Page 2 - S A F E T Y G U I D E L I N E S; Pride Mobility Products Corp.
2 Jazzy 1120 2000 S A F E T Y G U I D E L I N E S Copyright © 2002 Pride Mobility Products Corp. INFMANU1445/B/JULY 2002 Please read and follow all instructions in this owners manual before attempting to operate your Please read and follow all instructions in this owners manual before attempting t...
Page 3 - C O N T E N T S
3 Jazzy 1120 2000 I. INTRODUCTION ......................................................................................................................... 4 II. SAFETY ......................................................................................................................................
Page 4 - I . I N T R O D U C T I O N; you attempt to operate your Jazzy for the first time.
4 Jazzy 1120 2000 I . I N T R O D U C T I O N Welcome to Pride Mobility Products Corporation (Pride). Congratulations on the purchase of your new Jazzy Power Chair. The Jazzy 1120 2000 design combines the most advanced state-of-the-art components with modern, attractive styling. We are certain that ...
Page 5 - Pride Owners Club; we will be glad to send you a new one immediately.
5 Jazzy 1120 2000 I . I N T R O D U C T I O N Pride Owners Club As an owner of a Pride product, you are invited to register your products warranty and enroll in the Pride Owners Club. You may do so by filling out and returning your enclosed registration card or by visiting Prides web site at www.p...
Page 6 - TRANSFERS; MOTOR VEHICLE TRANSPORT; WEIGHT LIMITATIONS
6 Jazzy 1120 2000 I I . S A F E T Y Your Jazzy 1120 2000 is a state-of-the-art, life-enhancement device designed to increase your mobility. There are certain situations, including some medical conditions, where you will need to practice operating your Jazzy in the presence of an attendant. Below are...
Page 7 - INCLINES AND UNEVEN TERRAIN; MAXIMUM RECOMMENDED INCLINE
7 Jazzy 1120 2000 I I . S A F E T Y PUBLIC ROADS AND PARKING LOTS It may be difficult for motorists to see you when you are seated on your Jazzy. To ensure your safety, always assume you cannot be seen. Wait until your path is clear of traffic, and then proceed with extreme caution. NOTE: Many munic...
Page 9 - Are all powered wheelchairs susceptible to EMI/RFI?; a strong radio source than one with a low immunity level.; What is the FDA doing about the problem?; manufacturers have these actions implemented by December 2, 1994.; What should I do if my powered wheelchair moves unexpectedly?
9 Jazzy 1120 2000 I I I . E M I / R F I Are all powered wheelchairs susceptible to EMI/RFI? Each make and model of chair differs in its ability to resist electromagnetic interference. That is, each has a particular level of immunity to interference, measured in volts per meter (V/m). A higher immu...
Page 10 - I V . T H E J A Z Z Y 1 1 2 0
10 Jazzy 1120 2000 I V . T H E J A Z Z Y 1 1 2 0 2 0 0 0 Your Jazzy has two main assemblies: the seat and the power base. See figure 1. There are a variety of seating options that are designed to accommodate most users. Typically, the seating assembly includes the armrests, seatback, and joystick co...
Page 12 - UTILITY TRAY; Battery Charger Plug:; view the controller harness connectors.
12 Jazzy 1120 2000 I V . T H E J A Z Z Y 1 1 2 0 2 0 0 0 UTILITY TRAY The utility tray is located on the rear of your Jazzy. The utility tray is located underneath the rear sliding door. The utility tray consists of the ammeter, the battery charger plug, the main circuit breaker, accessory connector...
Page 13 - FREEWHEEL LEVER; To disengage the drive and place chair in freewheel:; Push the freewheel lever down. See figure 8.; to the desired position.
13 Jazzy 1120 2000 I V . T H E J A Z Z Y 1 1 2 0 2 0 0 0 FREEWHEEL LEVER For your convenience, your Jazzy is equipped with a freewheel lever. See figures 7 and 8. This lever allows you to disengage the drive motors and maneuver the chair manually. WARNING! Do not use your Jazzy while the drive motor...
Page 15 - Specifications
15 Jazzy 1120 2000 I V . T H E J A Z Z Y 1 1 2 0 2 0 0 0 Specifications Suspension: Full suspension with Active-Trac Rear Caster Suspension Drive Wheels: 14 in., pneumatic (solid tires are optional) Rear Casters: 8 in., solid, rear articulating Anti-tip: 6 in., solid, front mounted Maximum Speed: 6 ...
Page 16 - V . A S S E M B L Y; SEAT ANGLE ADJUSTMENT; To adjust the seat angle:; JOYSTICK INSTALLATION; To install the joystick:
16 Jazzy 1120 2000 Figure 11. Controller Cable Connection V . A S S E M B L Y SEAT ANGLE ADJUSTMENT The seatback can be adjusted at four different angles, depending on user preference. A 90º, 102º, 105º, or 107 º angle can be set. To adjust the seat angle: 1. Use a hex key and a 3/8-in. wrench to re...
Page 17 - POWER SEAT OPTION INSTALLATION; To install the power seat:; l. Align the seat shaft to the hole in the actuator. See figure 13.
17 Jazzy 1120 2000 V . A S S E M B L Y POWER SEAT OPTION INSTALLATION Your Jazzy may be equipped with the power seat option. While the seat itself may be any one of the styles offered for this model, the way the seat base attaches to the Jazzy power base is different. To install the power seat: l. A...
Page 18 - V I . C O M F O R T A D J U S T M E N T S; SEAT HEIGHT AND ANGLE; To change the seat height:; ARMREST WIDTH; To change the armrest width:
18 Jazzy 1120 2000 V I . C O M F O R T A D J U S T M E N T S Once you are familiar with your Jazzys operation, you may find the need to adjust your seating position. There are some adjustments you can make to increase your comfort, such as seat height and angle, armrest width, angle and height, joy...
Page 19 - ARMREST ANGLE; To change the armrest angle:; JOYSTICK EXTENSION; To extend the joystick:
19 Jazzy 1120 2000 V I . C O M F O R T A D J U S T M E N T S ARMREST ANGLE You can adjust the armrest angle to fit your specific needs. To change the armrest angle: 1. Lift the armrest straight up so that it is perpendicular to the floor. 2. Use a 7/16-in. wrench to loosen the jam nut. See figure 17...
Page 20 - FOOTREST HEIGHT; To raise or lower the footrest:; FOOTREST DEPTH; To adjust the footrest depth:; FOOTREST ANGLE; To adjust the footrest angle:; SWING-AWAY FOOTRESTS OPTION; To swing the footrests:; ELEVATING LEG RESTS OPTION; To adjust the ELR angle:
20 Jazzy 1120 2000 V I . C O M F O R T A D J U S T M E N T S FOOTREST HEIGHT The footrest height is easily adjusted to one of six different heights in 1-in. increments. To raise or lower the footrest: 1. Remove the nuts and bolts from bracket. See figure 21. 2. Raise or lower the footrest to the des...
Page 21 - To adjust the ELR height:; RECLINING SEAT OPTION; To adjust the seatback angle:; POWER ELEVATING SEAT OPTION
21 Jazzy 1120 2000 To adjust the ELR height: 1. Remove the two screws from the side of each leg rest exten- sion. See figure 25. 2. Slide the leg rest in or out to the desired length. 4. Reinstall the two screws on each leg rest extension. RECLINING SEAT OPTION If your Jazzy is equipped with a recli...
Page 22 - Power Seat warnings and Cautions; If your Jazzy is equipped with the deluxe high-back seat, you can; To adjust the headrest height:; Move the headrest up or down to the desired position.
22 Jazzy 1120 2000 V I . C O M F O R T A D J U S T M E N T S Power Seat warnings and Cautions WARNING! Never raise the seat from its lowest position on an inclined surface. Failure to heed this warning can result in your Jazzy tipping over and causing injury. WARNING! Never raise the seat from its l...
Page 23 - ANTI-TIP WHEEL ADJUSTMENT
23 Jazzy 1120 2000 WARNING! The higher you raise the anti-tip wheels, the more tendency your Jazzy has to tilt forward when coming to a stop. You can compensate for this by making a small adjustment to the pre-programmed deceleration setting in the controller or by moving the seat assembly further t...
Page 24 - V I I . D I S A S S E M B L Y; SEAT REMOVAL; To remove a power seat:; FOOT FRAME REMOVAL; To remove the foot frame:; BATTERY REMOVAL; To remove the batteries:
24 Jazzy 1120 2000 V I I . D I S A S S E M B L Y SEAT REMOVAL You may wish to remove the seat for transportation. If you have a Versa Seat, please refer to the Versa Seat Installation and Adjustment guide. To remove the seat: 1. Turn the power off. 2. Make sure your Jazzy is not in freewheel mode. 3...
Page 25 - V I I I . O P E R A T I O N; JOYSTICK AND CONTROLLER; To operate your Jazzy:; CONTROLLER FUNCTIONS
25 Jazzy 1120 2000 V I I I . O P E R A T I O N JOYSTICK AND CONTROLLER Your Jazzy is operated by your joystick and controller. The Jazzy 1120 2000 is currently available with one of three controller options: Pilot, Remote Plus, or Europa. See figures 33 through 35. Refer to the text that applies to ...
Page 26 - PILOT CONTROLLER; Joystick Functions; Speed and Response Adjustment; Battery Condition Meter; ing you the batteries need to be charged immediately!
26 Jazzy 1120 2000 V I I I . O P E R A T I O N PILOT CONTROLLER The Pilot controller is an integral controller. See figure 36. This means that the joystick is housed in the same enclosure as the con- troller module. This assembly is mounted on the seat arm. The Pilot controller is connected to the m...
Page 28 - REMOTE PLUS CONTROLLER; and come to a complete stop. If your Jazzy begins to move in an unex-; The on/off key turns your unit on and off.; Horn Key; This key activates the horn.
28 Jazzy 1120 2000 V I I I . O P E R A T I O N REMOTE PLUS CONTROLLER The Remote Plus controller system consists of the joystick (see figure 39) and the controller box. The joystick sends signals to the controller box through a cable attached to the back of the joystick. This cable connects to the c...
Page 29 - Speed and Actuator Adjustments; operate at the selected speed setting.
29 Jazzy 1120 2000 V I I I . O P E R A T I O N Speed and Actuator Adjustments The Remote Plus joystick controller is equipped with a mode key and a speed indicator. See figure 39. The mode key allows you to access different wheelchair functions. Activating the mode key allows you to adjust the maxi-...
Page 30 - Flashing
30 Jazzy 1120 2000 V I I I . O P E R A T I O N Flashing Bars Diagnosis Solution 10 Green High Battery Voltage Check Batteries 9 Green Solenoid Brake Fault Check Motor/Brake Wiring 8 Green Possible Controller Fault See Authorized Provider Service Center 7 Yellow Possible Joystick Fault See Authorized...
Page 31 - EUROPA REMOTE CONTROLLER
31 Jazzy 1120 2000 V I I I . O P E R A T I O N EUROPA REMOTE CONTROLLER The Europa Remote controller system consists of the joystick (see figure 42) and the power module. This means that all of the pro- gramming is done within the joystick and the power module reacts accordingly. The power module is...
Page 32 - To arm the lockout system:; chair because the controller is still locked.; System Status Indicator; Remote fault. See Out Of Neutral At Power Up.
32 Jazzy 1120 2000 V I I I . O P E R A T I O N To arm the lockout system: 1. Hold the magnetic key on or near the key symbol. The controller beeps and automatically powers down. No LEDs should be on. 2. Press the on/off key to power up the chair. The key LED flashes, but you will not be able to driv...
Page 33 - V I I I . O P E R A T I O N; OUT OF NEUTRAL AT POWER UP; To control actuator movement with either of the two actuator keys:; Press the actuator key to activate the actuator.; To use the joystick to control the actuators:; Press the Drive Mode Select key until you get to 0.
33 Jazzy 1120 2000 V I I I . O P E R A T I O N OUT OF NEUTRAL AT POWER UP The Europa Remote Controller is equipped with Out Of Neutral At Power Up (OONAPU). If you power up the system and the joystick is not in the neutral position, the System Status Indicator flashes rapidly for either as long as t...
Page 34 - TROUBLE CODES
34 Jazzy 1120 2000 V I I I . O P E R A T I O N TROUBLE CODES Your controller is programmed to detect faults within its own system. If something happens to the controller system that prevents your Jazzy from operating, you should see a trouble code. This is indicated by the System Status Indicator fl...
Page 35 - I X . B A T T E R I E S A N D C H A R G I N G; BATTERIES
35 Jazzy 1120 2000 I X . B A T T E R I E S A N D C H A R G I N G BATTERIES Your Jazzy uses two long-lasting, 12-volt, deep-cycle batteries. These batteries are sealed and maintenance free. Since they are sealed, there is no need to check the electrolyte (fluid) level. Deep-cycle batteries are design...
Page 36 - I X . B A T T E R I E S A N D C H A R G I N G; To charge the batteries using the onboard charger:; NOTE: If the run plug is not reconnected, your Jazzy will not run.
36 Jazzy 1120 2000 I X . B A T T E R I E S A N D C H A R G I N G WARNING! Never use an extension cord to plug in your battery charger. Plug the charger directly into a properly wired standard wall outlet. To charge the batteries using the onboard charger: 1. Position the rear of your Jazzy close to ...
Page 37 - To break in new batteries for maximum efficiency:; accustomed to the controls and break in the batteries.; How does the charger work?; recommend using other types of chargers.; How often must I charge the batteries?; a daily basis or you may not use it for weeks at a time.; Daily Use; batteries for more than 24 hours at a charging cycle.
37 Jazzy 1120 2000 I X . B A T T E R I E S A N D C H A R G I N G BATTERY BREAK-IN To break in new batteries for maximum efficiency: 1. Fully recharge any new battery prior to its initial use. This brings the battery up to about 90% of its peak performance level. 2. Operate your Jazzy about the house...
Page 38 - How can I get maximum range or distance per charge?; Battery Specifications; Why do my new batteries seem weak?
38 Jazzy 1120 2000 I X . B A T T E R I E S A N D C H A R G I N G How can I get maximum range or distance per charge? Rarely do you have an ideal driving situation such as smooth, flat, hard terrain with no wind, hills, or curves. More often you are presented with hills, sidewalk cracks, uneven and l...
Page 39 - How can I ensure maximum battery life?; should be warmed for several days prior to recharging.; What about public transportation?; shipping container and ship the batteries in separate boxes.
39 Jazzy 1120 2000 6 I X . B A T T E R I E S A N D C H A R G I N G How can I ensure maximum battery life? A fully charged, deep-cycle battery provides reliable performance and extended battery life. Keep your Jazzys batteries fully charged whenever possible. Batteries that are regularly and deeply ...
Page 40 - X . C A R E A N D M A I N T E N A N C E; ROUTINE MAINTENANCE; Should your Jazzy come in contact with water:; TEMPERATURE; GENERAL GUIDELINES
40 Jazzy 1120 2000 X . C A R E A N D M A I N T E N A N C E ROUTINE MAINTENANCE Your Jazzy is a sophisticated powered wheelchair. Like any motorized vehicle, it requires routine maintenance checks. You can perform some of these checks, but others require assistance from an authorized Pride provider. ...
Page 41 - correct wiring layout.
41 Jazzy 1120 2000 X . C A R E A N D M A I N T E N A N C E WARNING! Overinflating tires can cause them to explode and can result in personal injury. WARNING! Do not use high pressure hose. n Use a rubber conditioner on the tire sidewalls to help preserve them. Never use a rubber conditioner on the t...
Page 42 - blinks once, and then it blinks continuously.
42 Jazzy 1120 2000 X . C A R E A N D M A I N T E N A N C E To calibrate the joystick (Remote Plus only): 1. Position the joystick in the full reverse position and hold it there. Turn on the controller. 2. The battery condition meter lights up from one bar to ten bars, and then back to one bar. It do...
Page 43 - Follow these easy steps for a quick and safe repair:; BATTERY REPLACEMENT; To replace the battery:; FRONT; This gives you more room to work.
43 Jazzy 1120 2000 X . C A R E A N D M A I N T E N A N C E WARNING! Make sure the tire is completely deflated before attempting repair. Follow these easy steps for a quick and safe repair: 1. Completely deflate the tire if pneumatic. 2. Use a 3/4-in. socket wrench to remove the drive wheel nut from ...
Page 44 - MOTOR BRUSHES; To inspect or replace the motor brushes:; CORRECTIVE MAINTENANCE
44 Jazzy 1120 2000 X . C A R E A N D M A I N T E N A N C E MOTOR BRUSHES The electric motors that power your Jazzy use carbon brushes. These brushes may become susceptible to wear over a long pe- riod of time. The motor brushes are the two contacts located inside the motor assembly that supply power...
Page 45 - X I . O P T I O N A L A C C E S S O R I E S; POSITIONING BELT
45 Jazzy 1120 2000 X I . O P T I O N A L A C C E S S O R I E S The following accessories are available from your authorized Pride provider. POSITIONING BELT The positioning belt (see figure 50) is designed to support the operator so that he or she does not slide down or forward in the seat. The posi...
Page 46 - CANE AND CRUTCH HOLDER
46 Jazzy 1120 2000 X I . O P T I O N A L A C C E S S O R I E S CANE AND CRUTCH HOLDER The removable cane and crutch holder is mounted to the back of the seat by means of the accessory bracket. See figure 52. WALKER HOLDER The removable walker holder is mounted to the back of the seat by means of the...
Page 47 - X I I . W A R R A N T Y; LIFETIME LIMITED WARRANTY
47 Jazzy 1120 2000 X I I . W A R R A N T Y LIFETIME LIMITED WARRANTY For the lifetime of your Jazzy, from the date of purchase, Pride will repair or replace at our option to the original purchaser, free of charge, any of the following parts found upon examination by an authorized representative of P...
Page 48 - WARRANTY EXCLUSIONS
48 Jazzy 1120 2000 X I I . W A R R A N T Y Warranty service can be performed by an authorized Pride provider or by Pride. Do not return faulty parts to Pride without prior consent. All transportation costs and shipping damage incurred while submitting parts for repair or replacement are the responsi...
