Porter-Cable CFFN251T - Manual

Page 2 - SAFETY GUIDELINES - DEFINITIONS; understand. This information relates to protecting; IMPORTANT SAFETY INSTRUCTIONS

2 - ENG A11894 SAFETY GUIDELINES - DEFINITIONS This manual contains information that is important for you to know and understand. This information relates to protecting YOUR SAFETY and P R E V E N T I N G E Q U I P M E N T P R O B L E M S . To h e l p y o u re c o g n i z e t h i s information, we u...

Page 3 - Save these instructions; HAZARD; WARNING: Risk of explosion or fire

3 - ENG A11894 IMPORTANT SAFETY INSTRUCTIONS Save these instructions Improper operation or maintenance of this product could result in serious injury and property damage. Read and understand all warnings and operation instructions before using this equipment. HAZARD WARNING: Risk of explosion or fir...

Page 6 - WARNING: Risk of Burns; WARNING: Risk from Moving Parts

6 - ENG A11894 WARNING: Risk of Burns Touching exposed metal such as the compressor head or outlet tubes, can result in serious burns. Never touch any exposed metal parts on compressor during or immediately after operation. Compressor will remain hot for several minutes after operation. Do not reach...

Page 7 - WARNING: Risk of Unsafe Operation; WARNING: Risk of Serious Injury or Property Damage; SAVE THESE INSTRUCTIONS

7 - ENG A11894 Review and understand all instructions and warnings in this manual. Become familiar with the operation and controls of the air compressor. Keep operating area clear of all persons, pets, and obstacles. Keep children away from the air compressor at all times . Do not operate the produc...

Page 8 - CFM; SPECIFICATIONS

8 - ENG A11894 GLOSSARY DUTY CYCLE Accessories for this unit are available at the store the unit was purchased. ACCESSORIES Become familiar with these terms before operating the unit. CFM : Cubic feet per minute. SCFM: Standard cubic feet per minute; a unit of measure of air delivery. PSIG: Pounds p...

Page 9 - ASSEMBLY; Unpacking; INSTALLATION; HOW TO SET UP YOUR UNIT; Location of the Air Compressor

9 - ENG A11894 ASSEMBLY Unpacking 1. Remove unit from carton and discard all packaging. 2. Make sure the outlet being used has the same configuration as the grounded plug. DO NOT USE AN ADAPTER. See illustration. 3. Inspect the plug and cord before each use. Do not use if there are signs of damage. ...

Page 10 - Certain air

10 - ENG A11894 Extension Cords Using extension cords is not recommended. The use of extension cords will cause voltage to drop resulting in power loss to the motor and overheating.Instead of using an extension cord, increase the working reach of the air hose by attaching another length of hose to i...

Page 11 - Outlet Pressure Gauge:; Description of Operation; OPERATION; Know Your Air Compressor

11 - ENG A11894 Outlet Pressure Gauge: The outlet pressure gauge indicates the air pressure available at the outlet side of the regulator. This pressure is controlled by the regulator and is always less than or equal to the tank pressure. Regulator: Controls the air pressure shown on the outlet pres...

Page 12 - How to Use Your Unit; Before Starting; Risk of Unsafe; before

12 - ENG A11894 2. Plug the power cord into the correct branch circuit receptacle. (Refer to "Voltage and Circuit Protection" paragraph in the "Installation" section of this manual.) 3. Open the drain valve (counter- clockwise) fully to permit air to escape and prevent air pressure b...

Page 13 - MAINTENANCE; Customer Responsibilities; To Check Safety Valve

13 - ENG A11894 How to Start: 1. Set the On/Off switch to ON (I) and allow tank pressure to build. Motor will stop when tank pressure reaches "cut-out" pressure. 2. Pull the regulator knob out and turn clockwise to increase pressure. When the desired pressure is reached push knob in to lock ...

Page 14 - To Drain Tank; SERVICE AND ADJUSTMENTS; Risk of Unsafe Operation. Unit cycles automatically when

14 - ENG A11894 To Drain Tank 1. Set the On/Off switch to OFF (O).2. Pull the regulator knob out and turn counterclockwise to set the outlet pressure to zero. 3. Remove the air tool or accessory.4. Pull ring on safety valve allowing air to bleed from the tank until tank pressure is approximately 20 ...

Page 15 - To Replace Regulator

15 - ENG A11894 5. Make sure the valve disc moves freely inside the check valve and the spring holds the disc in the upper, closed position. The check valve may be cleaned with a solvent, such as paint and varnish remover. 6. Apply sealant to the check valve threads. Reinstall the check valve (turn ...

Page 16 - STORAGE; Water will

16 - ENG A11894 STORAGE Before you store the air compressor, make sure you do the following:1. Review the "Maintenance" section on the preceding pages and perform scheduled maintenance as necessary. 2. Set the On/Off switch to OFF (O) and unplug unit. 3. Turn the regulator counterclockwise a...

Page 17 - TROUBLESHOOTING

17 - ENG A11894 TROUBLESHOOTING Performing repairs may expose voltage sources, moving parts or compressed air sources. Personal injury may occur. Prior to attempting any repairs, unplug the air compressor and bleed off all air tank air pressure. PROBLEM CAUSE CORRECTION Pressure switch does not shut...

Page 19 - for a list of service centers or call

19 - ENG A11894 SERVICE REPLACEMENT PARTS When servicing use only identical replacement parts. For a service parts list or to learn more about Porter-Cable visit our website at www.porter-cable.com. SERVICE AND REPAIRS All quality tools will eventually require servicing, or replacement of parts due ...

Page 20 - WARRANTY

20 - ENG A11894 Limited Warranty Porter-Cable warrants to the original purchaser that all products covered under this warranty are free from defects in material and workmanship. Products covered under this warranty include air compressors, air tools, service parts, pressure washers, and generators, ...

Porter-Cable CFFN251T - Manual

Table of Contents:

Summary

Other Porter-Cable Models