SoleusAir KC-30H / KC-35H- User Manual

Page 2 - TABLE OF CONTENTS; OPERATING CONTROLS............................................................................................14; This mark indicates a direction/procedure that must be followed!

TABLE OF CONTENTS INTRODUCTION……………………………..…………………………………….…................................1 SAFETY INFORMATION………………………………………………....…………........…..……......….1 NORMAL CARE AND MAINTENANCE……………………………………………….…..………….…3 INSTALLATION REQUIREMENTS………………………………………………..……….……….....…5 ELECTRICAL REQUIREMENTS...

Page 3 - Introduction; Operating Controls; NOTE; Safety Information; RECOGNIZE THIS SYMBOL AS A SAFETY PRECAUTION.

1 Introduction Room air conditioners cool, dehumidify, and filter air inside your home. Heat pump and electric heat models offer both heating and cooling. Opening sections of manual provide general information for all room air conditioner models. Operating Controls section describes operation of con...

Page 4 - Electrical Requirements; Grounding Instructions; WARNING; Unpacking; WARNING

2 OWNER'S PRODUCT IDENTIFICATION MODEL NUMBER SERIAL NUMBER MANUFACTURING NUMBER Owner's Name Address City State Zip / / Date of Purchase Authorized Dealer Address City State Zip ( ) Phone Number To avoid death, personal injury or propertydamage due to electrical shock: • Observe all local codes and...

Page 5 - Installation; Unit with a window mounting kit; Room Heat Pumps; CAUTION; Annual Inspection

3 NEMA No. 5-15P NEMA No. 5-15R 125V-15AMP 115V NEMA No. 6-15P NEMA No. 6-15R 250V-15AMP 230/208V ratedat 12 amperes orless NEMA No. 6-20P NEMA No. 6-20R 250V-20AMP 230/208V ratedover 12 amperes,but not more than16 amperes NEMA No. 6-30P NEMA No. 6-30R 250V-30AMP 208V rated over16 amperes, butnot mo...

Page 7 - INSTALLATION REQUIREMENTS; Tools and Parts; Tools Needed; Location Requirements; IMPORTANT SAFETY INSTRUCTIONS

5 INSTALLATION REQUIREMENTS Tools and Parts Gather the required tools and parts before starting installation. Read and follow the instructions provided with any tools listed here. Tools Needed Through-the-wall installation: In addition to the tools listed above, the following tools are needed for th...

Page 8 - Window installation

6 Window installation Window opening measurements: ■ 27" min. to 39" max. (68.6 cm to 99 cm) opening width. ■ 16 ¹⁄₄ " min. (41.3 cm) opening height. Through-the-wall installation The wall opening measurements should be: ■ Height: 16" (40.6 cm) plus twice the thickness of wood used t...

Page 9 - Recommended grounding method; Power Supply Cord; To test your power supply cord:

7 Recommended grounding method This air conditioner must be grounded. This air conditioner is equipped with a power supply cord having a grounded 3 prong plug. To minimize possible shock hazard, the cord must be plugged into a mating, grounded 3 prong outlet, grounded in accordance with all local co...

Page 10 - INSTALLATION INSTRUCTIONS; Remove packaging materials

8 INSTALLATION INSTRUCTIONS Unpacking Remove packaging materials ■ Remove and dispose of/recycle all packaging materials. Remove tape and glue residue from surfaces before turning on the air conditioner. Rub a small amount of liquid dish soap over the adhesive with your fingers. Wipe with warm water...

Page 12 - Attach Side Curtains to Window Frame; Front View

10 4. Use a ³⁄₁₆ " drill bit to drill 3 starter holes 1/2" deep through the 3 holes in the cabinet and into the windowsill. 5. Attach cabinet to windowsill with 3 - #10 x 1/2" pan-head Phillips screws. 6. Check that air conditioner cabinet is tilted 1 / 2 bubble on carpenters level to th...

Page 13 - Install Cabinet into Wood Frame

11 Option 1—Wood, metal or plastic molding When you are using wood, metal or plastic molding, the wood frame should line up with inside wall as shown. Option 2—Plastered wall with no molding If the plastered wall is to be flush with the cabinet and no molding is used, the wood frame must be set ¹⁄₂ ...

Page 14 - Complete Installation

12 Complete Installation NOTE: Handle air conditioner gently. 1. Make sure the free end of the ground wire is outside of the cabinet. 2. Insert air conditioner into cabinet. REMEMBER: Make sure the free end of the ground wire is outside of the cabinet. 3. Connect green ground wire to cabinet base wi...

Page 15 - General Operating Instructions; only

1 3 General Operating Instructions While operation of all units is similar, controls vary slightlyfrom model to model. Operating Controls section shows control panel of unit purchased and gives detailed informationabout operation of controls. Airflow Around Unit Select the highest fan speed and set ...

Page 16 - COMFORT ZONE; AND HEAT PUMP MODELS

Fan Control OFF – Completely shuts off the unit. To prevent blowingfuses, wait two minutes after turning the unit off beforeturning it on again. LOW COOL – Filters and circulates room air with the fanrunning continuously on low speed. Also cools and dehu-midifies while the compressor is running. Sel...

Page 17 - Before Calling Service; If the problem cannot be fixed using the suggested remedies, see; When Service Is Required; An accurate description of problem.; CONSUMER INFORMATION LINE; (Technical Support and Warranty Service)

15 Before Calling Service The following is a list of problems that are sometimes encountered when using a room air conditioner. Possible cause and suggested remedies are given for each problem. If the problem cannot be fixed using the suggested remedies, see WHEN SERVICE IS REQUIRED section. PROBLEM...

Page 18 - Thru-wall Installation Instructions; for; Air Conditioner Dimensions; General Instructions; All; A finished opening 2

16 22 3 / 5 '' 21 1 / 3 '' 5 4 / 5 '' 15 3 / 8 '' Thru-wall Installation Instructions for GREE ® brand Room Air Conditioner Introduction This instruction sheet provides guidelines for installing acompact air conditioner through an outside wall. Installing an air conditioner through a wallrequires ex...

Page 19 - Dimensions of Finished Opening; Masonry Construction; Brick Veneer or Frame Wall Construction.; See CAUTION under General Instructions.; Framing; Framed/Finished Opening; Placement of Outer Case in Opening; Installed Case

17 15 9 / 16 " Electrical outlet must be located within 5-feetof this point. 22 13 / 16 " Dimensions of Finished Opening Masonry Construction See CAUTION under General Instructions. In masonry walls, cut or build a finished opening 15 9 / 16 -inches high by 22 13 / 16 -inches wide. When case...

Page 20 - Chamfering Walls Thicker Than

18 Installation in Wall Thicker Than 5 ½inches The side louvers in outer case provide ventilation to air con-ditioner compressor and fan motor and must not beblocked. When installing unit in a wall over 5 1 / 2 -inches thick, provisions must be made in wall opening to ensurefree air flow to the side...

Page 21 - Specifications

19 Specifications Model KC-30H KC-35H Cooling Capacity (BTU/HR) 9500/9700 11400/11600 Heating Capacity (BTU/HR) 8300/8500 10100/10500 Electric Heat (BTU/HR) 8500/10700 8500/10700 Rated Voltage 208/230V~ 208/230V~ Rated Frequency 60Hz 60Hz Design Pressure Lowside 150 P.S.I. 150 P.S.I. Design Pressure...

Page 22 - Warranty; YEARS FOR COMPRESSOR

20 Warranty Soleus International Inc. warrants the accompanying Soleus Air 10000 / 12000BTU Heat Pump Room Air Conditioner (KC-30H / KC-35H) to be free of defects in material and workmanship for the applications specified in its operation instruction for the period of parts specified below. 5 YEARS ...

SoleusAir KC-30H / KC-35H- User Manual

Table of Contents:

Other Manuals for SoleusAir KC-30H / KC-35H

Summary

Other SoleusAir Models