ProCom MD100TBA - Manual
ProCom MD100TBA – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Care and; TABLE OF CONTENTS
- Page 3 – PRODUCT SPECIFICATIONS
- Page 5 – CARBON MONOXIDE POISONING:; Make sure grill guard is in place before running heater.; IMPORTANT SAFETY INFORMATION
- Page 6 – QUALIFIED INSTALLING AGENCY
- Page 8 – PREPARING FOR INSTALLATION; * A CSA design-certified equipment shutoff valve with; WATER VAPOR: A BY-PRODUCT OF UNVENTED ROOM HEATERS; atmosphere experienced during cold weather.; UNPACKING; Remove heater from carton.
- Page 9 – AIR FOR COMBUSTION AND VENTILATION; Providing Adequate Ventilation; Confined and Unconfined Space; defines a confined space as a space whose volume is less than; Unusually Tight Construction; Unusually tight construction is defined as construction where:
- Page 10 – DETERMINING FRESH-AIR FLOW FOR HEATER LOCATION; Determining if You Have a Confined or Unconfined Space; Compare the maximum
- Page 11 – Ventilation Air From lnside Building; of the floor on the wall connecting the two spaces; Ventilation Air From Outdoors; Provide extra fresh air by using ventilation grills or
- Page 12 – INSTALLATION; Check Gas Type; set directly on the floor.; LOCATING HEATER; For convenience and efficiency, install heater:
- Page 13 – Attaching to wall stud:; Marking Screw Locations; Wall anchors, mounting screws, and spacers are in hardware
- Page 15 – too small, undue loss of pressure will occur.; CONNECTING TO GAS SUPPLY; Typical Inlet Pipe Diameters; Use 3/8-inch black iron pipe or greater. Installation must include
- Page 16 – Continued; steel or metal hex plug with sealant.; For changing from propane to natural gas supply:; regulator use thread sealant to ensure that there are no leaks.; For changing from natural gas supply to propane supply:; thread sealant to assure there are no leaks.
- Page 17 – CHECKING GAS CONNECTIONS; Figure 17 - Equipment Shutoff Valve
- Page 18 – Pressure Testing Heater Gas Connections; Make sure control knob of heater is in the OFF position.; OPERATION; FOR YOUR SAFETY READ BEFORE LIGHTING; When lighting the pilot, follow these instructions exactly.
- Page 19 – LIGHTING INSTRUCTIONS; STOP! Read the safety information on the side of the heater.; THERMOSTAT CONTROL OPERATION; Shutting Off Heater; Shutting Off Burner Only (pilot stays lit ); Turn control knob clockwise
- Page 20 – to the OFF position.; TO TURN OFF GAS TO APPLIANCE; Turn control knob clockwise; SHUTTING OFF BURNER ONLY
- Page 21 – INSPECTING BURNER; Check pilot flame pattern and burner flame pattern often.; PILOT FLAME PATTERN; turn heater off (see “To Turn Off Gas to Appliance” on page 19); BURNER FLAME PATTERN; turn heater off (see “To Turn Off Gas to Appliance”
- Page 22 – CARE AND MAINTENANCE; Turn off heater and let cool before servicing; CLEANING BURNER PILOT AIR INLET HOLE; Use a vacuum cleaner or pressurized air to clean.; Exterior; Use a soft cloth dampened with a mild soap and water mixture.
- Page 23 – Care and; TROUBLESHOOTING
- Page 24 – PROBLEM; POSSIBLE CAUSE
- Page 25 – top of page 23.; REMEDY; Checking Gas Connections,
- Page 26 – ACCESSORIES; EQUIPMENT SHUTOFF VALVE; figure 1; REPLACEMENT PARTS; PARTS UNDER WARRANTY; Usually, we will ask you to return the defective part to the factory; PARTS NOT UNDER WARRANTY
CAUTION - FOR YOUR SAFETY
Vent-Free Gas Wall Heater
Blue Flame
WARNING:
This appliance is
equipped for (Natural and Propane)
gas. Field conversion is not permitted
other than between natural or
propane gases.
PC-MD100TBE-0902
Model # MD100TBA
MD200TBA
MD300TBA
MD100HBA
MD200HBA
MD300HBA
MD200TBA-BB
MD300TBA-BB
MD200HBA-BB
MD300HBA-BB
WARNING: IF THE INFORMATION IN THIS MANUAL IS NOT FOLLOWED
EXACTLY, A FIRE OR EXPLOSION MAY RESULT CAUSING PROPERTY
DAMAGE, PERSONAL INJURY, OR LOSS OF LIFE.
--
Do not store or use gasoline or other flammable vapors and liquids in vicinity
of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS
Do not try to light any appliance.
Do not touch any electrical switch; do not use any phone in your building.
Immediately call your gas supplier from a neighbor’s phone. Follow the
gas supplier’s instructions.
If you cannot reach your gas supplier, call the fire department.
-- Installation and service must be performed by a qualified installer, service
agency or the gas supplier.
This is an unvented gas-fired heater. It uses air (oxygen) from the room in which it is
installed. Provisions for adequate combustion and ventilation air must be provided.
Refer to
Air For Combustion and Ventilation section
on page 9 of this manual.
INSTALLER: DO NOT DISCARD THIS MANUAL – LEAVE FOR HOMEOWNER’S
FUTURE REFERENCE.
This appliance may be installed in an aftermarket, permanently located manufactured
(mobile) home, where not prohibited by local codes. This appliance is for use with
the type of gas indicated on the rating plate only. This appliance is not convertible for
use with other gases.
Questions about installation, operation, or troubleshooting?
Before returning to your
retailer, call customer service department toll-free at
(877)886-5989.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
TABLE OF CONTENTS Important Safety Information ..............................................................................................................................5 Product Features................................................................................................................
PRODUCT SPECIFICATIONS MODEL MD100TBA MD200TBA MD300TBA BTU (available) 10,000 20,000 30,000 Gas Type Using Natural Gas Using Natural Gas Using Natural Gas Pressure Regulator Setting 4 in. W.C. 4 in. W.C. 4 in. W.C. Inlet Gas Pressure* (inches of water) * For purposes of input adjustment. Maximum 10...
IMPORTANT SAFETY INFORMATION IMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, operate, or service this heater. Improper use of this heater can cause serious injury or death from burns, fire, explosion, electrical shock, and carbon monoxide poisoning. Only a qua...
