Page 5 - Contents; Introduction; iii
Contents Introduction . . . . . . . . . . . . . 1 About this manual . . . . . . . . . . . . 1 Important service information . . . . . . . . 1 Strategy for replacing FRUs . . . . . . . . . 1 Strategy for replacing a hard disk drive . . . . 2 Important notice for replacing a system board . . 2 How to ...
Page 6 - iv
Page 7 - Important; support; Before
Introduction About this manual This manual contains service and reference information for Lenovo 3000 N100 and N200 (MT 0689, 0768, and 0769). Use this manual along with the advanced diagnostic tests to troubleshoot problems. The manual is divided into sections as follows: v The common sections prov...
Page 11 - Safety; Diskette
Diskette compatibility matrix The compatibility of each of the drives with the diskettes for it is as follows: Diskette drive Diskette capacity Compatibility 3.5-inch 1.0 MB Read and write 2.0 MB Read and write 4.0 MB Not compatible Safety notices: multilingual translations In this manual, safety no...
Page 12 - DANGER
Safety notice 2 DANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery, recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropri...
Page 18 - exposed
Important Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease electro...
Page 21 - Do; Laser
Laser compliance statement Some models of Lenovo 3000 computer are equipped from the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. Such devices are also sold separately as options. If one of these drives is installed, it is certified in the U.S. to conform to the ...
Page 26 - Passwords; Supervisor; Related
9. When prompted, insert the appropriate Product Recovery disc and then click OK . The second phase of the recovery process begins. 10. When all of the data has been copied from the last Product Recovery disc in the set, a message is displayed prompting you to restart the computer. Remove the disc a...
Page 29 - Hibernation
v If the battery indicator blinks orange, indicating that the battery power is low. (Alternatively, if Hibernate when battery becomes low has been selected in the “Power Management Properties” window, the computer goes into hibernation mode.) To cause the computer to return from sleep (standby) mode...
Page 30 - Creating; Diagnostic; Checkout
Checkout guide Use the following procedures as a guide in identifying and correcting problems with the Lenovo 3000 computer. Note: The diagnostic tests are intended to test only Lenovo 3000 products. The use of non-Lenovo 3000 products, prototype cards, or modified options can lead to false indicati...
Page 36 - Feature; Product
Product overview This section presents the following product-unique information: v “Specifications” v “Status indicators” on page 33 v “FRU tests” on page 34 v “Fn key combinations” on page 35 Specifications The following table lists the specifications of the Lenovo 3000 N100 and N200: Feature Descr...
Page 37 - Product overview
31 Feature Description Processor • Intel Celeron processor 530 (1.73GHz 533MHz 1MBL2)• Intel Celeron processor 550 (2.0GHz 533MHz 1MBL2)• Intel Core 2 Duo processor T5550 (1.83GHz 667MHz 2MBL2) • Intel Core 2 Duo processor T2330 (1.6GHz 533MHz 1MBL2)• Intel Core 2 Duo processor T2310 (1.46GHz 533MHz...
Page 39 - Indicator
Status indicators The system status indicators show the status of the computer, as follows: 1 2 3 4 5 6 7 8 Indicator Meaning 1 Caps lock Caps Lock mode is enabled. You can enter all alphabetic characters (A-Z) in uppercase without pressing the Shift key. To enable or disable Caps Lock mode, press t...
Page 40 - FRU
Indicator Meaning 6 Bluetooth status R Green: Bluetooth wireless is operational. This indicator is on when Bluetooth wireless is on and not in suspend mode. 7 Battery status Green: The battery is charged between 80% to 100% of the capacity, and being discharged between 0% to 80% of the capacity. Bli...
Page 41 - Key
Fn key combinations The following table shows the function of each combination of Fn with a function key. Key combination Description Fn+F1 Volume down. Fn+F2 Volume up. Fn+F3 Reserved. Fn+F4 Put the computer in sleep (standby) mode. To return to normal operation, press the Fn key only, without pres...
Page 42 - Numeric; index
Symptom-to-FRU index The symptom-to-FRU index in this section lists symptoms and errors and their possible causes. The most likely cause is listed first, in boldface type. Note: Do the FRU replacement or other actions in the sequence shown in the column headed “FRU or action, in sequence.” If replac...
Page 45 - symptoms
No-beep symptoms Symptom or error FRU or action, in sequence No beep, power-on indicator on, LCD blank, and no POST. 1. Make sure that every connector is connected tightly and correctly . 2. DIMM. 3. System board. No beep, power-on indicator on, and LCD blank during POST. 1. Reseat DIMM . 2. System ...
Page 47 - at; Undetermined
Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardware defect, such as cosmic radiation, electrostatic discharge, or software errors. FRU replacement should be considered only when a problem recurs. When analyzing an intermit...
Page 51 - Removing
Removing and replacing a FRU This section presents directions and drawings for use in removing and replacing a FRU. Be sure to observe the following general rules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts. 2...
Page 56 - Step; When
For MT 0769 1 1 2 3 Step Screw (quantity) Color Torque 1 M2.5 × 3 mm, pan-head, nylon-coated (2) Silver 0.392 Nm (4 kgfcm) In step 2 , unplug the jacks by using the removal tool antenna RF connector (P/N: 08K7159) or pick the connectors with your fingers and gently unplug them in direction of the ar...
Page 60 - DIMM
1070 DIMM For access, remove these FRUs in order: v “1010 Battery pack” on page 46 v “1060 DIMM slot cover” on page 53 1 1 2 When installing: Insert the notched end of the DIMM into the socket. Press the DIMM firmly, and pivot it until it snaps into the place. Make sure that it is firmly fixed in th...
Page 64 - Fan
1100 Fan For access, remove this FRU: v “1010 Battery pack” on page 46 v “1090 Thermal module slot cover” on page 57 2 3 1 1 1 For MT 0689 Step Screw (quantity) Color Torque 1 M2.5 × 5 mm, flat-head, nylon-coated (3) Black 0.392 Nm (4 kgfcm) For MT 0768 Step Screw (quantity) Color Torque 1 M2.5 × 6 ...
Page 69 - strip
1130 Cover, strip (E cover) For access, remove this FRU: v “1010 Battery pack” on page 46 2 1 3 3 Removing and replacing a FRU Lenovo 3000 N100 and N200 63
Page 70 - daughter
1140 Bluetooth daughter card (BDC) for MT 0769 For access, remove this FRU: v “1010 Battery pack” on page 46 v “1130 Cover, strip (E cover)” on page 63 1 2 3 Step Screw (quantity) Color Torque 1 M2.5 × 3 mm, pan-head, nylon-coated (1) Silver 0.392 Nm (4 kgfcm) When installing: Make sure that the con...
Page 71 - Keyboard
1150 Keyboard For access, remove these FRUs in order: v “1010 Battery pack” on page 46 v “1130 Cover, strip (E cover)” on page 63 1 1 For MT 0689 and 0768 Step Screw (quantity) Color Torque 1 M2.5 × 3 mm, flat-head, nylon-coated (2) Black 0.392 Nm (4 kgfcm) For MT 0769 Step Screw (quantity) Color To...
Page 110 - Locations
Locations Front view 1 Lenovo Care button 2 Volume control buttons 3 Built-in stereo speaker (right) *1 4 Keyboard 5 Fingerprint reader (for some models) 6 Touch pad 7 Touch pad buttons 8 System and power status indicators Note: For the description of each indicator, see “Status indicators” on page ...
Page 112 - OP; Parts
Parts list v Each FRU is available for all types or models, unless specific types or models are specified. v FRU with specific models listed and described as xxU (where U is an example of a country designator) should be used for all models ending in U. v FRU with specific models listed and described...
Page 113 - Overall
Overall 1 2 3 4 5 6 9 8 a 10 1112 13 14 16 17 18 19 b c 22 20 7 15 23 24 21 Parts list Lenovo 3000 N100 and N200 107
Page 117 - Parts list; RoHS
Lenovo 3000 N100 and N200 111 Parts list No. FRU FRU no. RoHS ID CRU ID 6 System board assembly, 15W integrated 0768-E5x, E6x, EGx, EHx, EJx, ELx, F3x, F4x, F6x, F7x, FBx, FGx, FHx, G2x, G3x, GFx, GGx, GHx, GJx, GKx, GLx, GRx, GSx, GTx, GUx • 41W8032 R N System board assembly, 15W integrated 0769-AA...
Page 118 - System board assembly, 15W discrete
112 MT 0689, 0768, and 0769 Parts list No. FRU FRU no. RoHS ID CRU ID 6 System board assembly, 15W discrete 0769-CZx, A8x, A9x, Adx, B2x, B3x, G2x, G6x, Acx, D2x, CVx, CWx, CXx, D4x, G3x. D5x, D9x, DBx, DCx, DDx, B4x, DHx, B6x, B7x, BEx, BFx, BNx, BPx, BQx, BRx, BSx, BWx, BXx, BZx, E4x, E5x, E9x, Ee...
Page 119 - Panasonic
Lenovo 3000 N100 and N200 113 Parts list No. FRU FRU no. RoHS ID CRU ID 8 DVD/CD-RW combo drive assembly, 12.7 mm, TSST (TS-L462C CO01) 0689-24x, 25x, 26x, 2Ex, 2Hx, 2Jx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 31x, 36x, 37x, 38x, 39x, 3Ax, 3Fx, 3Gx, 3Hx, 3Jx, 3Lx, 3Mx, 41x, 52x, 57x, 5Jx, 5Kx, 67x, 69x,...
Page 120 - HLDS
114 MT 0689, 0768, and 0769 Parts list No. FRU FRU no. RoHS ID CRU ID 8 DVD-RAM/RW drive assembly, 12.7 mm, TSST (TS-L632C) 0689-22x, 27x, 28x, 29x, 2Ax, 2Bx, 2Fx, 2Kx, 2Tx, 33x, 34x, 3Bx, 3Cx, 3Dx, 3Kx, 42x, 43x, 44x, 54x, 55x, 56x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Fx, 5Gx, 5Hx, 5Lx, 5Mx, 5Nx, 5Px, 65x, 6...
Page 121 - USB/Audio connector card
Lenovo 3000 N100 and N200 115 Parts list No. FRU FRU no. RoHS ID CRU ID 10 USB/Audio connector card for MT 0689 and 0768 41W1316 R N USB/Audio connector card for MT 0689 and 0768 (updated) 41R7813 R N USB/Audio connector card 0768-Axx, Bxx, Cxx, Dxx, Exx, Fxx, Gxx 0769-all • • 41W1439 R N 11 Bottom ...
Page 122 - GRx
116 MT 0689, 0768, and 0769 Parts list No. FRU FRU no. RoHS ID CRU ID 12 SATA hard disk drive, 80 GB, 9.5 mm, 5,400 rpm, Toshiba 0689-22x, 27x, 28x, 29x, 2Ex, 2Hx, 2Jx, 2Kx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 34x, 37x, 38x, 3Cx, 3Dx, 3Gx, 3Hx, 42x, 43x, 52x, 54x, 56x, 59x, 5Ax, 5Fx, 5Kx, 5Lx, 5Mx, 5...
Page 123 - Hitachi
Lenovo 3000 N100 and N200 117 Parts list No. FRU FRU no. RoHS ID CRU ID 12 SATA hard disk drive, 80 GB, 9.5 mm, 5,400 rpm, Fujitsu 0689-A4x, A6x, ADx, AEx, AFx, AGx, AHx, AJx, B4x, B5x, B6x, B9x, BBx, BEx, C3x, C5x, CFx, CJx, CKx, CLx, CMx, CNx, CPx, CQx, CRx, CVx, CXx, D4x, D8x, D9x, E2x, E4x, F2x,...
Page 125 - Intel PRO Wireless 3945ABG Mini-PCI Express Adapter
Lenovo 3000 N100 and N200 119 Parts list No. FRU FRU no. RoHS ID CRU ID 13 Intel PRO Wireless 3945ABG Mini-PCI Express Adapter 0689-22x, 24x, 28x, 29x, 2Ax, 2Bx, 2Ex, 2Fx, 2Kx, 2Qx, 2Sx, 2Tx, 33x, 34x, 37x, 38x, 3Ax, 3Bx, 3Cx, 3Dx, 3Fx, 3Hx, 3Lx, 3Mx, 41x, 42x, 43x, 44x, 52x, 54x, 55x, 56x, 5Ax, 5Bx...
Page 126 - xxY
120 MT 0689, 0768, and 0769 Parts list No. FRU FRU no. RoHS ID CRU ID 13 Broadcom 802.11bg WLAN PCI-E Mini Card 0689-A8x, A9x, AAx, ABx, B2x, BAx, C3x, C5x, CCx, CVx, D2x, E2x, E4x, EAx, G8x, GLx, GMx, GNx, GRx 0768-A3x, A4x, A5x, A6x, ACx, ADx, B3x, B4x, B5x, BPx, C2x, CJx, CRx, CTx, CWx, DGx, DHx,...
Page 128 - DIMM slot cover for MT 0769
122 MT 0689, 0768, and 0769 Parts list No. FRU FRU no. RoHS ID CRU ID 15 1-GB DDR2-667 SDRAM SO-DIMM (PC2-5300) card 0689-6Gx, A7x, CGx, CLx, CMx, CNx, CPx, CYx, D5x, DBx, DCx 0768-5Bx, 7Yx, A2x, AJx, BJx, BKx, BLx, BSx, CAx, CBx, CDx, CEx, CHx, CKx, CYx, DFx, E2x, E7x, FDx, FEx, FFx, FJx, G7x, GBx,...
Page 130 - CPU assembly, Intel Core Solo processor T1300
124 MT 0689, 0768, and 0769 Parts list No. FRU FRU no. RoHS ID CRU ID 23 CPU assembly, Intel Celeron M processor 410 (1.46 GHz) 0689-65x, 66x, 67x, 68x, 69x 0768-65x, 66x, 67x, 68x, 82x • • 41W5181 R N CPU assembly, Intel Celeron M processor 420 (1.6 GHz) 0689-25x, 26x, 27x, 2Ex, 2Lx, 2Mx, 2Nx, 2Px,...
Page 135 - WXGA
LCD FRUs 1 2 3 4 7 5 6 14.1-in. WXGA TFT No. FRU FRU no. RoHS ID CRU ID 1 LCD front bezel, 14W without a camera v 0689-2xx, 3xx, 65x, 67x, 68x, 69x, 6Ax, 6Bx, 6Cx, 6Dx, 6Ex, 6Fx, 6Gx, 6Hx, 6Kx, 6Px, 6Qx, 6Rx, 6Sx, 6Xx, 6Yx, 6Zx, 73x, 7Mx, 7Nx, 7Px, 7Qx, 7Rx, 7Sx, 7Tx, 82x, 83x, 86x, K2x, A4x, A5x, A...
Page 140 - TFT
15.4-in. WSXGA+ TFT No. FRU FRU no. RoHS ID CRU ID 1 LCD front bezel for MT 0768, 15W (B cover) without a camera v 0768-21x, 22x, 25x, 26x, 27x, 28x, 2Cx, 6Kx, 6Lx, 6Nx, 6Px, 6Qx, 6Rx, 7Kx, 7Lx, 7Sx, 7Tx, 7Yx, A3x, A4x, A5x, A6x, A7x, A8x, A9x, DFx, GNx 41W5211 R N LCD front bezel for MT 0768, 15W w...
Page 142 - Language
Keyboard Keyboard for MT 0689 and 0768 Language P/N (NMB) P/N (Chicony) RoHS ID CRU ID Arabic 39T7368 39T7432 R N Belgian 39T7365 39T7429 Chinese, Traditional 39T7379 39T7443 Czech 39T7373 39T7437 Danish 39T7362 39T7426 Dutch 39T7359 39T7423 English, U.K. 39T7357 39T7421 English, U.S. 39T7353 39T741...
Page 144 - Windows
Recovery discs Windows XP Professional CDs Windows XP Professional is preinstalled as the operating system in the following models: v 0689-22x, 26x, 27x, 29x, 2Bx, 2Jx, 2Px, 33x, 34x, 36x, 38x, 3Ax, 3Dx, 3Hx, 41x, 43x, 44x, 5Dx, 5Fx, 5Hx, 6Ax, 6Cx, 6Ex, 6Fx, 6Gx, 6Hx, 6Jx, 6Kx, 6Lx, 6Vx, 6Wx, 7Nx, 7...
Page 157 - Power
Power cords Power cords for MT 0689 and 0768 A Lenovo 3000 power cord for a specific country or region is usually available only in that country or region: For 2-pin power cords: Region P/N RoHS ID CRU ID Canada, U.S. (models xxF, xxL, xxS, xxU) 39M5016 R * Japan (models Exx, Jxx) 39M5040 Argentina ...
Page 161 - Tools; Tool
Common parts list Tools Tool P/N Triconnector wrap plug 72X8546 Audio wrap cable 66G5180 USB parallel test cable 05K2580 Screwdriver kit 95F3598 Mini PC tool set 00P7033 1/4" drive spinner handle 1650840 1/4" Sq. to 1/4" hex torx adapter 93F2838 TR7-TR-10 tamper resistant torx bits 00P69...
Page 162 - Notices
Notices Lenovo may not offer the products, services, or features discussed in this document in all countries. Consult your local Lenovo representative for information on the products and services currently available in your area. Any reference to a Lenovo product, program, or service is not intended...
Page 163 - Trademarks
estimated through extrapolation. Actual results may vary. Users of this document should verify the applicable data for their specific environment. Trademarks The following terms are trademarks of Lenovo in the United States, other countries or both: Lenovo Lenovo Care Rescue and Recovery The followi...
