Monessen IDV380PVC - Manual
Monessen IDV380PVC – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 3 – Cleaning and Maintenance; iMPORtANt SAFety iNFORMAtiON; CARBON MONOxiDe POiSONiNG:; Continued on page 4; iNStAlleR; Any change to this fireplace or its controls can be dangerous.; ARN
- Page 4 – iMPORtANt SAFety iNFORMAtiON and CODe APPROVAl; Continued from page 3; CODe APPROVAl; liSteD VeNteD GAS FiRePlACe heAteR; Manufactured; Standard for Manufactured home installations, ANSi/NCSBCS A225.1; WARNING; PleASe ReAD the FOllOWiNG
- Page 5 – hiGh eleVAtiONS; Orifice; GAS SPeCiFiCAtiONS & ORiFiCe SiZe
- Page 6 – iNSeRt DiMeNSiONS
- Page 7 – The following factors should be taken into consideration:; iNSeRt APPliCAtiONS; The dimensions shown on
- Page 9 – ney before installing.
- Page 10 – iNStAllAtiON; The damper and grate must be removed.; with screws supplied.; Please review the following carefully.
- Page 11 – Figure 6; VeNtiNG RequiReMeNtS
- Page 12 – VeNtiNG iNStAllAtiON
- Page 13 – You may use either reline configuration with a masonry
- Page 14 – Figure
- Page 15 – uti; CheCK GAS tyPe
- Page 16 – iNSeRt iNStAllAtiON; Natural Gas; From Gas Meter
- Page 17 – CheCK GAS PReSSuRe; the gas supply is different from the fireplace,
- Page 18 – Verify proper operation after servicing.; and; Canadian Electrical Code, CSA; wall switch wiring
- Page 19 – lOG PlACeMeNt; Before you begin; After handling; Refer to Figure 18
- Page 20 – Align holes in the bottom of the left base
- Page 21 – Set right center log #5 on center pin to
- Page 22 – iNStAlliNG ON/OFF SWitCh; After installing surround, disconnect the
- Page 23 – DOOR and FiliGRee iNStAllAtiON; Slide cabinet door frame on to front of unit. Make sure; ti; Slide one door onto hinges. Repeat for other door.
- Page 24 – FOR yOuR SAFety ReAD BeFORe liGhtiNG; iNitiAl liGhtiNG
- Page 25 – Continued on next page; APPROVeD leAK teStiNG MethOD; liGhtiNG PilOt; Figure 32 - Pilot Position; Never check for gas leak with open flame!; liGhtiNG PilOt FOR the FiRSt tiMe; OPeRAtiNG iNStRuCtiONS
- Page 26 – control knob on; fan control knob; liGhtiNG BuRNeR; MAiN BuRNeR SWitCh; Depress and turn the knob counterclockwise; PilOt POSitiON; tO tuRN OFF GAS; ADjuStiNG BlOWeR SPeeD; . One click clockwise turns blower to high speed.; Figure 34 - On Position
- Page 28 – GlASS RePlACeMeNt; lifting the door up and off the unit.
- Page 29 – VeNtiNG SySteM; A qualified agency should examine the venting system annually.; CleANiNG GlASS; Visually check pilot and burner flames periodically.; CleANiNG and MAiNteNANCe
- Page 30 – Refer to Pages 19 through 21.; MAiNtAiNiNG yOuR heAteR’S APPeARANCe
- Page 31 – . Turn gas control knob to “OFF” position to shut off gas to heater.
- Page 32 – tROuBleShOOtiNG; OBSeRVeD PROBleM; Pilot will not stay lit.; POSSiBle CAuSe; NOTE: All troubleshooting items are listed in order of operation.
- Page 33 – White; Description
- Page 34 – RePlACeMeNt PARtS
- Page 39 – liMiteD liFetiMe WARRANty POliCy; liFetiMe WARRANty; serial number of your MHSC product.
- Page 40 – Model
Models:
iDV380NVC & iDV380PVC
iDV490NVC & iDV490PVC
iDV Series Direct Vent
Gas Fireplace insert
57D0016 3/10 Rev. 9
installation and
Operating instructions
WARNiNG
iF the iNFORMAtiON iN theSe iNStRuCtiONS iS NOt
FOllOWeD exACtly, A FiRe OR exPlOSiON MAy
ReSult CAuSiNG PROPeRty DAMAGe, PeRSONAl
iNjuRy OR lOSS OF liFe.
–
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other
appliance.
– WhAt tO DO iF yOu SMell GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any
phone in your building.
• immediately call your gas supplier from a neighbor's
phone. Follow the gas supplier's instructions.
• if you cannot reach your gas supplier, call the fire
department.
– i n s t a l l a t i o n a n d s e r v i c e m u s t b e p e r f o r m e d
by a qualified installer, service agency or the
gas supplier.
WARNiNG: improper installation, adjustment, alteration,
services or maintenance can cause injury or property
damage. Refer to this manual. For assistance or additional
information consult a qualified installer, service agency
or the gas supplier.
this appliance may be installed in an aftermarket*,
permanently located, manufactured home (uSA only) or
mobile home, where not prohibited by local codes.
this appliance is only for use with the type of gas
indicated on the rating plate. this appliance is not
convertible for use with other gases, unless a certified
kit is used.
* Aftermarket: Completion of sale, not for purpose of resale, from the
manufacturer.
Due tO hiGh teMPeRAtuReS, the APPliANCe
ShOulD Be lOCAteD Out OF tRAFFiC AND
AWAy FROM FuRNituRe AND DRAPeRieS.
ChilDReN AND ADultS ShOulD Be AleRteD
t O t h e h A Z A R D S O F h i G h S u R F A C e
teMPeRAtuRe AND ShOulD StAy AWAy tO
AVOiD BuRNS OR ClOthiNG iGNitiON.
yOuNG ChilDReN ShOulD Be SuPeRViSeD
WheN they ARe iN the SAMe ROOM AS the
APPliANCe.
ClOthiNG OR OtheR FlAMMABle MAteRiAl
ShOulD NOt Be PlACeD ON OR NeAR the
APPliANCe.
KeeP the ROOM AReA CleAR AND FRee FROM
COMBuStiBle MAteRiAlS, GASOliNe, AND
OtheR FlAMMABle VAPORS AND liquiDS.
iNStAlleR: leave this manual with the appliance.
CONSuMeR: Retain this manual for future refer-
ence.
570016
IDV cover
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
57D0016 IDV380/IDV490 Fireplace Insert 3 4. Never install the insert • in a recreational vehicle • where curtains, furniture, clothing, or other flam- mable objects are less than 36" from the front, top, or sides of the insert • in high traffic areas • in windy or drafty areas 5. This insert rea...
4 57D0016 IDV380/IDV490 Fireplace Insert iMPORtANt SAFety iNFORMAtiON and CODe APPROVAl Continued from page 3 15. This appliance, when installed, must be electrically grounded in accordance with local codes or in the absence of local codes, with the National Electrical Code, ANSI/NFPA 70 , or the Ca...
57D0016 IDV380/IDV490 Fireplace Insert 5 FP2621IDV controls PRODuCt FeAtuReS • This appliance has been certified for use with either natural or propane gas. Refer to the appropriate data plates. • This appliance is not for use with solid fuels. • The appliance is approved for bedroom or bedsitting r...
