Renogy Wanderer 30A User Manual

Page 2 - Important Safety Instructions; Please save these instructions.

01 General Safety Information Charge Controller Safety This manual contains important safety, installation, and operating instructions for the charge controller. The following symbols are used throughout the manual: There are no serviceable parts for this controller. Do NOT disassemble or attempt to...

Page 4 - Table of Contents

03 Table of Contents General Information 04 Identification of Parts 07 Installation 07 Mounting Recommendations 07 Operation 10 System Status Troubleshooting 11 Battery Charging Parameters 13 Maintenance 12 Fusing 12 Technical Specifications 13 Dimensions 14 Optional Components 06 LED Indicators 10 ...

Page 5 - General Information; prevent damage from installation mistakes or system faults.; Key Features

04 General Information Negative ground controllerMultiple LED indicators for easy to read charge status and battery information . Remote temperature compensation compatible (accessory sold separately)Integrated communication port for remote monitoring.Charges over-discharged lithium batteries. The W...

Page 6 - Wh e n the battery has charged to the Boost voltage set-point, it

05 Float Charge: After Boost Charge, the controller will reduce the battery voltage to a float voltage set point. Once the battery is fully charged, there will be no more chemical reactions and all the charge current would turn into heat or gas. Because of this, the charge controller will reduce the...

Page 7 - Optional Components; Lithium Battery Activation

06 Optional Components Lithium Battery Activation The Wanderer PWM charge controller has a reactivation feature to awaken a sleeping lithium battery. The protection circuit of lithium battery will typically turn the battery off and make it unusable if over-discharged. This can happen when storing a ...

Page 10 - Bluetooth Module Communication (optional)

09 Temperature Sensor (optional, not polarity sensitive) Bluetooth Module Communication (optional) Place the sensor close to the battery

Page 11 - Setting Battery Type

10 Operation LED Indicators Simply hold the gray button for approximately 7 seconds until the LED flashes. Once flashing, then press the gray button again to the desired battery type (they are color coded) and simply leave the controller alone until the flashing stops (this should take approximately...

Page 12 - System Status Troubleshooting; Description

11 System Status Troubleshooting Description Troubleshoot Other Considerations Use a multi-meter to verify the rated battery voltage. Disconnect any loads connected to the battery to allow it to charge. Use a multi-meter to check the voltage of the battery. Make sure the battery voltage is not excee...

Page 13 - AWG; NEC Maximum Current for different Copper Wire Sizes

12 Maintenance Fusing 1. Check that controller is mounted in a clean, dry, and ventilated area. 2. Check wiring going into the charge controller and make sure there is no wire damage or wear. 3. Tighten all terminals and inspect any loose, broken, or burnt up connections. For best controller perform...

Page 14 - Technical Specifications; •Reorient or relocate the receiving antenna.

13 Technical Specifications Description Nominal system voltage 30A Parameter Rated Charge Current 12 VDC ≤10mA Max. PV Input Voltage 25 VDC -3mV/°C/2V 10mm 8 AWG -35°C to +45°C / -20°F to 113°F 0.29 kg 0.65 lb. RS232 IP20 163.8 x 109.6 x 44.7mm 6.5 x 4.3 x 1.8in Electrical Specifications Self-Consum...

Page 15 - Dimensions; Battery Charging Parameters; hours

14 Dimensions Battery Charging Parameters Battery Type GEL FLOODED Over-voltage Warning 16 V 16 V Charging Limit VoltageOver-voltage Recover 15.5 V 15.5 V Boost Charge VoltageFloat Charge Voltage Boost Return Voltage Over-discharge Recover Equalization Voltage ----- ----- ----- ----- ----- 14.8 V 14...

Page 16 - US

Renogy reserves the right to change the contents of this manual without notice. RENOGY.COM US 2775 E Philadelphia St, Ontario, CA 91761, USA909-287-7111 www.renogy.com [email protected] https://www.renogy.cn [email protected] CN 400-6636-695 苏州高新区科技城培源路1号5号楼-4 CA https://ca.renogy.com supportca@ren...

Renogy Wanderer 30A - User Manual

Table of Contents:

Was this manual helpful?

About this manual

Summary

Ask a question