Nissan NL221 - Manual
Nissan NL221 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Before Starting Installation; Only install this kit on the vehicle for which it is; If anytime during the installation you; Kit parts are prefaced by the word kit and appear in; bold; Ride Height; Bolt Size
- Page 3 – Engine Compartment; Remove lug nuts and front wheels from vehicle.; Battery; Install Front Leveling Kit; Driver side coil-over assembly; Nuts
- Page 5 – spacer; Spacer; Kit; Bolts; Kit
- Page 6 – After Completing Installation; Apply kit; Dynamic Vehicle Check; Kit Parts List; Performance Automotive Group
2265 Crosswind Drive • Prescott, AZ 86301
(928) 636-3175 • www.p-a-g.net
NISSAN FRONTIER
FRONT LEVELING KIT
INSTALLATION INSTRUCTIONS
2005-2006
KIT# NL221
WARNING
Installation of a Performance Automotive Group sus-
pension lift kit will change the vehicle’s center of gravity
and handling characteristics both on- and off-road. You
must drive the vehicle safely! Extreme care must be
taken to prevent vehicle rollover or loss of control,
which could result in serious injury or death. Avoid sud-
den sharp turns or abrupt maneuvers and always make
sure all vehicle occupants have their seat belts fas-
tened.
WARNING
Before you install this kit, read and understand all
instructions, warnings, cautions, and notes in this
instruction sheet and in the vehicle owner’s manual.
CAUTION
Proper installation of this kit requires knowledge of the
factory recommended procedures for removal and
installation of original equipment components. We rec-
ommend that the factory shop manual and any special
tools needed to service your vehicle be on hand during
the installation. Installation of this kit without proper
knowledge of the factory recommended procedures
may affect the performance of these components and
the safety of the vehicle. We strongly recommend that
a certified mechanic familiar with the installation of sim-
ilar components install this kit.
WARNING
This kit should only be installed on a vehicle that is in
good working condition. Before you install the kit, thor-
oughly inspect the vehicle for corrosion or deformation
of the sheet metal. If the vehicle is suspected to have
been in a collision or misused, do not install this kit.
Off-road use of your vehicle with this kit installed may
increase the stress applied to the factory components.
Failure to observe this warning may result in serious
personal injury and/or severe damage to your vehicle.
WARNING
Many states and municipalities have laws restricting
bumper heights and vehicle lifts. Consult state and
local laws to determine if the changes you intend to
make to the vehicle comply with the law.
WARNING
The installation of larger tires may reduce the effective-
ness of the braking system.
WARNING
Always wear eye protection when operating power
tools.
WARNING
Before you install this kit, block the vehicle tires to pre-
vent the vehicle from rolling.
NOTE
Performance Automotive Group recommends using
the Loctite® supplied in the kit on the threads of all kit
nuts and bolts unless specified otherwise in these
instructions.
NOTE
Installation of a suspension lift will change the driveline
angles which may cause a noticeable vibration in the
vehicle. See the troubleshooting section at the end of
these instructions.
WARNING
DO NOT combine suspension, body, or other lift
devices. Use of vehicle with combined lifts may result
in unsafe and/or unexpected handling characteristics.
NOTE
Lift height may vary depending on vehicle configura-
tion, engine size, additional accessories, the factory
suspension package, and vehicle’s condition.
1
‘05-’06 Frontier Leveling - Kit NL221
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 ‘05-’06 Frontier Leveling - Kit NL221 Before Starting Installation 1. Carefully read all warnings and instructions com-pletely before beginning. 2. Verify all parts have been received in this kit bychecking the parts list at the end of this document. 3. Only install this kit on the vehicle for whi...
3 ‘05-’06 Frontier Leveling - Kit NL221 Engine Compartment 1. Disconnect both battery cables. Disconnect negativecable first, then positive cable. Prepare to Install FrontLeveling Kit 1. Loosen, but do not remove, lug nuts on each frontwheel. 2. Using a hydraulic floor jack, slowly lift front axle u...
5 ‘05-’06 Frontier Leveling - Kit NL221 g. Align marks on coil spring, upper plate, andshock. Install upper plate, shock, bushing,washer, and nut onto coil spring. h. Ensure marks are aligned along upper plate, coilspring, and shock. i. Install kit spacer (upper) onto upper plate. Washer& Bushin...
