Liebert Integrated Secured Protection - Manual

Page 2 - Model Number Breakdown; RD

2 SAFETY INSTRUCTIONS ................................................................................................................................... 3 GLOSSARY OF SYMBOLS................................................................................................................................

Page 4 - INTRODUCTION; ENCLOSURE

4 INTRODUCTION Your Liebert Little Glass House™ (LGH) willprovide a secure controlled environment in asingle factory assembled enclosure. Theintegrated/matched models are designed tocontrol the environment and provide smoothreliable power so that your sensitive computerand network equipment will pro...

Page 5 - INSTALLATION

5 UPS SUPPORT The integrated/matched models include anuninterruptible power supply (UPS) module toprovide surge suppression, regulated voltageand frequency, and battery backed operatingtime. This will allow you to perform a controlledcomputer shutdown in the event of autility/mains power failure. Th...

Page 6 - ALCOVE INSTALLATION; INSTALLATION CONNECTIONS

6 ALCOVE INSTALLATION ECM ECM/UAS FAC Rear 12" 12" 12" Top 12" 12" 12" Sides 0" 0" 0" Bottom Non-Restricted The unit can be rolled forward on casters foreasy access to Liebert and customer wiring atthe rear of the unit. To open the front door,clearance required de...

Page 8 - OPERATION; SITENET® INTEGRATOR®

8 OPERATION ENVIRONMENTAL CONTROL MODULE(ECM) & UNINTERRUPTIBLE AIR SUPPLY™(UAS) For integrated/matched models, theEnvironmental Control Module is normally sizedto match the capacity of the UPS module andheat transmitted into the Little Glass House™.The module is located at the bottom of theencl...

Page 9 - SENSOR OPTIONS

9 An optional UPS status communication cable isavailable that allows transmission of informationbetween the UPS and the SiteNet Integrator.This cable will plug into the 25 pin D Typeconnector on the rear of the UPS marked DB-25P. The opposite end of the cable in pluggedinto the 9 pin D Type receptac...

Page 10 - MAINTENANCE; FILTER CLEANING; PLUG WIRING

10 MAINTENANCE CAUTION: To avoid tipping the unit when it isbeing moved, push slowly on the lower part ofthe enclosure. After customer equipment isinstalled, the Little Glass House™ may have ahigh center of gravIty. FILTER CLEANING NOTE: Inspect the air filter periodically todetermine the necessary ...

Page 11 - TABLES; ENVIRONMENTAL COOLING MODULE (ECM) PERFORMANCE DATA

11 TABLES FORCED AIR COOLING (FAC) PERFORMANCE DATA (WITH 30PPI FILTER) AIRFLOW (w/Filter) SOUND LEVEL INPUT POWER (1PH) FLA / WSA / OPD MODEL # # FANS HIGH SPEED LOW SPEED HIGH SPEED LOW SPEED 120V/60Hz 220V/50Hz FAC-190 1 190 CMF 112 CMH 90 CMF 53 CMH 61 dBa 47 dBa 0.5/15/15 0.5/15/15 FAC-360 2 36...

Page 12 - *LGH ECM-80 systems provided with separate; 0 Hz Systems with NO UPS - Service Connection Selection; (based on customer selected Service Connection); 0 Hz Systems with NO UPS or WITH UPS - Full Load Amp Draw; Cooling System

12 Electrical Service / Connection The 60 Hz LGH is provided with a single NEMA plug and cord input power connection (except for ECM-80 systems). 60 Hz Systems with UPS - Service Connection If a UPS is supplied, the system power rating and plug connection are fixed. FIXED SERVICE CONNECTION (AMPS) U...

Page 13 - DRAWINGS

Page 21 - INTERNAL LOAD PER CABINET, WATTS; MINIMUM SPEED SET AT 2000 RPM

21 0 10 20 30 40 200 400 600 800 1000 1200 1400 INTERNAL LOAD PER CABINET, WATTS MINIMUM SPEED SET AT 2000 RPM LGH RD/HD FORCED AIR CABINET TEMP. RISE AT STANDARD AIR CONDITIONS TEM P . RISE PER CABINE T , DE G . F FAC-360(2 FAN) HIGH SPEED FAC-190(1 FAN) HIGH SPEED FAC-360(2 FAN) LOW SPEED FAC-190(...

Page 23 - TROUBLESHOOTING

23 TROUBLESHOOTING PROBLEM CAUSE SOLUTION No Power 60 HZ: Verify F2 fuse not blown by checking on/off switch. If not lit, fuse is blown 50Hz: Verify breaker has not tripped. Filter Clogged Clean, or replace filter Refrigerant loss Verify leak. If refrigerant system needs repaired, replace ECM. Hot G...

Page 24 - Limited Warranty

24 Limited Warranty (for U.S. Sales and Installations) We are pleased that you have purchased the Little Glass House™ product toenhance the environment and the reliability of the available AC power foryour sensitive electronic equipment.Liebert Corporation warrants to the original user all parts tha...

Page 25 - Technical Support; The Company Behind The Products; Integrated Secured Protection; Little Glass House

25 1050 Dearborn Drive Columbus, OH 43229 614-888-0246 Technical Support U.S.A. 1-800-222-5877 Outside the U.S.A. 614-841-6755 U.K. +44 (0) 1793 553355 France +33 (0) 1 43 60 01 77 Germany +49 89 99 19 220 Italy +39 2 98250 1 Netherlands +31 (0) 475 503333 E-mail [email protected] Web site http://...

Liebert Integrated Secured Protection - Manual

Table of Contents:

Summary

Other Liebert Models