick. 4. If the oil l...
Page 27 - O NOT; release the starter knob after pulling. Allow it to
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 27 STOW G-4.5R — INITIAL START-UP (ENGINE) DO NOT attempt to operate this generator until the Safety, General Information and Inspectionsections of this manual have been read and thoroughly understood . This sectio...
Page 30 - Generator Storage; Clean all external parts of the generating set with a cloth.
PAGE 30 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) STOW G-4.5R — PREPARATION FOR LONG -TERM STORAGE Generator Storage For storage of the generating set for over 30 days, thefollowing is required: ■ Drain the fuel tank completely, or add STA-BIL to the fuel. ■ Run...
Page 33 - Cleaning the Fuel Strainer
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 33 STOW G-4.5R — MAINTENANCE (ENGINE) Maintenance Perform the scheduled maintenance procedures as defined byTable 6 and below: DAILY ■ Thoroughly remove dirt and oil from the engine and controlarea. Clean or replac...
Page 40 - Items Found In the “Remarks” Column; Items Found In the “Items Number” Column; All parts with same symbol in the number column,; STOW G-4.5R — EXPLANATION OF CODE IN REMARKS COLUMN
PAGE 40 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) How to read the marks and remarks used in this partsbook. Items Found In the “Remarks” Column Serial Numbers-Where indicated, this indicates a serialnumber range (inclusive) where a particular part is used. Model...
Page 41 - Description
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 41 G-4.5R 1 TO 3 UNITS WITH ROBIN EX270D20110 ENGINE 1 to 3 Units Qty. P/N Description 1 ............ 0810106004 .......... CAP, FUEL TANK, S/N 5498030 AND BELOW1 ............ A9924800014 ........ CAP, FUEL TANK, S...
Page 45 - DECAL WARNING READ MANUAL
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 45 STOW G-4.5R — NAME PLATE AND DECALS (S/N 5498030 AND ABOVE) NAMEPLATE AND DECALS (S/N 5498031 AND ABOVE) NO. PART NO. PART NAME QTY. REMARKS 1 A4511200402 DECAL; CONTROL PANEL ......................................
Page 58 - CRANKSHAFT AND PISTON ASSY.
PAGE 58 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) ROBIN EX270D20110 — CRANKSHAFT AND PISTON ASSY. CRANKSHAFT AND PISTON ASSY.
Page 62 - INTAKE AND EXHAUST ASSY.
PAGE 62 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) ROBIN EX270D20110 — INTAKE AND EXHAUST ASSY. INTAKE AND EXHAUST ASSY.
Page 65 - BODY CP
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 65 ROBIN EX270D20110 — AIR CLEANER ASSY. AIR CLEANER ASSY. NO. PART NO. PART NAME QTY. REMARKS 510 2793262030 AIR CLEANER ASSY. LOW PROFILE ................. 1 ......... INCLUDES ITEMS W/ * 510-200 * 2793263308 BOD...
Page 66 - COOLING STARTING ASSY.
PAGE 66 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) ROBIN EX270D20110 — COOLING STARTING ASSY. COOLING STARTING ASSY.
Page 71 - FLYWHEEL CP
STOW G-4.5R A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #3 (03/13/06) — PAGE 71 ROBIN EX270D20110 — FLYWHEEL ASSY. FLYWHEEL ASSY. NO PART NO PART NAME QTY. REMARKS 10 2797923001 FLYWHEEL CP 1 11 2797943001 IGNITION COIL CP 1 30 0011406250 BOLT & WASHER ASSY. 2 50 27773102H1 WIRE 2 CP, W...
Page 72 - ELECTRIC DEVICE ASSY.
PAGE 72 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) ROBIN EX270D20110 — ELECTRIC DEVICE ASSY. ELECTRIC DEVICE ASSY.
Page 74 - TERMS AND CONDITIONS OF SALE — PARTS; Terms and Conditions of Sale
PAGE 74 — STOW G-4.5R A.C. GENERATOR— OPERATION & PARTS MANUAL — REV. #3 (03/13/06) Effective: July 15, 2003 TERMS AND CONDITIONS OF SALE — PARTS Terms and Conditions of Sale STOW Construction Equipment STOW CONSTRUCTION EQUIPMENT POST OFFICE BOX 6254CARSON, CALIFORNIA 90749310-661-4242 • 877-BU...
Page 76 - OPERATION AND PARTS MANUAL; PARTS DEPARTMENT
Manufactured for MULTIQUIP INC.byDENYO MANUFACTURING CO., JAPAN PARTS DEPARTMENT: 800-427-1244FAX: 800-672-7877 SERVICE DEPARTMENT/TECHNICAL ASSISTANCE: 800-478-1244FAX: 310-631-5032 STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT STOW CONSTRUCTION EQUIPMENT STOW ...
