Lochinvar F0600187510 - Manual

Lochinvar F0600187510

Lochinvar F0600187510 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
49 Page 49
50 Page 50
51 Page 51
52 Page 52
53 Page 53
54 Page 54
55 Page 55
56 Page 56
57 Page 57
58 Page 58
59 Page 59
60 Page 60
Page: / 60

Table of Contents:

  • Page 2 – Commercial Pool Heaters; Table of Contents
  • Page 3 – Installation and Ser vice Manual; Special Instructions; Water Chemistry; SAFETY INFORMATION; DANGER; : Carbon Monoxide poisoning may; : Should overheating occur or the; WARNING; : To minimize the possibility of
  • Page 5 – PRODUCT IDENTIFICATION; Figure 1A – Standard Horizontal Piping Loop
  • Page 6 – INSTALLATION; LOCATING POOL HEATER; Clearances from Combustible; Clearances from Combustible Construction; No additional clearance is needed on the right side of the; Figure 2 – Clearances from Combustible Construction; Base for Combustible Floors
  • Page 7 – Figure 3 – Draining Pool Heater; FREEZE PROTECTION; Anytime the temperature measured at the sensor drops below; : Under no circumstances should the; Combustion Air Filter; units. You can find these commercially; COMBUSTION AND VENTILATION AIR; CAUTION; : Some pleated filters are too
  • Page 8 – Continued; Remove the metal panel from the pool heater’s side wall (see; Figure 5 – Moving Air Filter/Bracket Assembly from Rear of; Combustion Air Options; This pool heater has four combustion air options.; Figure 6 – Outside Combustion Air - Single Opening
  • Page 9 – Outside Combustion Air, Using Direct Venting; Direct; Combustion Air from Interior Space; Exhaust Fans
  • Page 10 – VENTING; General Infor mation; Figure 10 – Vent Termination from Peaked Roof - 10' or Less
  • Page 11 – Figure 12 – Vent Termination from Flat Roof 10' or Less from; : Pool heaters which are shut down or; Freeze; Flue and Air Inlet Pipe Sizes; Input
  • Page 12 – Combustion Air Inlet Piping; : Locate and install the combustion; Combined; Length of Air Inlet Pipe; Minimum Recommended Combustion Air Supply to Equipment Room; Combustion Air Source
  • Page 13 – Figure 14 – Sidewall Combustion Air Inlet; Vertical Rooftop Air Inlet; Figure 16 – Roof Top Combustion Air Inlet; Clearances; Combined Air Inlet Points; area each) have a total
  • Page 14 – Vent System Options; This pool heater has six venting options.; The tee or collar; Conventional Ne gative Dr aft; Venting, General Information; Figure 17 – Conventional Negative Draft Vertical Venting with; Negative Draft
  • Page 15 – Do Not; Flue Outlet Piping; Common Venting Systems
  • Page 16 – Vertical Vent Termination Clearances and; Ver tical DirectAireTM Venting; Figure 18 – Vertical DirectAire Installation with Sidewall
  • Page 17 – Figure 20 – Vertical DirectAire Installation with Rooftop; Vent Kits; : Only use a sidewall air inlet cap; Venting of Flue Products; Vertical; DirectAireTM Kits; Figure 21 – Sidewall Venting Installation with an Induced
  • Page 18 – Sidewall Fan; Sidewall Venting Without an External Fan; Venting Guidelines
  • Page 19 – Figure 22 – Sidewall Venting; : Do not combine the flue from this; Masonry Chimney Installation; : Do not vent this pool heater into a; Sidewall Vent Termination Clearances and
  • Page 20 – Sidewall Vent Kits; Sidewall; Figure 23A – Horizontal DirectAire Installation (Illustration; Combustion and Ventilation Air; Only use the sidewall air inlet cap; Venting of Flue Products; Sidewall Vent Termination Clearances and Location; Horizontal DirectAireTM Venting; installations. The damper will help to
  • Page 21 – Horizontal DirectAireTM Kits
  • Page 23 – : Pool heaters that are shut down or; Modifications to the DV box adapter will be necessary to; Figure 25 – Moving Air Filter Assembly and DV Box Adapter; Check local codes for possible restrictions.; : Use only vent or air intake materials; Seal all joints and seams of the air inlet pipe using either
  • Page 24 – Secure all joints with a minimum of three sheet metal screws; : Properly seal all joints and seams in
  • Page 25 – Vertical Combustion Air Inlet Clearances; Multiple Sidewall Direct Vent Installations; Outdoor Installation Venting; : Only install outdoor models; Combustion air supply must be free of contaminants (see; Outdoor Vent/Air Inlet Location
  • Page 26 – TABLE H; The Outdoor Vent Cap Kit; Adjusting Differential Air Pressure; Figure 27 – Outdoor Vent Cap Installed on Rear of Pool Heater; CONNECTING TO GAS SUPPLY; Inlet Pressure; Maximum; Gas Manifold Pressure Adjustment; Gas Pressure Test
  • Page 27 – Gas Piping; Figure 28 – Gas Line Connection; : Do not have any open flame in; Gas Train and Controls
  • Page 28 – Figure 29 – Typical Pool Heater Gas Train Drawing; Suggested Gas Pipe Size for Single Unit Installations; Combination Gas Valves; Venting of Combination Gas Valves; Operating Temperature
  • Page 29 – Remove the manometer and related fitting from the “inlet” side; : After completing any testing on the; Burner Flames; Figure 30 – Measuring Gas Supply Pressure at Combination; Nominal
  • Page 30 – Figure 31 – Measuring Net Manifold Gas Pressure; Programming
  • Page 31 – Net Manifold Pressure; The piping from the pool heater back to the filter; Auxiliar y Mixed Water Limit Control
  • Page 32 – : Failure to remove power from the
  • Page 33 – Figure 34 - Heater is Within 15 Feet of Pool Piping; Figure 35 - Heater is Beyond 15 Feet of Pool Piping
  • Page 34 – Figure 36 - Heaters are within 15 feet Perpendicular of Pool Piping; Figure 37 - Heaters are Beyond 15 feet of Pool Piping
  • Page 35 – Relief Valve; : Avoid contact with hot discharge; of the pool heater and have an; Water Flow Switch
  • Page 36 – Pump Purge Delay Option; : Power must be removed and the
  • Page 37 – Figure 39 - Control Panel Component Location Drawing; Wire; Ter minal Strip Connection Options; anytime; the
  • Page 38 – : If you do not follow these; OPERATION; Do not try to light any appliance.; Lighting Instructions; Operating Temperature Control,; Figure 41 – Control Panel Cover
  • Page 39 – Figure 42 – ON/OFF Switch; What To Do If You Smell Gas; To Tur n Off Gas To Pool Heater; Star ting the Filter System
  • Page 40 – OPERATING TEMPERATURE CONTROL
  • Page 41 – Programming Mode
  • Page 42 – HOT SURFACE IGNITION SYSTEM; This unit has one ignition module and one hot surface igniter.; The igniter is extremely fragile, be; Hot Surface Ignition Control Module; Ignition Module Lockout Functions
  • Page 43 – Code Sequence; Ignition Control Diagnostic Codes; Access to Inter nal Control Panel; Ignition and Control Timings; : Control panel is heavy and awkward
  • Page 44 – Condition Lights; Status LED Diagnostic Codes; Water Chemistr y
  • Page 45 – Refer to; AMP Draw Data; Pipe Size Requirements; Pipe Sizing Chart
  • Page 46 – Circulating Pump; Lubricate the pump to the manufacturer’s recommendations.; GPM; Minimum Pump Perfor mance; Heat Exchanger; High Water Temperature Limit Control
  • Page 47 – : Label all wires prior to; Appliance Area; : The areas around the burner view; A normal flame is blue with slight yellow tips, has; Flue Gas Passageways Cleaning Procedures
  • Page 48 – Bur ner Removal and Cleaning; Burner Removal and Cleaning; Electrical
  • Page 49 – Combustion Air Fans; Figure 53 – Loosening Fan Transition Box Screws
  • Page 50 – Low Air; Adjustment Procedure; Figure 55 – Combustion Air Adjustment with a Manometer to; Ignition System Checkout
  • Page 51 – SEQUENCE OF OPERATION; OVERVIEW
  • Page 52 – GLOSSARY; The On/Off switch does not provide for disconnection of
  • Page 53 – HEAT TRANSFER PROCESS
  • Page 54 – WIRING BOX CONNECTIONS; OP; WIRING BOX; CONNECTION DIAGRAM B
  • Page 55 – MAIN UNIT CONNECTIONS; MAIN UNIT; CP
  • Page 56 – LADDER DIAGRAM
  • Page 57 – CONTROL BOX CONNECTIONS
  • Page 58 – Unit Star t Up Checklist; Measure the supply gas pressure.; Installation and Service Manual
  • Page 59 – Adjust Menu Settings for Operating Modes
Loading the manual

INSTALLATION AND SERVICE MANUAL

GAS HEATERS FOR COMMERCIAL

POOL APPLICATIONS

500,000 - 2,070,000 Btu/hr MODELS

Starting Serial #F0600187510

CPE-I-S-10

WARNING

: If the

information in this manual
is not followed exactly, a
fire or explosion may result
causing property damage,
personal injury or loss of
life.

– This appliance MUST
NOT be installed in any
location where gasoline or
flammable vapors are likely
to be present, unless the
installation is such to
eliminate the probable
ignition of gasoline or
flammable vapors.

WHAT TO DO IF YOU SMELL
GAS

• Do not try to light any

appliance.

• Do not touch any electric

switch; do not use any
phone in your building.

• Immediately call your

gas supplier from a
neighbors phone. Follow
the gas supplier ’s
instructions.

• If you cannot reach your

gas supplier, call the fire
department.

– Installation and service
must be performed by a
qualified installer, service
agency or the gas supplier.

WARNING

: Do not use

this pool heater if any part
has been under water. The
possible damage to a
flooded pool heater can be
extensive and present
numerous safety hazards.
Any pool heater that has
been under water must be
replaced.

WARNING

: Improper

installation, adjustment,
alteration, service or
maintenance can cause
property damage, personal
injury, exposure to hazardous
materials or loss of life.
Refer to this manual.
Installation and service
must be performed by a
qualified installer, service
agency or the gas supplier.
This pool heater contains
materials that have been
identified as carcinogenic,
or possibly carcinogenic,
to humans.

Save this manual for future reference.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - Commercial Pool Heaters; Table of Contents

Commercial Pool Heaters Table of Contents General Product Information . . . . . . . . . . . . . . . . . . . . . . . . . .3Special Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3Unpacking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ....

Page 3 - Installation and Ser vice Manual; Special Instructions; Water Chemistry; SAFETY INFORMATION; DANGER; : Carbon Monoxide poisoning may; : Should overheating occur or the; WARNING; : To minimize the possibility of

Installation and Ser vice Manual GENERAL PRODUCT INFORMATION Special Instructions This manual supplies information for the installation, operationand servicing of this pool heater. Read and understand this manualcompletely before installing the pool heater. Installation and service must be performed...

Page 5 - PRODUCT IDENTIFICATION; Figure 1A – Standard Horizontal Piping Loop

5 Installation and Ser vice Manual PRODUCT IDENTIFICATION Figure 1A – Standard Horizontal Piping Loop Figure 1B – Optional Vertical Piping Loop

Other Lochinvar Models

All Lochinvar Other