Monessen CSVF30SPV - Manual

Monessen CSVF30SPV

Monessen CSVF30SPV – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
Page: / 32

Table of Contents:

  • Page 2 – CONTENTS
  • Page 3 – National Fuel Gas; INSTALLER; Please leave these instructions with the owner.; OWNER; Please retain these instructions for future reference.; IMPORTANT; IMPORTANT SAFETY INFORMATION; CARBON MONOXIDE POISONING:; burns, explosion or carbon monoxide poisoning.; ARNING
  • Page 5 – PRODUCT FEATURES; Figure 1 - Cast Iron Stove
  • Page 6 – DIMENSIONS; Figure 2 - Dimensions
  • Page 7 – GETTING STARTED; MAKE SURE YOU HAVE RECEIVED ALL PARTS:; CAUTION
  • Page 8 – PRODUCT SPECIFICATIONS; NATURAL GAS; systems operating at higher pressure.; IGNITION CONTROLS
  • Page 9 – NFPA54 which can be obtained from...; American National Standards Institute, Inc.; or; National Fire Protection Association, Inc.; Batterymarch Park; GENERAL INSTALLATION INFORMATION; adequate combustion and ventilation air.; UNUSUALLY TIGHT CONSTRUCTION IS DEFINED AS CONSTRUCTION WHERE...; ) or less with openings gasketed or sealed
  • Page 10 – Figure 3 - Example of a Large Room with 1/2 Wall Divider
  • Page 11 – CLEARANCES / HEIGHT REQUIREMENTS; Figure 4 - Minimum Clearance to Walls and Ceiling; Figure 4
  • Page 12 – CLEARANCES / HEIGHT REQUIRMENTS; Figure 5 - Placing Stove in Alcove; Height From
  • Page 13 – REMOVING UNIT FROM CRATE; Open plastic bag and slide to bottom of unit.
  • Page 14 – CONNECTING THE GAS; Figure 9 - Gas Connection
  • Page 15 – CHECKING GAS PRESSURE; MILLIVOLT CONTROL; Figure 10 - Pressure Test Point Location; CONNECTING REMOTE RECEIVER; Figure 11 - Installing Remote Receiver; DO NOT USE AN OPEN FLAME.
  • Page 16 – THAT DOES NOT REQUIRE 110 VAC TO OPERATE.; Figure 12 - Wiring Diagram; CONNECTING OPTIONAL WALL SWITCH OR THERMOSTAT
  • Page 18 – OPERATING THERMOSTAT SENSOR
  • Page 19 – LOG PLACEMENT; INSTALLING LOGS ON GRATE; Figure 17 - Installing Logs to Grate; Before you begin; After handling the logs, wash your hands gently with
  • Page 20 – CHECKING PILOT FLAME; It should just touch the top of the ther-; ROCK WOOL INSTALLATION; Figure 18 - Rock Wool Installation; FLAME APPEARANCE
  • Page 21 – CHECKING BURNER FLAME; not; OPERATING INSTRUCTIONS; Avoid any drafts that alter burner flame patterns.; Do not allow fans to blow directly into the stove. Do not place
  • Page 22 – WHAT TO DO IF YOU SMELL GAS:; • Do not attempt to light any appliance.; FOR YOUR SAFETY READ BEFORE LIGHTING
  • Page 23 – TO TURN OFF GAS TO HEATER; Figure 24 - Control Cover Plate for Milli-Volt; Match Lighting Instructions; THERMOSTAT
  • Page 24 – CLEANING AND SERVICING; air intake holes clean will result in sooting and poor combustion.; MATCH LIGHTING INSTRUCTIONS
  • Page 25 – REPLACEMENT PARTS ARE AVAILABLE THROUGH YOUR RETAILER.; Item; REPLACEMENT PARTS LIST
  • Page 26 – BURNER ASSEMBLY
  • Page 27 – Accessories
  • Page 28 – Note: All troubleshooting items are listed in order of operation.; TROUBLESHOOTING
  • Page 30 – NOTES
  • Page 32 – LIMITED LIFETIME WARRANTY; the first five years of ownership and parts only thereafter.
Loading the manual

ON

OF

F

READ AND SAVE THESE INSTRUCTIONS

This is an unvented gas-fired heater.
It uses air (oxygen) from the room
in which it is installed. Provisions for
adequate combustion and ventilation
air must be provided. Refer to page 8.

WARNINGS

If the information in this manual is not followed
exactly, a fire or explosion may result causing
property damage, personal injury or loss of life.

– Do not store or use gasoline or other flammable

vapors and liquids in the vicinity of this or any
other appliance.

– WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use

any phone in your building.

• Immediately call your gas supplier from a

neighbor's phone. Follow the gas supplier's
instructions.

• If you cannot reach your gas supplier, call the

fire department.

– Installation and service must be performed by

a qualified installer, service agency or the gas
supplier.

WARNINGS

This appliance may be installed in
an aftermarket, permanently located,
manufactured (mobile) home, where
not prohibited by local codes.

T h i s a p p l i a n c e i s o n l y f o r u s e
with the type of gas indicated on
the rating plate. This appliance is
not convertible for use with other
gases.

UNVENTED GAS

CAST IRON STOVE

INSTALLATION AND OPERATING

INSTRUCTIONS

MODELS:

CSVF20SNV CSVF30SNV

CSVF20SPV CSVF30SPV

Natural Gas or

Propane/LPG

Milli-Volt Control

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - CONTENTS

2 58D6002 CONTENTS Important Safety Information .......................... 3 Product Features .............................................. 5 Dimensions ....................................................... 6 Getting Started .................................................. 7 Product Specificatio...

Page 3 - National Fuel Gas; INSTALLER; Please leave these instructions with the owner.; OWNER; Please retain these instructions for future reference.; IMPORTANT; IMPORTANT SAFETY INFORMATION; CARBON MONOXIDE POISONING:; burns, explosion or carbon monoxide poisoning.; ARNING

58D56002 3 9. The installation must conform with local codes or, in the absence of local codes, with the National Fuel Gas Code, ANSI Z223.l/NFPA54. 10. This unit complies with ANSI Z21.11.2-2001 Unvented Heaters. 11. Do not install heater in a bathroom or bedroom unless approved for bedroom use. 12...

Page 5 - PRODUCT FEATURES; Figure 1 - Cast Iron Stove

58D56002 5 ON OF F PRODUCT FEATURES Off/Pilot/On Knob Hi/Lo Knob Door Figure 1 - Cast Iron Stove Optional Remote Receiver Optional Thermostat Sensor Piezo Handle On/Off Switch

Other Monessen Models

All Monessen Other