Samsung AW-1407B - User Manual
Samsung AW-1407B Air Conditioner – User Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Samsung Electronics; -2-2 Replacing and refilling the refrigerant oil
- Page 3 – -3 Disassemby and Reassembly Procedure; Part name
- Page 4 – Disassembly and Reassembly
4-1
Samsung Electronics
4. Disassembly and Reassembly
4-1 Compressor Replacement Flow Chart
Locate cause of defect
Plug disconnected lines
Solder discharge line
Check refrigerant oil level
Add oil as necessary
Corrective action
Inspect electrical
wiring for defects,
and terminals for
correct and secure
connections
Solder suction line
Use nitrogen gas
Perform soldering function
Release refrigerant
Disconnect electrical
wiring from compressor
Replace compressor
Cut refrigerant lines
from compressor
Release nitrogen gas?
Pinch and braze filling tube
Fill system with nitrogen gas
Check for leakage
Evacuate system
Recharge system
Y
Y
Y
N
N
N
Problem?
Leakage?
Low oil level?
AW-1407-‡»¿º 1 98.6.27 11:2 AM ˘
`
9
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
Samsung Electronics 4-2 4-2 Checking the Oil 4-2-1 Oil quality 4-2-2 Replacing and refilling the refrigerant oil Refrigerant Cycle Normal Over-heated Compressor damage 1. Replacing the compressor-Do not fill the system with oil as the compressor is already charged.2. Replacing the condenser - Refill...
4-3 Samsung Electronics 4-3 Disassemby and Reassembly Procedure Stop operating the air conditioner, and pull out the power cord before repair. No. Part name Procedures Remarks Ass'y Grille Ass'y Cabinet Ass'y Control 1. Hold the lower part of the front grille with two hands while pressing down on bo...
Samsung Electronics 4-4 Disassembly and Reassembly No. Part name Procedures Remarks ¤Œ ¤º ¤ Plate-Cover Ass'y-Evaporator Plate-Evap Casing 1. Remove 11 screws on the plate cover. 1. Remove two screws on the left side of the evaporator. 1. Lift up the evaporator, and remove the tray-drain. 2. Remove ...
