Page 2 - pROpOSITION 65 WARNINg
page 2 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) pROpOSITION 65 WARNINg Engine exhaust and some of its constituents, and some dust created of California to cause cancer, birthdefects and other reproductive harm. by power sanding, sawing, grinding, drilling and oth...
Page 3 - NOTES
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 3 NOTES
Page 4 - TABLE Of CONTENTS; WBH16EAWD power Buggy; Drawings; NOTICE
page 4 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) TABLE Of CONTENTS WBH16EAWD power Buggy Proposition 65 Warning ........................................... 2 Table Of Contents .................................................... 4 Parts Ordering Procedures ..........
Page 5 - pARTS ORDERINg pROCEDuRES; Ordering parts has never been easier!; Choose from three easy options:; order via internet; Order; order via Fax
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 5 pARTS ORDERINg pROCEDuRES www .multiquip .com Ordering parts has never been easier! Choose from three easy options: We aCCept all major CreDit CarDs! When ordering parts, please supply: ❒ Dealer account number ❒ Dea...
Page 6 - SAfETy INfORMATION; saFety messages; Danger; Lethal exhaust gas hazards; Symbol; Hydraulic fluid hazards
page 6 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) SAfETy INfORMATION Do not operate or service the equipment before reading the entire manual. Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the safet...
Page 7 - general saFety
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 7 SAfETy INfORMATION general saFety Caution never operate this equipment without proper protective clothing, shatterproof glasses, respiratory protection, hearing protection, steel-toed boots and other protective de...
Page 8 - poWer Buggy saFety
page 8 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) SAfETy INfORMATION poWer Buggy saFety Danger Engine fuel exhaust gases contain poisonous carbon monoxide. This gas is colorless and odorless, and can cause death if inhaled. The engine of this equipment requires...
Page 10 - engine saFety; Fuel saFety
page 10 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) SAfETy INfORMATION engine saFety Warning Do not place hands or fingers inside engine compar tment when engine is running. never operate the engine with heat shields or guards removed. Keep fi ngers, hands hai...
Page 11 - liFting saFety; transporting saFety; environmental saFety
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 11 SAfETy INfORMATION alWays recharge the battery in a well-ventilated environment to avoid the risk of a dangerous concentration of combustible gases. If the battery liquid (dilute sulfuric acid) comes into conta...
Page 12 - SpECIfICATIONS
page 12 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) SpECIfICATIONS table 1. specifications (power Buggy) Model WBH16EAWD Wheelbase 44 in. (1117.6 mm) Overall Length 103 in. (2616.2 mm) Overall Width- Dual Wheels 43.25 in. (1098.6 mm) Overall Width - Single Wheels 30...
Page 14 - DIMENSIONS; Figure 1. WBH16EAWD Dimensions; siDe vieW
page 14 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) DIMENSIONS Figure 1. WBH16EAWD Dimensions siDe vieW rear vieW
Page 15 - read and thoroughly; gENERAL INfORMATION
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 15 The MQ Whiteman All-Wheel Drive (AWD) Power Buggy, Model WBH16EAWD (electric start) is intended for the transportation of concrete, concrete spreading and spot pouring. In addition, the WBH16EAWD is designed for la...
Page 16 - COMpONENTS; Figure 2. WBH16EAWD Power Buggy
page 16 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) COMpONENTS 1. tub or Bucket — Used for the transportation of material. Tub holds approximately 16 cubic feet (0.59 cubic yards) of water. 2. Handle Bar (steering) — This handle bar is used to steer the buggy. When ...
Page 17 - BASIC ENgINE; Figure 3. Briggs & Stratton Vanguard 18HP Engine
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 17 BASIC ENgINE Figure 3. Briggs & Stratton Vanguard 18HP Engine 1. oil Fill Cap — Remove cap to refill or replace oil with recommended type as listed in Table 3. Make sure cap is tightened securely. Do not over f...
Page 18 - INSpECTION; BeFore starting; Figure 4. Engine Oil Dipstick Removal; gasoline CHeCK; season; hot or
page 18 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) INSpECTION BeFore starting 1. Read safety information at the beginning of manual.2. Clean the machine, removing dirt and dust, particularly the engine cooling air inlet, carburetor and air cleaner. 3. Check the air...
Page 19 - Figure 7. Hydraulic Sight Glass
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 19 parKing BraKe CHeCK Check the brakes as outlined in the maintenance section of this manual. linKage CHeCK Check and make sure that all linkages within the buggy are functioning correctly. steering CHeCK 1. Check an...
Page 20 - OpERATION; eleCtriC start; Caution; Figure 10. Ignition Switch; reCoil start; Figure 12. Starter Grip
page 20 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) OpERATION eleCtriC start 1. Before attempting to start the power buggy, make sure that the safety kill switch (Figure 19) is not pushed in. The power buggy will not start with the kill switch engaged. 2. Pull the c...
Page 21 - Figure 13. Parking Brake Lever; parKing BraKe/DireCtion lever; Figure 15. Direction Lever; traCtion assist system sWitCH
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 21 OpERATION 4. If the engine has started, slowly push the choke lever (Figure 11) inward to the RUN position. If the engine has not started, repeat steps 1 through 3. pre-CHeCK 1. Engage the parking brake lever (Figu...
Page 22 - traveling; Figure 18. Brake Pedal
page 22 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) Figure 16. Traction Assist Switch 2. Release the switch to return to normal operation. all-WHeel Drive (aWD) system When operating the WBH16EAWD in rough or uneven terrain, use the AWD/2WD switch (Figure 17) on the...
Page 23 - emergenCy sHutDoWn; Figure 19. Safety Kill Switch; steering; Figure 20. Steering the Buggy; traveling on a slope; Figure 21. Determining Grade of Slope
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 23 OpERATION emergenCy sHutDoWn The WBH16EAWD is equipped with a safety kill switch. This switch is located on the right side of the handle bar.1. Press the power buggy's kill switch (Figure 19) and listen for the eng...
Page 24 - Figure 22. Slope Travel Direction; Figure 23. Dump Pedal
page 24 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) 2. When going up or down a slope, always travel in the forward direction (Figure 22). Figure 22. Slope Travel Direction tuB (BuCKet) Dumping The hydraulic dump can be controlled by hand (dump control lever) or foot...
Page 25 - MAINTENANCE; engine; Figure 24. Hydraulic Oil Tank Filler Cap; HyDrauliC Drive motors
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 25 MAINTENANCE engine Refer to the Briggs and Stratton Vanguard engine owner’s manual for specific information.1. Check engine oil after every 10 hours of operation and maintain proper levels. 2. Drain oil after every...
Page 26 - pump Control lever aDjustment; lug nut torque requirements; Figure 25. Lug Nut Torque Sequence; table 5. tire torque requirements
page 26 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) pump Control lever aDjustment If the power buggy tends to creep in the forward or reverse direction after you release the speed control lever, the pump control lever requires adjustment.3. Place the machines drive ...
Page 27 - TROuBLESHOOTINg
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 27 TROuBLESHOOTINg troubleshooting (power Buggy) symptom possible problem solution Loss of Power. Speed control cable out of adjustment? Adjust speed control cable. Replace cable if necessary Hydraulic oil level low.?...
Page 30 - HyDRAuLIC SySTEM DIAgRAM
page 30 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) HyDRAuLIC SySTEM DIAgRAM
Page 31 - ELECTRIC WIRINg DIAgRAM
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 31 ELECTRIC WIRINg DIAgRAM
Page 32 - HyDRAuLIC HOSE CONNECTIONS
page 32 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) HyDRAuLIC HOSE CONNECTIONS DRIVE MOTORS AWD STEERING MOTOR CHASSIS NOTES: ITEM 5 HYDRAULIC HOSE, HYDRAULIC HOSE, ITEM 28 ITEM 22 HYDRAULIC HOSE, ITEM 2 HYDRAULIC HOSE, INDICATES FRONT OF MACHINE DIRECTIONAL VALVE B...
Page 34 - ExpLANATION Of CODE IN REMARkS COLuMN; sample parts list; remarKs Column
page 34 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) ExpLANATION Of CODE IN REMARkS COLuMN The following section explains the different symbols and remarks used in the Parts section of this manual. Use the help numbers found on the back page of the manual if there ar...
Page 35 - SuggESTED SpARE pARTS; W B H 1 6 e aW D p oW e r B u g g y W i t H B r i g g s & s t r at to n va n g a r D 1 8 H p e n g i n e; Description
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 35 SuggESTED SpARE pARTS W B H 1 6 e aW D p oW e r B u g g y W i t H B r i g g s & s t r at to n va n g a r D 1 8 H p e n g i n e 1 to 3 units qty. p/n Description 1............508667 .................. FILTER, HY...
Page 36 - NAMEpLATES AND DECALS
page 36 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) NAMEpLATES AND DECALS
Page 37 - DECAL, HYDRAULIC OIL
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 37 no. part no. part name qty. remarKs 1 512446 DECAL, WPB-16EAWD 2 2 18252 DECAL, MQ WHITEMAN 2 3 EM985 DECAL, HYDRAULIC OIL 1 4 513608 DECAL, LIFTING HOOK 3 5 18245 DECAL, FORKLIFT LIFTING 6 6 18247 DECAL, CRUSH WAR...
Page 38 - HyDRAuLIC DRIVE ASSy.
page 38 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) HyDRAuLIC DRIVE ASSy.
Page 43 - ZERK FITTING
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 43 no. part no. part name qty. remarKs 1 18022 PISTON, HYD. DUMP 1 2 491705 ZERK FITTING 2 3 511803 ADAPTER, ELBOW 2 4 18020 HOSE, DUMP VALVE TO HYD. PISTON 2 5 511804 ADAPTER, STRAIGHT 2 6 512234 ADAPTER, ELBOW 1 7 5...
Page 46 - puMp AND COupLINg ASSy.
page 46 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) puMp AND COupLINg ASSy.
Page 49 - PIN, TUB FRAME CROSS
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 49 no. part no. part name qty. remarKs 1 18004 TUB, PLASTIC 1 2 492313 SCREW, HHC 3/8-16 X 1-1/2 9 3 512193 WASHER, FLAT 3/8 LARGE 9 4 492598 WASHER, FLAT 3/8 9 5 490957 RING, SNAP 6 6 18130 PIN, HYD. PISTON CROSS 2 7...
Page 51 - FASTENER, ACCESS DOOR
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 51 no. part no. part name qty. remarKs 1 511476 SCREW, ALLEN 1/8 X 1/4 1 2 511474 FASTENER, ACCESS DOOR 1 3 18008 DOOR, ACCESS 1 4 18024 SCREW, WING 1/4-20X3/4 2 5 492597 WASHER, FLAT 9.5X22.2 20 6 18141 COVER, R/SIDE...
Page 53 - LINKAGE, RIGHT BRAKE
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 53 no. part no. part name qty. remarKs 1 511762 SCREW, HHC 1/2-13X8 1 2 511698 CLEVIS, ASSY. BRAKE 2 3 511761 NUT, HEX 3/8-24 NF 2 4 18111 PEDAL, BRAKE 1 5 492600 WASHER, FLAT 1/2 1 6 492584 NUT, NYLOC 1/2-13 10 7 181...
Page 57 - CHASSIS
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 57 no. part no. part name qty. remarKs 1 492583 NUT, NYLOC 3/8 10 2 492598 WASHER, FLAT 3/8 18 3 492313 SCREW, HHC 3/8- 16 X 1- 1/2 3 4 503112 SCREW, HHC 3/8- 16 X 2- 3/4 4 5 492375 SCREW, HHC 3/8- 16 X 12 2 6 492357 ...
Page 58 - DuMp pADDLE AND HANDLE ASSy.
page 58 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) DuMp pADDLE AND HANDLE ASSy.
Page 59 - BELL CRANK, DUMP VALVE
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 59 no. part no. part name qty. remarKs 1 492401 SCREW, HHC 1/2- 13 X 4 1 2 512184 NUT, NYLOC 3/16- 24 1 3 18121 KNOB, LEVER 1 4 18065 LEVER, DUMP VALVE 1 5 512185 SCREW, HHC 1/4- 20 X1- 3/4 2 6 492622 WASHER, LOCK 1/4...
Page 60 - HyDRAuLIC OIL TANk ASSy.
page 60 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) HyDRAuLIC OIL TANk ASSy.
Page 61 - SCREEN, OIL RESERVOIR
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 61 no. part no. part name qty. remarKs 1 3336 SIGHT GAUGE, HYD. OIL TANK 1 2 16477 CAP, HYD. OIL TANK 1 3 18113 TANK HYD. OIL 1 4 492375 SCREW, HHC 3/8- 16 X1 3 5 491212 PLUG, HYD. OIL TANK 1/2’’ 1 6 492598 WASHER, FL...
Page 64 - To order parts for the EPA Fuel Tank,
page 64 — WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) fuEL TANk ASSy. NOTICE To order parts for the EPA Fuel Tank, contact MQ Parts Department.
Page 65 - TERMS AND CONDITIONS Of SALE — pARTS
WBH16eaWD epa poWer Buggy • operation anD parts manual — rev. #0 (09/09/13) — page 65 TERMS AND CONDITIONS Of SALE — pARTS payment terms Terms of payment for parts are net 30 days. FreigHt poliCy All parts orders will be shipped collect or prepaid with the charges added to the invoice. All shipments...
Page 66 - OperatiOn and parts Manual; Your Local Dealer is:; HERE’S HOW TO GET HELP; PLEASE HAVE THE MODEL AND SERIAL; Canada
OperatiOn and parts Manual Your Local Dealer is: HERE’S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING United StateS Multiquip Corporate Office MQ Parts Department 18910 Wilmington Ave. Carson, CA 90746 Contact: [email protected] Tel. (800) 421-1244 Fax (310) 537-3927 80...
