SoleusAir SG-WAC-25ESE - Manual

Page 3 - all the operational aspects of your new air conditioner.; IMPORTANT SAFETY INSTRUCTIONS

Thank you for choosing a Soleus Air powered by Gree Air Conditioner. This owner’s manual will provide you with valuable information necessary for the proper care and maintenance of your new product. Please take a few moments to thoroughly read the instructions and familiarize yourself with all the o...

Page 4 - Recommended Ground Method; ELECTRICAL REQUIREMENTS; It is the customer’s responsibility:

Wiring Requirement Recommended Ground Method For your personal safety, this air conditioner must be grounded. This air conditioner is equipped with a 3 prong power supply cord with a grounded plug. To minimize the possibility of electrical shock, the cord must be plugged into a 3 prong outlet and gr...

Page 5 - PARTS LIST; TOOLS NEEDED; Non-Hardware Packing List

PARTS LIST ( on 2 5ESE models ) SEAL-BOTTOM RAIL TO UNIT SIDE RETAINER FRAME ASSEMBLY (LEFT) WASHER HEADLOCKING SCREW FOAM GASKET TOP ANGLE FRAME ASSEMBLY ( RIGHT ) SAFETY LOCK AND3/4" ROUND-HEAD SCREW 1/2" LONG SCREWS AND LOCKNUTS LOCKNUT 3/4" LONG FLAT HEAD BOLT WINDOW SUPPORT BRACKET ...

Page 6 - SPECIFICATIONS; Refrigerant Charge (Oz) 28.22

SPECIFICATIONS • Noise level is measured at a distance of 3.28 ft away from the front of the unit in cooling mode. • Power consumption is measured when the fan runs at the highest speed setting. • These specifications are for reference only. For actual data, please refer to the rating label on the u...

Page 7 - INSTALLATION & ASSEMBLY INSTRUCTIONS; Window Preparation; Model

INSTALLATION & ASSEMBLY INSTRUCTIONS Window Preparation Please read all instructions prior to installing your air conditioner. Two people are recommended to install this product. If a new electrical outlet is required, have the outlet installed by a qualified electrician before installing the un...

Page 8 - INSTALLATION & ASSEMBLY INSTRUCTIONS - WINDOW MOUNTING; REMOVE CHASSIS

INSTALLATION & ASSEMBLY INSTRUCTIONS - WINDOW MOUNTING REMOVE CHASSIS 1. Pull down the front panel and remove the filter (FIG. 1 below) 2. Lift the front panel upwards to remove and place to the side. 3. Locate the four faceplate screws and remove. These screws will need to be re-installed prior...

Page 9 - Foam Gasket and Top; Top Angle Rail and Side Bracket Installation; Install side retainer to cabinet as shown in; insert; Placing the Cabinet Inside the Window

ASSEMBLY & INSTALLATION (CONT.) 8 4. Install top angle side to cabinet as shown in FIG. 7. 5. Slide "I" section of window filler panel into side retainer. Do both sides. WINDOW FILLER PANEL WINDOW FILLER PANEL SIDE RETAINER SIDE RETAINER FIG. 8a FIG. 7 Foam Gasket and Top Angle Rail Top ...

Page 10 - Extend the Accordion Panels; Set a locking screw on both sides of the curtain as shown.; Install the Window Lock and Sash Seal

ASSEMBLY & INSTALLATION (CONT.) 9 Install Support Brackets 1. Hold each support bracket flush against the outside of the window sill. Tighten each bracket to the bottom of the cabinet as shown below. Mark the brackets at top lever of the window sill and then remove. 2. Assemble the sill angle br...

Page 11 - IMPORTANT; Prepare the Wall; Max Wall

ASSEMBLY & INSTALLATION (CONT.) 10 Installing the Chassis into the Cabinet 1. Team lift (two people) the air conditioner chassis and carefully slide it into the cabinet. Let the front of the air conditioner hang out approximately 6”. 2. DO NOT PUSH ON THE CONTROLS OR FINNED COILS. 3. Be sure the...

Page 12 - NOTE; Prepare and Install the Cabinet; Inside Frame

ASSEMBLY & INSTALLATION - THRU-THE-WALL (CONT.) 11 Carefully measure and cut an opening with the following dimensions depending on your model (FIG. 1 & 2). WIDTH “X” = inside model plus twice the thickness of the framing material used. HEIGHT “Y” = inside model height plus twice the thicknes...

Page 13 - MASONRY CONSTRUCTION; Wooden Strip

ASSEMBLY & INSTALLATION - THRU-THE-WALL (CONT.) 12 Refer to the SUPPORT BRACKET ASSEMBLY in the WINDOW MOUNTING section to assemble the support brackets. A wooden strip nailed to the outside wall should be used in conjunction with the angled sill support brack- ets. 5. Screw or nail the cabinet ...

Page 14 - USING YOUR AIR CONDITIONER; Electronic Control Panel & Remote Control; Normal Operating Sounds

13 USING YOUR AIR CONDITIONER Electronic Control Panel & Remote Control 1. Power Button: Turns the air conditioner on and off 2. Digital Display: Displays the current room tem- perature or the amount of time left on the timer. Shows the Set Temp when setting the tempera- ture. Shows the Timer Se...

Page 16 - CARE AND CLEANING; Air Filter Cleaning

15 CARE AND CLEANING Clean your air conditioner to keep it looking new and to minimize dust build up. Air Filter Cleaning The air filter should be checked at least once every month to see if it needs cleaning. Trapped particles and dust can build up in the filter and may decrease airflow as well as ...

Page 17 - TROUBLESHOOTING; The Air Conditioner is freezing up

PROBLEM The Air Conditioner will not start POSSIBLE CAUSES The air conditioner is unplugged The fuse is blown/circuit breaker is tripped. Power Failure The current interrupter device is tripped. SOLUTIONS • Make sure the air conditioner is plug is pushed completely into the outlet • Check the house ...

Page 18 - PROBLEM; Water is dripping outside; POSSIBLE CAUSES; Water collects in the base pan

PROBLEM Water is dripping outside POSSIBLE CAUSES Hot and Humid weather. SOLUTIONS • This is normal TROUBLESHOOTING (CONT.) Water is dripping inside the room The air conditioner is not correctly tilted outside. • For proper water drainage, make sure the air conditioner is slightly tilted downward fr...

Page 19 - WARRANTY; THIS WARRANTY DOES NOT COVER:

WARRANTY One Year Limited Warranty Soleus International, Inc. warrants the accompanying Soleus Air Powered by Gree Air Conditioner to be free of defects in material and workmanship for the applications specified in its operation instruction for a period of ONE (1) year from the date of original reta...

SoleusAir SG-WAC-25ESE - Manual

Table of Contents:

Summary

Other SoleusAir Models