Page 5 - Contents; Introduction; iii
Contents Introduction . . . . . . . . . . . . . 1 About this manual . . . . . . . . . . . . 1 Important service information . . . . . . . . 1 Strategy for replacing FRUs . . . . . . . . . 1 Strategy for replacing a hard disk drive . . . . 2 Important notice for replacing a system board . . 2 How to ...
Page 6 - iv
Page 7 - Important; support; Before
Introduction About this manual This manual contains service and reference information for Lenovo 3000 C200 (MT 8922). Use this manual along with the advanced diagnostic tests to troubleshoot problems. The manual is divided into sections as follows: v The common sections provide general information, ...
Page 11 - Safety; Diskette
Diskette compatibility matrix The compatibility of each of the drives with the diskettes for it is as follows: Diskette drive Diskette capacity Compatibility 3.5-inch 1.0 MB Read and write 2.0 MB Read and write 4.0 MB Not compatible Safety notices: multilingual translations In this manual, safety no...
Page 12 - DANGER
Safety notice 2 DANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery, recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropri...
Page 18 - exposed
Important Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease electro...
Page 21 - Do; Laser
Laser compliance statement Some models of Lenovo 3000 computer are equipped from the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. Such devices are also sold separately as options. If one of these drives is installed, it is certified in the U.S. to conform to the ...
Page 26 - Related
9. When prompted, insert the appropriate Product Recovery CD and then click OK . The second phase of the recovery process begins. 10. When all of the data has been copied from the last Product Recovery CD in the set, a message is displayed prompting you to restart the computer. Remove the CD and the...
Page 27 - Passwords; Supervisor; How; If
Passwords As many as three passwords may be needed for any Lenovo 3000 computer: the power-on password (POP), the hard-disk password (HDP), and the supervisor password (SVP). If any of these passwords has been set, a prompt for it appears on the screen whenever the computer is turned on. The compute...
Page 29 - Screen
5. Select Password . 6. Select Hard-disk x password , where x is the letter of the hard disk drive. A pop-up window opens. 7. Select Master HDP . 8. Type the current master HDP in the Enter Current Password field. then leave the Enter New Password field blank, and press Enter twice. 9. Press F10. 10...
Page 31 - Creating; Diagnostic; Checkout
Checkout guide Use the following procedures as a guide in identifying and correcting problems with the Lenovo 3000 computer. Note: The diagnostic tests are intended to test only Lenovo 3000 products. The use of non-Lenovo 3000 products, prototype cards, or modified options can lead to false indicati...
Page 37 - Lenovo
Lenovo 3000 C200 Product overview . . . . . . . . . . . . 32 Specifications . . . . . . . . . . . . . 32 Status indicators . . . . . . . . . . . . 34 FRU tests . . . . . . . . . . . . . . 35 Fn key combinations . . . . . . . . . . 36 Symptom-to-FRU index . . . . . . . . . . 37 Numeric error codes . ...
Page 38 - Feature; Product
Product overview This section presents the following product-unique information: v “Specifications” v “Status indicators” on page 34 v “FRU tests” on page 35 v “Fn key combinations” on page 36 Specifications The following table lists the specifications of the Lenovo 3000 C200: Feature Description Pr...
Page 40 - Indicator
Status indicators The system status indicators show the status of the computer, as follows: 1 2 3 4 5 6 7 8 Indicator Meaning 1 Caps lock Caps Lock mode is enabled. You can enter all alphabetic characters (A-Z) in uppercase without pressing the Shift key. To enable or disable Caps Lock mode, press t...
Page 42 - Key
Fn key combinations The following table shows the function of each combination of Fn with a function key. Key combination Description Fn+F1 Volume down. Fn+F2 Volume up. Fn+F3 Reserved. Fn+F4 Put the computer in standby mode. To return to normal operation, press the Fn key only, without pressing a f...
Page 43 - Numeric; index
Symptom-to-FRU index The symptom-to-FRU index in this section lists symptoms and errors and their possible causes. The most likely cause is listed first, in boldface type. Note: Do the FRU replacement or other actions in the sequence shown in the column headed “FRU or action, in sequence.” If replac...
Page 47 - at; Undetermined
Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardware defect, such as cosmic radiation, electrostatic discharge, or software errors. FRU replacement should be considered only when a problem recurs. When analyzing an intermit...
Page 48 - FRU
FRU replacement notices This section contains notices related to removing and replacing parts. Read this section carefully before replacing any FRU. Screw notices Loose screws can cause a reliability problem. In the Lenovo 3000 computer, this problem is addressed with special nylon-coated screws tha...
Page 51 - Removing
Removing and replacing a FRU This section presents directions and drawings for use in removing and replacing a FRU. Be sure to observe the following general rules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts. 2...
Page 54 - daughter; Step; When
1040 Bluetooth daughter card (BDC) For access, remove these FRUs in order: v “1010 Battery pack” on page 46 v “1020 Hard disk drive slot cover” on page 47 2 1 3 Step Screw (quantity) Color Torque 1 M2 × 4 mm, flat-head, nylon-coated (1) Black 0.245 Nm (2.5 kgfcm) When installing: Make sure that the ...
Page 58 - DIMM
1080 DIMM For access, remove these FRUs in order: v “1010 Battery pack” on page 46 v “1070 DIMM slot cover” on page 51 1 1 2 When installing: Insert the notched end of the DIMM into the socket. Press the DIMM firmly, and pivot it until it snaps into the place. Make sure that it is firmly fixed in th...
Page 61 - Fan
1110 Fan For access, remove this FRU: v “1010 Battery pack” on page 46 v “1100 Thermal module slot cover” on page 54 2 3 1 1 1 Step Screw (quantity) Color Torque 1 M2.5 × 6 mm, flat-head, nylon-coated (3) Silver 0.392 Nm (4 kgfcm) When installing: Make sure that the fan connector is attached firmly....
Page 65 - strip
1140 Cover, strip (E cover) For access, remove this FRU: v “1010 Battery pack” on page 46 2 1 3 3 Removing and replacing a FRU Lenovo 3000 C200 59
Page 66 - Keyboard
1150 Keyboard For access, remove these FRUs in order: v “1010 Battery pack” on page 46 v “1140 Cover, strip (E cover)” on page 59 1 1 Step Screw (quantity) Color Torque 1 M2.5 × 3 mm, flat-head, nylon-coated (2) Black 0.392 Nm (4 kgfcm) In step 2 , unlatch the keyboard. 2 When installing: Make sure ...
Page 85 - Locations
Locations Front view 1 Lenovo Care button 2 Volume control buttons 3 Keyboard 4 Fingerprint reader (for some models) 5 Touch pad 6 Touch pad buttons 7 System and power status indicators Note: For the description of each indicator, see “Status indicators” on page 34. 8 5-1 Digital Media Reader 9 PC C...
Page 87 - Parts
Parts list Overall 1 2 3 4 5 6 7 10 9 a 11 12 13 15 14 16 18 19 20 21 b c 23 22 8 17 24 Parts list Lenovo 3000 C200 81
Page 88 - OP
v Each FRU is available for all types or models, unless specific types or models are specified. v FRU parts with specific models listed and described as xxU (where U is an example of a country designator) should be used for all models ending in U. v FRU parts with specific models listed and describe...
Page 93 - XGA
LCD FRUs 1 2 3 4 6 5 15.0-in. XGA TFT No. FRU FRU no. RoHS ID CRU ID 1 LCD front bezel 42W2110 R N 2 LCD panel, 15.0-in. XGA LG 13N7138 R N AUO 13N7140 R N 3 Inverter card Sumida 41W1394 R N Mitac 41W1395 R N YEC 41W1396 R N 4 LCD cable assembly 93P4357 R N 5 LCD rear cover 42W2109 R N 6 Hinges 42W2...
Page 94 - Language
Keyboard Language P/N (NMB) P/N (Chicony) RoHS ID CRU ID Arabic 39T7368 39T7432 R N Belgian 39T7365 39T7429 Chinese, Traditional 39T7379 39T7443 Czech 39T7373 39T7437 Danish 39T7362 39T7426 Dutch 39T7359 39T7423 English, U.K. 39T7357 39T7421 English, U.S. 39T7353 39T7417 English, U.S. (International...
Page 95 - Windows
Recovery CDs Windows XP Professional Windows XP Professional is preinstalled as the operating system in the following models: v 8922-24x, 25x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Gx, 2Hx, 2Jx, 2Px, 2Qx, 2Ux, 3Hx, 44x, 46x, 4Ax, 4Dx, 4Ex, 4Fx, 4Gx, 4Hx, 4Kx, 4Mx, 4Nx, 58x, 5Ax, 5Dx, 5Gx, 5Hx Language P/N ...
Page 99 - Tools; Tool
Common parts list Tools Tool P/N Triconnector wrap plug 72X8546 Audio wrap cable 66G5180 USB parallel test cable 05K2580 Screwdriver kit 95F3598 Mini PC tool set 00P7033 1/4" drive spinner handle 1650840 1/4" Sq. to 1/4" hex torx adapter 93F2838 TR7-TR-10 tamper resistant torx bits 00P69...
Page 100 - For
Power cords A Lenovo 3000 power cord for a specific country or region is usually available only in that country or region: For 2-pin power cords: Region P/N RoHS ID CRU ID Canada, U.S. (models xxF, xxL, xxS, xxU) 39M5016 R * Japan (models Exx, Jxx) 39M5040 Argentina (models xxY) 39M5020 Brazil (mode...
Page 101 - Notices
Notices Lenovo may not offer the products, services, or features discussed in this document in all countries. Consult your local Lenovo representative for information on the products and services currently available in your area. Any reference to a Lenovo product, program, or service is not intended...
Page 102 - Trademarks
estimated through extrapolation. Actual results may vary. Users of this document should verify the applicable data for their specific environment. Trademarks The following terms are trademarks of Lenovo in the United States, other countries or both: Lenovo Lenovo Care Rescue and Recovery The followi...
