Porter-Cable H451CS - Manual

Page 2 - SPECIFICATION; MODEL

2 — ENG This product is equipped with a spark arresting muffler. If the product will be used around flammable materials, or on land covered with materials such as agricultural crops, forest, brush, grass, orother similar items, then an approved spark arrester must be installed and is legally require...

Page 3 - WARRANTY; THIS WARRANTY IS NOT TRANSFERABLE AND DOES NOT COVER; WARRANTY SERVICE

3 — ENG WARRANTY Porter-Cable Corporation 4825 Highway 45 North P.O. Box 2468 Jackson, TN 38302-2468 1-888-559-8550 PORTER-CABLE CORPORATION warrants to the original purchaser that each new electric generator and service part is free from defects in material and workmanship, and agrees to repair or ...

Page 4 - WILL VOID; RISK OF ELECTROCUTION AND FIRE; When using this product basic precautions should always be fol-; • SAVE THESE INSTRUCTIONS •; IMPORTANT SAFETY INSTRUCTIONS

4 — ENG Attempting to connect generatordirectly to the electrical system ofany building structure. Back feeding electricity through abuilding’s electrical system to theoutside utility feed lines could endan-ger repair persons attempting to re-store service. Attempting to connect to the incom-ing uti...

Page 5 - READ AND UNDERSTAND ALL WARNINGS BEFORE; HAZARD

5 — ENG READ AND UNDERSTAND ALL WARNINGS BEFORE ATTEMPTING TO OPERATE GENERATOR. Use of worn, damaged, under-sized or ungrounded extensioncords. Placing generator on or againsthighly conductive surface, such asa steel walkway or metal roof. Improper connection of items togenerator. Operation of unit...

Page 6 - RISK OF FIRE; Inadequate ventilation for generator; Improper storage of fuel; DO NOT OPERATE UNIT; Never attempt to

6 — ENG READ AND UNDERSTAND ALL WARNINGS BEFORE ATTEMPTING TO OPERATE GENERATOR. RISK OF FIRE Inadequate ventilation for generator Use care in filling the tank to avoidspilling fuel. Make sure fuel cap issecured tightly and check enginefor fuel leaks before startingengine. Move generator awayfrom re...

Page 7 - RISK OF BREATHING - INHALATION HAZARD; Risk of Injury and Property Damage When

7 — ENG READ AND UNDERSTAND ALL WARNINGS BEFORE ATTEMPTING TO OPERATE GENERATOR. RISK OF BREATHING - INHALATION HAZARD Operate generator in clean, dry,well ventilated area. Never operateunit in enclosed areas such asgarages, basements, storage,sheds, or in any location occupiedby humans or animals. ...

Page 8 - RISK OF UNSAFE OPERATION; A multiple outlet strip is

8 — ENG READ AND UNDERSTAND ALL WARNINGS BEFORE ATTEMPTING TO OPERATE GENERATOR. • Review and understand all ofthe operating instructions andwarnings in this manual. • Become familiar with the oper-ation and controls of the gen-erator. Know how to shut it offquickly. • Equip area of operation with a...

Page 9 - RISK FROM LIFTING; Lifting a very heavy object.; RISK OF MOVING PARTS

9 — ENG RISK FROM LIFTING HAZARD HOW TO PREVENT IT WHAT COULD HAPPEN The generator is too heavy to belifted by one person. Obtain assis-tance from others before you tryto move it. Serious injury can result from attempt-ing to lift too heavy an object. Lifting a very heavy object. READ AND UNDERSTAND...

Page 10 - Extension Cords; ASSEMBLY; REMOVE GENERATOR FROM CARTON

10 — ENG Extension Cord Wire Gauge Chart Amperage *Up to 20 amp draw Up to 30 amp draw Cord Length 0 to 100 ft. 0 to 100 ft. Wire Gauge Size 12 ga. 10 ga. *NOTE: When amperage exceeds 20 amps; a 12 gauge extension cord should not be used for long dis-tances. Extension Cords When using an appliance o...

Page 11 - OPERATION; KNOW YOUR GENERATOR; Compare the illustration; GENERATOR CAPACITY; Exceeding the rated capacity of your; Wattage; section in this manual to assist you in de-; CIRCUIT BREAKERS; Choose the correct application.; Place the idle control switch in the OFF position.; To operate 12V DC equipment:

11 — ENG OPERATION KNOW YOUR GENERATOR Read this General Manual and Safety Rules beforeoperation of your Generator. Compare the illustration in your parts manual with your generator to familiarizeyourself with the location of various controls and ad-justments. Save all manuals for future references....

Page 12 - All electrical loads; MUST; be disconnected; BEFORE START UP

12 — ENG Never fill fuel tank indoors. Never fill fuel tankwhen engine is running or hot. Do not smokewhen filling fuel tank. Never run engine indoors or in enclosed, poorventilated areas, engine exhaust contains car-bon monoxide, an odorless and deadly gas. 3. Make sure generator is grounded in acc...

Page 13 - TO START THE ENGINE; Open the fuel shut-off valve on tank and engine.; STOPPING ENGINE; Wattage Calculation; Section in this

13 — ENG TO START THE ENGINE Never run engine indoors or in enclosed, poorventilated areas, engine exhaust contains carbon monoxide, an odorless and deadly gas. 1. Open the fuel shut-off valve on tank and engine. 2. Move the choke control located on the engine to "CHOKE" position. NOTE: No c...

Page 14 - MAINTENANCE; GENERAL RECOMMENDATIONS; ated in extreme dusty or dirty conditions.; CUSTOMER RESPONSIBILITIES TABLE; MAINTENANCE TASK; For maximum protection against electrical

14 — ENG MAINTENANCE GENERAL RECOMMENDATIONS The warranty of the generator does not cover itemsthat have been subjected to operator abuse or negli-gence. To receive full value from the warranty, operatormust maintain the generator as instructed in this manu-al. ENGINE MAINTENANCE Refer to the Engine...

Page 15 - STORAGE; Engine Preparation; Replace the spark plug, but do not connect the; Generator; • Clean the generator as outlined in the; nance; Section on this manual.

15 — ENG STORAGE If you are going to store your generator for more than30 days, use the following information as a guide toprepare the generator for storage. Never store generator with fuel in the tank in-doors or in enclosed, poorly ventilated areas,where fumes can reach an open flame, spark orpilo...

Page 16 - IMPORTANT; DETERMINING WATTAGE REQUIREMENTS; TOTAL; WATTAGE CALCULATIONS

16 — ENG Never exceed the rated capacity of your generator. Serious damage to the generator or appliance couldresult from an overload. 1. Starting and running wattage requirements should always be calculated when matching a generators wattage capacity to the appliance or tool. 2. There are two types...

Page 17 - STARTING WATTAGE REQUIREMENTS; will; be listed in wattage.; Application Guide; Electric Appliance

17 — ENG STARTING WATTAGE REQUIREMENTS 1. Some appliances and tools will list on the motorname plate the starting and running voltage andamperage requirements. Use the following formula toconvert voltage and amperage to wattage: Volts X Amp = Watts 120 volts x 10 amps = 1200 watts 2. To determine th...

Page 18 - HOUSEHOLD WATTAGE CALCULATOR

18 — ENG HOUSEHOLD WATTAGE CALCULATOR WATTAGE CALCULATIONS APPLIANCE OR LOAD DEVICE* REFRIGERATOR/ FREEZER 800 SMALL REFRIGERATOR AIR COND.(ROOM) SUMP PUMP 1/2 HP 600 TELEVISION CAUTION !! HOT PLATE MICROWAVE SPACE HEATER 2400 1000 3 2 LIGHTING 60 WATT BULBS 75 WATT BULBS 100 WATT BULBS 300 WATT BUL...

Page 19 - TROUBLESHOOTING GUIDE; Engine will not start

19 — ENG PROBLEM CAUSE CORRECTION TROUBLESHOOTING GUIDE Engine will not start No electrical output Repeated circuit breakertripping Generator overheating 1. Low on fuel or oil. 2. Ignition switch in "Off" position. 3. Faulty spark plug. 4. Choke in wrong position. 5. Fuel shut-off valve in c...

Page 20 - ALWAYS REFER TO THE MANUALS SUPPLIED WITH THIS UNIT; Generator Quick Facts

Porter-Cable Corporation 4825 Highway 45 North P.O. Box 2468 Jackson, TN 38302-2468 1-888-559-8550 ALWAYS REFER TO THE MANUALS SUPPLIED WITH THIS UNIT Generator Quick Facts CALL 1-888-559-8550 TO FIND A LOCAL AUTHORIZED SERVICE CENTER NEAR YOUFOR REPAIRS AND SERVICE PART PURCHASES ENGINE GAS ENGINE ...

Porter-Cable H451CS - Manual

Table of Contents:

Summary

Other Porter-Cable Models